Beruflich Dokumente
Kultur Dokumente
rtibbitr
OCCASIONAL VISITOR
Options
07-18-2011 02:08 PM
Alan
Solved! Go to Solution.
4 people had this problem.
Tags:
ML350
View All (1)
0 KUDOS
REPLY
Previous Topic
Next Topic
26 REPLIES
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
4 KUDOS
REPLY
rtibbitr
OCCASIONAL VISITOR
Options
07-18-2011 02:39 PM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
0 KUDOS
REPLY
H08
OCCASIONAL VISITOR
Options
11-01-2011 02:55 AM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
Hi Leslie, I also have an HP Proliant ML350 G5. I tried your procedure but there was no change. i.e. Power-
off system, remove battery, remove all the RAM and put 1 back, switch 6 on, put battery and power up PC.
It just makes that noise for hours and no change. Please help!
0 KUDOS
REPLY
SFHR
FREQUENT ADVISOR
Options
11-01-2011 05:38 AM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
Hi
Power off, unplug power cord.
Pull all RAM and reinsert
Revert back all switches to original condition(thecondition which it was before you change them) on your
system board.
Power up and see, if it works.
If it doesn't, please look at system front panel and see LEDs, if there is any amber. Identify health LED, the
top one on the front LED pannel. check status.
Post error condition here and I'll see what else can be done.
Regards//
SF Hussain
0 KUDOS
REPLY
H08
OCCASIONAL VISITOR
Options
11-01-2011 07:47 AM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
hi, powered off, removed all RAM, reinserted, turned off switch 6 (only one on), powered and waited for 30
minutes. At front panel there is that same LED - internal health LED blinking red. I also thought it would be
nice to clean the mother board with contact cleaner - WD -40. and blowed with a blower until board was
dry.
However, there is another circuit board below the main board for the power units. There is one LED
labelled LED-1 that is amber in color. Could it be a problem with the power supply?
0 KUDOS
REPLY
H08
OCCASIONAL VISITOR
Options
11-05-2011 12:08 AM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
Hi, I finally discovered the problem with my server. I was the SAS controller that is faulty. I have ordered for
a new one but i need to know how to reconfigure the new card to detect the initial RAID and other Hard
drive configurations in order to function without erasing the data on the hard drives. How do i go about
this? Please help!
0 KUDOS
REPLY
Matti_Kurkela
HONORED CONTRIBUTOR
Options
11-05-2011 02:31 AM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
If you simply replace the controller without changing the number and ordering of the disks at the same
time, the controller should automatically detect the presence of existing RAID sets at first boot. It might
require you to visit the SmartArray BIOS screen once to confirm the configuration, but no other special
actions are needed.
MK
0 KUDOS
REPLY
SFHR
FREQUENT ADVISOR
Options
11-15-2011 09:21 PM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
Sorry for long absence.
That's good.
The new SAS controller installtion should not be a problem. I hope you already have installed it if not yet,
please install the new card in same slot. Do not change card slot and existing HDD position. The SAS array
controller will automatically detect existing raid and will once ask you for confirmation only. Nothing more
needed to configure.
Thank you
Regards//
SF Hussain
0 KUDOS
REPLY
varsamis
OCCASIONAL VISITOR
Options
06-08-2013 04:24 AM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
I have the same problem I suppose. The internal health led is blincing red I don't get anything on the
screen will powering up. I allready tried removing all RAM, removed the battery, turned switch no.6 on,
powered the system back on, nothing happened on my screen for a couple of minutes. Turned the system
off reinstalled all RAM, turned switch off and powered up again but still the same thing. Internal health ledd
still blincing red.
Any Ideas?
Thanks in advance.
0 KUDOS
REPLY
Herv91
OCCASIONAL VISITOR
Options
08-30-2013 08:22 AM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
good luck
0 KUDOS
REPLY
leofara
OCCASIONAL VISITOR
Options
10-09-2013 07:57 AM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
Hi,
I've a ML350 G5 that won't boot. The internal health LED is red, and the LED near CPU#1 is amber. I tried
all the suggestions I read ( remove the ram modules, the bios batt, moving dip switch 6, etc.) here but
nothing happens.
Leo
image.jpg 132 KB
image2.jpg 162 KB
0 KUDOS
REPLY
pope-2009
OCCASIONAL ADVISOR
Options
10-10-2013 10:01 PM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
I have an ML370 G5 server.It was working fine, but the mistake i made was removing the Harddisk while
still in use.I also couldnt remember which order they were arranged in.
Now,when i boot the server doesnt display on the monitor and the RED LED is on.
Please advise me on what to do, coz i wouldn't want to lose such a server.
Thanks
0 KUDOS
REPLY
Torsten.
ACCLAIMED CONTRIBUTOR
Options
10-10-2013 10:35 PM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
Even without disks it should reach the BIOS and boot selection at least. Check IML and ILO for problems.
Hope this helps!
Regards
Torsten.
__________________________________________________
There are only 10 types of people in the world -
those who understand binary, and those who don't.
__________________________________________________
No support by private messages. Please ask the forum!
If you feel this was helpful please click the KUDOS! thumb below!
0 KUDOS
REPLY
pope-2009
OCCASIONAL ADVISOR
Options
10-10-2013 10:50 PM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
thanks
0 KUDOS
REPLY
Torsten.
ACCLAIMED CONTRIBUTOR
Options
10-10-2013 10:54 PM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
ILO should still work, connect to ILO and check the system status and logs.
Hope this helps!
Regards
Torsten.
__________________________________________________
There are only 10 types of people in the world -
those who understand binary, and those who don't.
__________________________________________________
No support by private messages. Please ask the forum!
If you feel this was helpful please click the KUDOS! thumb below!
0 KUDOS
REPLY
Fossa
OCCASIONAL VISITOR
Options
10-11-2013 11:23 AM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
Ive a ML350 with 2 x Xeon 5060. Ive changed the mainboard(new Mainboard part nr. 439399-001) due
to incompatibility of supporting Xeon L5420. After changing and checking of all connections, I started the
server. HDD were checked all fans are spinning up but no graphical output. All fans remains on top
speed and nothing else happens.
I did the following (suggested earlier)
get system off power,
get battery out of systemboard, pull all the memory and put 1 back,
look on the inside of the lid, on the drawing there is a system maintenance switch, switch number 6 on,put battery
back,power back on and see what happens after a couple of minutes on the screen
But nothing changed. All LEDs are green no error reported by the mainboard. Can anybody help?
0 KUDOS
REPLY
masoksian
OCCASIONAL VISITOR
Options
11-17-2013 10:27 AM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
Server all fan fully speed spin. and starting all healthy led greeen but after 2 or 3 seconds healty led is red.
And mono IERR led RED and CPU 0 led amber and nothing post system.
Trying DIP switch 6 resetting the clear cmos but nothing.
north and east bridge normal heat and ram normal heat but CPU cool and error IERR CR59 led.
0 KUDOS
REPLY
Ogyadam
OCCASIONAL VISITOR
Options
05-06-2014 11:39 AM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
0 KUDOS
REPLY
FaisalMansoori
OCCASIONAL VISITOR
Options
07-16-2014 09:56 PM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
Hi Buddy,
I did everything as you have mentioned but still didnt work. it boots only if i place a ram on the 4D, but
then it gives a ram erorr and then i get a message system halted, could you please help me with this what
should i do.
0 KUDOS
REPLY
FaisalMansoori
OCCASIONAL VISITOR
Options
07-16-2014 09:56 PM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
Actually my server was turned off from last 2 years and now today i have started.
0 KUDOS
REPLY
zerodisbelief
OCCASIONAL VISITOR
Options
09-04-2014 10:49 AM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
Yah I'm having the same problem. I tried the disconnecting the DVD & flipping the sixth switch / CMOS
battery work around but neither of them seemed to work. I have no other red light except for the IERR
CR59 LED. My CPU LED's are fine and all the front panel display lights are also green. I'm thinking that this
could be a PSU issue for me. The PSU is making some sort of clicking sound that is remincent of something
that sounds like electrical unstablility. Feels like there is too much drain on it and its having a tought time
powering everything up. The PSU still has a green light though.
The following is what I have in my ML350 G5, just the basic things that I need to make sure the server
boots.:
However I only have one PSU, so I'm thinking that I don't have enough power to run all the components.
Would any of you know if having two Xeon Quad Core's running at 120V's needs two PSU's or not? If so I'll
purchase a new one and see how things progress.
0 KUDOS
REPLY
egoncalves
OCCASIONAL VISITOR
Options
09-23-2014 02:19 AM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
the problem is the server turn on but the fans works at maximum speed for hours and no post no display.
Buy a motherboard and replaced the old but has the same problem. anyone knows any solution?
0 KUDOS
REPLY
Gowlikar
OCCASIONAL VISITOR
Options
04-25-2015 02:48 AM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
Hi,
Your solution also help me. The server was dead till today (untill I saw the suggestion posted by you) and
after 2 Years it woke-up because of you. Thank you very much.
0 KUDOS
REPLY
deggialcfr
OCCASIONAL VISITOR
Options
01-26-2016 01:04 PM
Re: ML350 G5 won't boot, red internal health LED, undocumented system board LEDs flashing
i have the same problem, did the unplug, remove battery, remove ram, dip switch 6, ram in, battery in,
power on but it still wont do anything. Until last week, the server was working and then just one day i went
into the room where the machine is located and two red leds were flashing. does anybody have another
solution?
Also, it has only two hdds that were in RAID (i dont remember if 0 or 5), if i want to extract the info, can i
just plug one drive into another server/computer and take out what i need? or do i have to put them in a
machine with the same RAID configuration?
thanks.