Beruflich Dokumente
Kultur Dokumente
3. OPERATIONS ...................................................................................................................................................10
6. SPECIFICATIONS ............................................................................................................................................ 28
2
1. Safety and EMC instructions
1-2. Preparation
1-3. Installation
3
1-4. Connection Warnings
TN
4
1-5. Operation
1-6. Standards
* Safety
* EMI
*EMS
Warning:
5
2. Installation and Operation
NOTE:
6
2-3. Single UPS Installation
NOTE:
NOTE 1:
NOTE 2:
NOTE 3:
7
NOTE 1:
NOTE 2:
NOTE 3:
Warning:
Warning:
NOTE:
8
2-4. UPS Installation for Parallel System
NOTE:
9
3. Operations
3-1. Button Operation
Button Function
LED Indicators:
10
LCD Panel:
Display Function
Discharge time information
Fault information
Mute operation
Load information
11
Battery information
Warning
Fault
NOTE:
NOTE:
2. Turn on the UPS without utility power supply (in Battery mode)
12
4. Charge the batteries
NOTE 1:
NOTE 2:
13
8. Turn off the UPS without utility power supply in Battery mode
14
Turn on the parallel system in AC mode:
NOTE:
If more detailed information is needed, please contact supplier or service center for parallel
operation instruction.
15
Warning:
16
3-7. LCD Setting
Note: Up Down
17
01: Output voltage
Interface Setting
Parameter 3: Output voltage
208:
220:
230:
240:
50.0Hz:
60.0Hz:
ATO:
CF:
NCF:
ATO
Note: For single unit, it will have bypass output for a couple of seconds after the unit is powered on.
Therefore, to avoid damage on connected devices, it s strongly suggested to add an additional
Output relay board for CVCF application.
Parameter 3:
18
04: Frequency range for bypass
Interface Setting
Parameter 2:
Parameter 3:
DIS:
ENA:
Parameter 3:
Parameter 3:
FBD
Parameter 3: ENA
DIS
19
09: Maximum battery discharge time setting
Interface Setting
Parameter 3:
000~999:
DIS:
10: Reserved
Interface Setting
11: Reserved
Interface Setting
ATO:
CHE:
20
13: Battery voltage calibration
Interface Setting
Parameter 3:
NOTE:
21
16: Output voltage calibration
Interface Setting
Parameter 2: OP.V
Parameter 3:
Up Down
Enter
Parameter 3:
DIS:
ENA:
PAR
22
Operating mode/status
23
24
3-9. Fault Code
Fault code Fault event Icon Fault code Fault event Icon
3-10.Warning Indicator
Warning Icon (flashing) Alarm
25
4. Trouble Shooting
26
5. Storage and Maintenance
5-1. Storage
5-2. Maintenance
27
6. Specifications
MODEL 15K(L) 20K(L)
CAPACITY*
INPUT
OUTPUT
EFFICIENCY
BATTERY
PHYSICAL
ENVIRONMENT
MANAGEMENT
28