le shear stress Lore $4.3 of the Code),
assuming mortar in he of Ml grade.
A= 01+ G6 where f is axial compressive
sires on the wall due to dead load.
Je = stress due to self load of wall + stress doe
tw dew baud Crom sla
_ fh x w+ 6x 10° x2
26% 100
= 7% Nicm?
= 0.28 N/mm?
Thus a
=0)+—
OLE
= 0.14 N/mm?
Actual stess being wily 0.50 N/a’, wall is
safe in shear, In fact since actual shear stress is
about one third of permissible shear for MI
mortar, we could use ME mortar, Thus both cross
walls are safe im tension as well as shear.
6) Masonry for Walle
i) Lome wails
Masonry of long walls should be desi
maxinem comperisive stress dha is, 1.19
SR= *
= M7840.7 + 5.8 + D4)
026
ied fay
imm
=
Stresi reduction factor k, from Table 9 of the
code
= Ob5
Therefore Basic compressive stress for masonry
for unity
Shape modificanon factor
Lig
marc
= 183 Ny me?
Referring to Table # and Table 10, bricks
should be of strength 25 N/mm" and mortar
should be of grade Hi. If bricks of this strength
are mod locally available it would be meeessary to
introduce piers under the beams so as ta increase
the supporting ama thereby reducing ssrese in
masonry.
ii) Masonry for cross walle
Masonry of cross wall should be designed for
TAAL Coenpressive stress that is, Od Navn”
sant
4.75. (07 + 55+ 0.8 - 0.08)
0.26
‘Stress reduction factor from Table 9
= WE
Basic compressive sires for unity Shape modi-
fication factor
O34
* U62
=0.59 Nim’
Referring to Tables 8 and 10 of the Code,
hocks should be of stremgen 7.3 Ny enen” and with:
Shape modification factor equal 1a I.t.
Thus basic stress of masonry required
SS us N/com*
Grade of murat should be M3. However [rom
the considemtian of shear stress, we should use
grade M2 mortar.
Example 12: Design of Panel Walls
In a framed stracture a pane) wall (see Fig.
E-42) of brickwork 23 cm thick is 4.4 m long ard
3m high (between centres of supports). If the
panel is subjected to a horizontal wind pressure of
730 Nj nv, determine the mia of motor for the
brickwork assutning:
8) paoel is supported at top and bottom and is
rec on oiher 2 edges,
rh nase ry
pe
|| oot
sn ——af
Fic. E43 Panee Watts
6) panel is free at the top and supported on
oiler 3 edges, and
¢) panel is supported on all 4 edges.
Saterion
Case (a)
In this case, panel is spanning in the vertical
dirkctien and masimum bending moment ir
PH
Men
x
— TXAM AS MS
- 8
a HANDBOOK ON MASONHY DESIGN ANID CONSTRUCTIONSPART 1