100%(1)100% fanden dieses Dokument nützlich (1 Abstimmung)
945 Ansichten3 Seiten
The standard operating procedures document outlines the 9 step process for operating an EDM wire cut machine. The steps include: 1) closing the wire cutter to the workpiece, 2) adjusting the platform and pedals until the workpiece is tightly secured, 3) covering the workpiece to prevent debris, 4) covering the machine, 5) setting up the workpiece profile, 6) setting the design, 7) selecting the workpiece material, and 8) pressing various buttons to select settings and start the cutting process.
The standard operating procedures document outlines the 9 step process for operating an EDM wire cut machine. The steps include: 1) closing the wire cutter to the workpiece, 2) adjusting the platform and pedals until the workpiece is tightly secured, 3) covering the workpiece to prevent debris, 4) covering the machine, 5) setting up the workpiece profile, 6) setting the design, 7) selecting the workpiece material, and 8) pressing various buttons to select settings and start the cutting process.
The standard operating procedures document outlines the 9 step process for operating an EDM wire cut machine. The steps include: 1) closing the wire cutter to the workpiece, 2) adjusting the platform and pedals until the workpiece is tightly secured, 3) covering the workpiece to prevent debris, 4) covering the machine, 5) setting up the workpiece profile, 6) setting the design, 7) selecting the workpiece material, and 8) pressing various buttons to select settings and start the cutting process.
No Description Picture . 1 Push arrow button at the controller to move the wire cutter closed at least 2-5mm to the work piece.
2 Next,use the manual controlled the platform
until the ruler shows 40 at pedal and A steering at the machine until closed the workpiece. If the platform very tight, adjust the pedal that shows A and turn the steering slowly.
3 Take the rubber cover and tight the clip at
the machine for cover the workpiece when the work run move from water spread small piece cut.
4 Put the outer cover to covered the machine.
5 Push the button workpiece setup and this setup shows in the screen.Next, press the button M2 and M6 and press button enter and start. Must be wait until the tool automatic setting owned to workpiece.
6 Press the blue button at the board twice to
set the design on the screen.
7 Push the button esper and screen show the
setting to put the workpiece substance. Next, choose steel and press enter and M2.
8 Press the button 25 or 31.After that, push
button M8 two times and M4, M7 and press M1 twice, M3 press twice and M8. 9 Press the arrow on the board for choose adjustment on the screen. After finish, push start and wait the process cut the workpiece begin.