Beruflich Dokumente
Kultur Dokumente
(HTTP://WORKITAFTY.CA)
MNU
FallProtectionxam
If you do not achieve a score of 80%, you may take the exam again.
RULT
0 of 20 questions answered correctly
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
Answered Review
A horizontal lifeline must be designed by a professional engineer. What information should be included in the
design?
The type of fall arrester that must be used with the system
The number of workers that can safely be attached to the lifeline at one time
The emergency procedures response workers should follow in the event of a fall incident
A part of a guardrail must be removed in order to complete the task you have been assigned. What measures
should be taken to ensure your safety and the safety of other workers working in the area?
Install a safety net before you begin your task
Only remove the part of the guardrail that is in the way of completing your task
When you are working at height near a wall or oor opening, an open-top container, or a walkway, what type of
control should be used?
Elimination
A hazard is anything that has the potential to cause you injury or illness.
True
False
Which of these steps should you follow when positioning your ladder for safe use?
Set your ladder at the required angle, using the 4-to-1 rule
Place your ladder on a rm and level surface with both feet on the ground
Keep areas at the top and base of your ladder clear of tools, material, equipment, and debris
Extension ladder side rails must extend at least 1 m (3 feet) above the level you are accessing
Set up in a location that is the required distance away from any overhead electrical conductors
Post warning signs or use pylons or barricade tape, if people or vehicles might pass near your ladder
What three rights do you have as a worker under Canadian occupational health and safety legislation?
The right to know the hazards at work and how to control them
The right to refuse work because you would prefer to be reassigned to a dierent task
The right to create and implement occupational health and safety policies at your workplace
A buer zone is the area immediately outside the inner edge of a control zone that extends a further distance,
usually an additional 2 metres (6.5 feet), in from that edge.
True
False
Rescue
Ladder climbing
Conned spaces
Is a Fall Protection Plan necessary for situations involving the use of a boom-supported elevating work platform or
the use of a fork-mounted elevating work platform intended to support a worker?
Yes
No
Which of these are facts about a lanyard used for fall protection?
It is used to secure your safety belt or full body harness to a lifeline or to an anchor
What components should a full-body harness capable of fullling all the functions of an industrial fall arrest
system include?
D-ring
Energy absorber
Shoulder straps
What type of fall protection should be used when your tools or other objects may fall from your work surface onto
other workers below you?
A safety net
Guardrails
If your wire rope lanyard shows evidence of worn or broken wires, crushed, jammed or attened strands, or
corrosion, should your lanyard fail inspection and be removed from service?
Yes
No
They are warning barriers that alert workers about a fall hazard
They are set up around a work area, at least 2 metres from an unprotected edge
They consist of weighted posts, bre rope, and warning ags or signs along their entire length
Any repair to a ladder must be done by the manufacturer to ensure that the strength of the ladder continues to
meet CSA standards.
True
False
Which of these are conditions you should look for when inspecting a shock absorbing lanyard that require that you
remove your lanyard from service?
Damaged bres
Indications of heat damage (hard or shiny spots, burnt, charred or melted bres, etc)
Indications of a possible fall (a missing or popped ag, a change in the core size, or undue stretching)
What are some factors that increase your risk of falling when working at height?
Are there specic criteria you should use when inspecting your lifeline to determine whether your lifeline is t for
use, depending on the type of lifeline you are using?
Yes
No
Which type of full-body harness has additional front D-rings for attachment to a ladder system, and connection to
a rope grab, cable, rope, or rail.
Type A
Type D
Type E
Type L
According to the hierarchy of controls, if a fall hazard cannot be eliminated, which category of controls should be
considered next?
Engineering controls
Administrative controls
(http://twitter.com/worksite
scc)
(http://facebook.com/worksi
tesafety)
(http://linkedin.com/compa
ny/worksite-safety-
compliance-centre)
Copyright 2017 Worksite Safety Compliance Centre Inc. All Rights
Reserved.
Powered by Touchstone (http://touchstonelms.com/).