Beruflich Dokumente
Kultur Dokumente
ECO4\ECO4+ Solutions
Data Sheet
Small size 82 x 63 x 28 mm
1-Wire interface
PH YSI C AL
PR OPERI TIE S
Dimensions, mm 82 x 63 x 28 Electrical specification Environmental data, reliability, certification
Connector 12pin
Indication 3 LEDs Power supply 12/24 V DC (range:10 - 32 V DC) ECO4 ECO4+
Housing Plastic Absolute maximum ratings 50 V @ 60 s Storage temperature -40 - +65 -40 - +65
Device is resistible to water (on ECO4+) 72 V @ 0.1 s Operating temperature -35 - +60 -35 - +60
drops and humidity of Power consumption ECO4 ECO4+ Operating from battery:
environment Deep sleep mode 6 mA* 7 mA* Charging -20 - +45
Normal mode, battery Discharging -20 - +60
100 mA 100 mA
not charging/full battery Operating altitude Up to 2000 m
Normal mode, battery Certifications:
200 mA
PR OD U C T F AM IL Y charging E-mark
Internal supply (ECO4+) Li-Po 3.7 V 190 mAh CE ready
ECO4/ECO4+ Protections RoHS
ECO3 Short circuit protection Temp. Test ISO16750
PRO4 Reverse polarity protection FCC HW ready
PRO3 Electrostatic discharge protection on USB
TCO4 Electrostatic discharge protection on 1-wire data Telecommunication, Positioning
TCO3 Over-current protection on 1-Wire power
Electrostatic discharge protection on sim card slot GPS\GLONASS module Ublox MAX-7C
Charging protection (on ECO4+)** Internal
* Firmware dependent 56 channel
CONTACTS ** If temp is >45C, charging is disabled, if >60C Sensitivity -161 dBm
battery is disconnected from the system at all Cold start 29 s
+370 5 272 65 70
Aided start 5s
info@ruptela.lt I\O Characteristics Reacquisition 1s
Device can be installed within 45 angle in any axis but top surface facing up.
PR OD U C T F AM IL Y Device should be installed tightly, does not move or shake.
ECO4/ECO4+
ECO3
PRO4
PRO3
TCO4
TCO3
Warning!
info@ruptela.lt
www.Ruptela.lt
Information Technology
ECO4\ECO4+ Solutions
Data Sheet
Device installation
When installing device into vehicle please obey these instructions over wise you
device may not work properly.
Module should not be seen or easily reached.
Module should be firmly fixed to the surface. Please avoid mounting module near
PH YSI C AL the metal surface or cables (see the picture below).
PR OPERI TIE S Wrong module mounting may be the cause of module malfunction.
Dimensions, mm 82 x 63 x 28
Module cannot be fixed to heat emitting or moving parts.
SIM card should be inserted in the module while the connector is plugged off (while
Connector 12pin
module has no power).
Indication 3 LEDs Module must be fitted with double sided stick tape!
Housing Plastic
Device is resistible to water
drops and humidity of
environment
PR OD U C T F AM IL Y
ECO4/ECO4+
ECO3
PRO4
PRO3
TCO4 Antenna installation
TCO3
It is recommended to place GPS/GLONASS antenna behind the dashboard as close
to the window as possible. It must be uncovered, installed heads up (see picture).
+370 5 272 65 70
info@ruptela.lt
www.Ruptela.lt