Beruflich Dokumente
Kultur Dokumente
Description
2017-5-3 1 , 6
Then we can check the monitor set of this point, if SC 170 is not in monitor set, most possibility
SC 170 was missed neighbor cell.
We can check the measurement control information to verify whether SC170 was sent by RNC. If
not, this cell is missing neighbor cell.
If there is no scanner, we also have one method to check whether it is missing neighbor cells:
After call drop UE will do cell reselection and camp in a cell. We can check whether this cell was
in previous Active set and Monitor set. If not, this cell is missing neighbor.
Solution:
Add neighbor cells.
2017-5-3 2 , 6
During very short time, EcIo of current service cell decreased very much and EcIo target cell
increased very much suddenly; UE cant receive ASU (active set update) and call drop. This case
usually happened at the corner of a street.
Phenomenon and analysis
Corner effect- EcIo change trend
From the table, we can see that: EcIo of cell56 decreased 10dB in 1 second and EcIo of cell041
increased 10dB. When UE report measurement report to RNC, if 1a event is triggered RNC will
send ASU update command to UE; but due to the bad EcIo of the service cell, UE cant
demodulate the signaling so that call drop happen.
Here is a typical corner effect case:
Before turning the corner, EcIo of SC104 and SC168 decreased very much (below -17dB); but
2017-5-3 3 , 6
EcIo of SC208 in monitor set is good (-8dB). Then from the signaling message from RNC we find
UE report 1a event of SC208 and RNC send the ASU but cant receive ASU complete message.
Solution:
Usually we can solve this problem by following methods:
1. Tuning the antenna of SC208, to make this cells coverage can overcome the corner so that
avoiding the call drop.
2. Configure specific 1a parameters of cell (SC=104) to make soft handover more easily to
happen. For example: change TrigTime1A to 200ms or 100ms (default 320ms);
MML command: ADD CELLINTRAFREQHO
3. Configure CIO to make target cell more easily to be added into active set. For example:
configure CIOOffset=5dB.
MML command: MOD INTRAFREQNCELL: CellId=104(SC), NCellId=208(SC),
CIOOffset=5;
In very short time, EcIo of target cell is good meanwhile EcIo of current cell experience quick
decrease and quick increase. The figure shown as below is the EcIo change trend of a typical
pinpoint effect.
2017-5-3 4 , 6
2017-5-3 5 , 6
Solution:
1. Tuning the antenna to avoid the pinpoint.
2. Configure specific parameters to remain previous cell (cell 104) always in active set during
the pinpoint time to avoid the call drop.
For example:
MML command: MOD INTRAFREQNCELL: CellId=168, NCellId=104, CIOOffset=10;
3. Of course we also need to make sure target cell (cell 168) can be added into active set in
time. For this we can refer to the solution of corner effect.
TO BE CONTINUED
To RNC owners:
We plan to collect some valuable common cases to guild us to do better optimization. This is just
the beginning, in future we plan to output more cases. So if you think some part of optimization is
very difficult due to lacking materials, you can communicate with Pak EKO. We will collect some
related cases which is useful for us to optimize current Telkomsel network. Of course if you have
some successful optimization case, you can also tell us. We will make cases then share with the
team.
Hope we can use less time to do more efficient optimization..
2017-5-3 6 , 6