Beruflich Dokumente
Kultur Dokumente
Prerequisites:
Networking Diagram:
Data Configuration:
Below table describes the H.248 VoIP service data configuration
TABLE 22 H.248 VoIP SERVICE DATA CONFIGURATION
Item Data
VoIP service VLAN VLAN ID: 200
Pnority: 7
Bandwidth: 50 Mbps
Item Data
Prerequisites:
Make sure that the network device works normally.
Make sure that the GPON card works normally.
The corresponding VoIP resource data is configured on the SIP server.
Log in to the ZXA10 C220 through HyperTerminal or Telnet.
Networking Diagram:
Bellow figure shows the SIP VoIP service networking diagram.
Configure SIP VoIP Service networking diagram
Configuration Data:
Below Table describes the SIP VoIP service configuration data.
TABLE 21 SIP VoIP SERVICE CONFIGURATION DATA
Item Data
Bandwidth: 10 Mbps
I I I I I
Tweet
Read More
Prerequisites:
Tweet
Read More
Prerequisites:
Context:
Tweet
Read More
Prerequisites:
Context:
Tweet
Read More
Prerequisites:
Context:
To configure the MVLAN parameters, perform the following steps:
Use the igmp mvlan enable command to configure that the MVLAN processes multicast packets with IGMP protocol.
Use the igmp mvlan disable command to configure that the MVLAN transparently transmits multicast packets.
4. Use the igmp mvlan workmode command to configure MVLAN work mode.
Note: In IGMP snooping mode, prejoin and static join functions are invalid.
Note:
When MVLAN group management is enabled, IGMP join packets must check whether the group is configured. The configured group is
management group.
When MVLAN group management is disabled, IGMP join packets do not check whether the group is configured. The learned group is dynamic
group.
When spanVLAN is enabled, MVLAN groupfilter must be enabled.
7. Use the igmp mvlan group bandwidth command to configure multicast bandwidth.
8. Use the igmp mvlan maxgroup command to configure MVLAN maximum group number.
9. Use the igmp mvlan group prejoin command to configure prejoin function.
10. Use the igmp mvlan sourceport command to configure MVLAN source port.
11. Use the igmp mvlan receiveport command to configure MVLAN receiving port.
12. Use the igmp mvlan staticport command to configure MVLAN static receiving port.
13. Use the igmp mvlan hostip command configure MVLAN proxy IP address in IGMP proxy mode.
14. Use the igmp mvlan group command to query MVLAN configuration.
Tweet
Read More
Page 4 of 9
Previous
1
2
3
4
5
6
7
8
9
Next>
Facebook Like
Popular Posts
Archives
Categories
CISCO (57)
Router (40)
BGP
(15)
MPLS
(3)
OSPF
(5)
Switch (25)
Fiber Optic (3)
GPON (192)
Alarm (16)
Commands (18)
Fiberhome (1)
GPON products (39)
Huawei Config (45)
LS Cable (6)
OLT (18)
ONT (14)
PHYHOME FHNet (3)
Troubleshooting command (19)
ZTE GPON (50)
Huawei (10)
Huawei Router (1)
Huawei Switch (10)
Juniper (11)
Juniper basic (10)
Uncategorized (1)
Tag Cloud
Anything in here will be replaced on browsers that support the canvas element
Meta
Log in Entries
RSS Comments
RSS
WordPress.org