Beruflich Dokumente
Kultur Dokumente
ACUV-S Series
Air Cooled Condensing Units
Range 7 TR to 136 TR
(25 kW to 480 kW)
Contents
Introduction........................................ 2 Selection Procedure........................ 15
Legend.............................................. 2 Typical Wiring Diagram................... 12 Introduction
Nomenclature.................................... 2 Electrical Data............................ 18-20
General Features.............................. 3 Dimensional Data....................... 20-23
Component Features......................... 3 Loading Points............................ 23-24 SKM ACUV-S series Air cooled condensing
Control Panel..................................... 4 Location & Space Requirements..... 25 unit are designed for the use on systems with
Unit Controller................................... 5 Unit Installation................................ 26 indoor units connected to remote condensing
Optional Features.............................. 5 Typical Refrigerant Piping............... 27 units located outside either on ground or on
Engineering Specification............. 7-10 Recommended Line Sizes......... 28-29
Capacity Ratings........................ 11-14 Guide Specification......................... 30 roof level.
Capacity Control Steps.................... 15
SKM ACUV-S units are manufactured to meet
the requirements of the gulf severe climatic
conditions.
Legend
The ACUV-S Air Cooled Condensing unit
The following abbreviations are used throughout this manual:
are ideal for warehouses, large halls, schools,
BPF..... By-pass Factor MBh.... BTUH x 1000 mosques, or wherever the requirement calls
cfm ..... Cubic feet per minute Ph ....... Phase for a heavy duty unit with a scroll hermetic
EER .... Energy Efficiency Ratio Pa ....... Pascals compressor.
Hz ....... Hertz PD ....... Pressure Drop
inwg .... Inches of water gauge PI ......... Power Input
kW ...... Kilowatts RPM.......Revolutions per Minute ACUV-S series Air cooled condensing unit
kg ......... kilogram TR ....... Tons of Refrigeration = 12 MBh ( Hermetic Scroll ) are available in 50 models
lbs ........ Pounds weight ( British units ) V .......... Volt covering nominal capacity ranges from 7 TR
L/S ...... Liters per second 136 TR (25 kW to 480 kW) in 50Hz and 60Hz.
The SKM ACUV-S series air cooled condensing units are durable,
dependable, strong, reliable, versatile, quiet and energy efficient.
Wherever a heavy duty condensing unit is required, the ACUV-S
series should be an automatic choice.
Condenser Coil
Component Features
All coils are tested against leakage by air pressure of 450 psig
(3100 kPa) under water. All standard coils are 2, 3 or 4 rows/14
Compressor FPI, 3/8 (9.5 mm) O.D. tubes. An integral subcooling circuit is
provided to increase the cooling capacity, without additional
Compressors used in ACUV-S condensing unit series are operating cost.
hermetically sealed, compact scroll with the following features:
3
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
SKM ACUV-S series, all models, are restricted to a 14FPI (1.8
mm) fin spacing condenser coil.
Refrigerant Charge
Gulf dust storms and the general level of available maintenance
in Gulf countries ensures this condenser coil design shall provide ACUV-S Air Cooled Condensing units are shipped with nitrogen
long life and maintenance-free operation with the least holding charge only. Actual charging with refrigerant R-134a
possibility of operational blockage on the condenser. Ample should be done at site.
condenser surface and sensible air flow across the condenser
ensures a low temperature differential between condensing
temperature and the high Gulf ambients making the ACUV-S Piping connections
condensing unit perform efficiently and durably.
Condenser fans are Normal installation would require the cutting off (using roller-type
propeller type, aluminium tube cutters) of the ends prior to connections being resoldered
alloy blades, directly and connected to the field supplied refrigerant pipework.
driven by electric motors.
M o t o r s a r e To t a l l y
E n c l o s e d A i r O ve r Refrigerant Pipe work
(TEAO) six pole with
class F insulation and SKM ACUV-S series Condensing units are provided with
minimum IP55 protection. all internal piping, using ACR grade copper tubing, between
compressor and condenser.
The TEAO and class
F insulation features Loose supplied liquid line refrigerant controls are available as
ensure long life and are Condenser Fan Motor an option for field installation (Please specify CRSP). When
unique for SKM. ordered this option, the unit should be supplied with a correctly
sized thermostatic expansion valve, liquid line solenoid valve,
The motors are factory wired, using wires specially selected for liquid line sight glass/moisture indicator and filter drier having
high ambients operation, to unit control panel where the motor flared or soldered ends isolatable with one shut-off valve.
contactors are located to control the operation of these motors.
Shut-off valve for the other side of the filter drier can be supplied,
The condenser fans are individually statically and dynamically if option CXFV is specified.
balanced at the factory. Complete fan assembly is provided with
suitable acrylic coated fan guard.
Control Panel
The unit mounted control panel enclosure is fabricated out of heavy
Casing/Structure gauge sheet steel in phosphatized powder coated baked finish.
The enclosure conforms to IP54 as per guidelines in IEC 529.
Designed for ease of handling and low cost to install. The
ACUV-S Air cooled condensing Units are factory assembled A hinged access door and key-fastener is provided for easy access
and mounted on a rigid base. The unit casing used in ACUV-S and security. The panel is factory wired in accordance with NEC
condensing units is made of zinc coated galvanized steel 430 & 440, labelled, tagged and features 220V / 240V controls.
sheets conforming to JIS-G3302 and ASTM A653 which is
phosphatized then baked after an electrostatic powder coat of All compressors are with DOL starting.
approximately 60 microns. Individual compressor & condenser fan motor contactors.
Motor protector circuit breaker for condenser fan motors.
This finish and coating pass a 1000 hours in 5 % salt spray testing
at 95F (35C) and 95% relative humidity as per ASTM B117. Voltage monitoring module for protection against under
voltage, over voltage, phase loss, phase reversal and
The entire assembly comes complete with lifting holes on phase unbalance of the incoming voltage.
the base frame for rigging and installation. Acess panels are Control circuit breaker.
provided for easy service and maintainance
Control circuit on/off switch.
Options available include hot dipped galvanized base frame Microprocessor control boards.
and structural members aluminium/stainless steel panels are Control Relays.
available, on request, as option. Power and control terminal blocks.
4
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
System Control Philosophy
Microprocessor Controller Unit is enabled from the on/off switch in the control panel.
Control is based on room temperature sensed by room unit.
Compressors will be staged based on the set point and actual
room temperature. On an increase in room temperature, cooling
stages will be added and on a decrease in room temperature,
cooling stages will be removed from the system.
5
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
Rotalock Valves on compressors (RVC) Ammeter & Phase Selector switch (AMPI)
For additional facilitation of maintenance of unit. To indicate running AMPS on main incomer of the unit.
Condenser Fan with polyglycoat coating (PGF) Voltmeter & Selector Switch (VSS)
For incoming line voltage.
To provide protection against corrosion for condenser fans.
7
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
ENGINEERING SPECIFICATIONS - 50 HZ
Model ACUV 52053-S 52060-S 53064-S 53071-S 53079-S 53084
Model ACUV 52053-S 52060-S 53064-S 53071-S 53079-S 53084-S
BTUH 625000 695000 750000 835000 920000 98000
Cooling Capacity (1) BTUH 625000 695000 750000 835000 920000 980000
Cooling Capacity (1) W 183177 203693 219812 244725 269637 28722
W 183177 203693 219812 244725 269637 287222
BTUH 549900 614050 656350 733900 811650 86200
Cooling Capacity (2) BTUH 549900 614050 656350 733900 811650 862000
Cooling Capacity (2) W 161166 179968 192365 215094 237881 25263
W 161166 179968 192365 215094 237881 252638
Type - Hermetic Scroll Compressor
TypeQuantity - - 4 4 Hermetic Scroll Compressor
6 6 6 6
Compressor 4 4 6
Compressor
Quantity
Oil Charge per Circuit - US Gal 3.0/3.0 3.6/3.6 2.1/2.1/2.1 6 2.5/2.5/2.56 6
3.0/3.0/2.5 3.6/3.0/
Oil Charge (A/B/C/D)
per Circuit US Gal 3.0/3.0 11.5/11.5 3.6/3.6 13.6/13.6 2.1/2.1/2.1 2.5/2.5/2.5
7.9/7.9/7.9 3.0/3.0/2.5
9.3/9.3/9.3 3.6/3.0/3.0
11.5/11.5/9.3 13.6/11.5
Liter
(A/B/C/D) Liter 11.5/11.5 13.6/13.6 7.9/7.9/7.9 9.3/9.3/9.3 11.5/11.5/9.3 13.6/11.5/11.5
Type - Air cooled 3 or 4 rows 14 FPI (1.8 mm) fin spacing Cu tubes Al fins
Type - Air cooled 3 or 4 rows 14 FPI (1.8 mm) fin spacing Cu tubes Al fins
Condenser Coil ft 72.0 72.0 97.5 97.5 97.5 97.5
Condenser Coil Face Area ft 72.0 72.0 97.5 97.5 97.5 97.5
Face Area m 6.7 6.7 9.1 9.1 9.1 9.1
m 6.7 6.7 9.1 9.1 9.1 9.1
Type - Propeller direct drive 960 RPM
Type - Propeller direct drive 960 RPM
Code / Qty. - 829/4 829/4 823/6 823/6 829/6 829/6
Condenser Fan Code / Qty. - 829/4 829/4 823/6 823/6 829/6 829/6
Condenser Fan cfm 42880 40920 54900 54900 59340 5934
Air Flow Rate cfm 42880 40920 54900 54900 59340 59340
Air Flow Rate l/s 20237 19312 25910 25910 28005 2800
l/s 20237 19312 25910 25910 28005 28005
Type - Totally enclosed, air over Class F insulation, 6-pole, IP-55
Condenser Motor Type - Totally enclosed, air over Class F insulation, 6-pole, IP-55
Condenser Motor Size / Quantity kW 1.5/4 1.5/4 1.5/6 1.5/6 1.5/6 1.5/6
Size / Quantity kW 1.5/4 1.5/4 1.5/6 1.5/6 1.5/6 1.5/6
Refrigerant (R - 134a) Operating Charge per lbs 31.9/31.9 35.9/35.9 28.8/28.8/28.8 28.8/28.8/28.8 35.7/35.7/35.7 35.7/35.7
Refrigerant (R - 134a) Operating Charge per lbs 31.9/31.9 35.9/35.9 28.8/28.8/28.8 28.8/28.8/28.8 35.7/35.7/35.7 35.7/35.7/35.7
Circuit (A/B/C/D) (3) kg 14.5/14.5 16.3/16.3 13.1/13.1/13.1 13.1/13.1/13.1 16.2/16.2/16.2 16.2/16.2
Circuit (A/B/C/D) (3) kg 14.5/14.5 16.3/16.3 13.1/13.1/13.1 13.1/13.1/13.1 16.2/16.2/16.2 16.2/16.2/16.2
Number of Refrigerant Circuits - 2 2 3 3 3 3
Number of Refrigerant Circuits - 2 2 3 3 3 3
lbs 3585 3815 6139 6533 6727 6727
Unit Operating Weight lbs 3585 3815 6139 6533 6727 6727
Unit Operating Weight kg 1626 1730 2784 2963 3051 3051
kg 1626 1730 2784 2963 3051 3051
8
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
Model ACUV 61009-S 61011-S 61016-S 62018-S 61018-S 62020-S 62022-S
BTUH 102000 132000 174000 200000 210000 226000 262000
Cooling Capacity (1)
ENGINEERING SPECIFICATIONS
W 29894 -3868760 HZ 50996 58617 61547 66237 76788
BTUH 88500 117250 154950 173400 185550 196550 229150
Cooling
Model Capacity (2) ACUV 61009-S 61011-S 61016-S 62018-S 61018-S 62020-S 62022-S
W 25938 34364 45413 50821 54382 57606 67160
BTUH 102000 132000 174000 200000 210000 226000 262000
Cooling Capacity (1) Type Hermetic Scroll
W- 29894 38687 50996 58617Compressor 61547 66237 76788
Quantity -
BTUH 1
88500 1
117250 1
154950 2
173400 1
185550 2
196550 2
229150
Compressor
Cooling Capacity (2)
Oil Charge per Circuit USWGal 0.86
25938 0.86
34364 1.23
45413 0.86/0.86
50821 1.80
54382 0.86/0.86
57606 0.86/0.86
67160
Type (A/B/C/D) -
Liter 3.3 3.3 4.7 Hermetic Scroll
3.3/3.3Compressor 6.8 3.3/3.3 3.3/3.3
Quantity - 1 1 2 mm) fin spacing Cu tubes1 Al fins
1 2, 3 or 4 rows 14 FPI (1.8 2 2
Compressor Type - Air cooled
Oil Charge per Circuit US Gal 0.86 0.86 1.23 0.86/0.86 1.80 0.86/0.86 0.86/0.86
Condenser Coil (A/B/C/D) ft 19.4 19.4 24.4 24.4 24.4 24.4 29.3
Face Area Liter 3.3 3.3 4.7 3.3/3.3 6.8 3.3/3.3 3.3/3.3
m 1.8 1.8 2.3 2.3 2.3 2.3 2.7
Type - Air cooled 2, 3 or 4 rows 14 FPI (1.8 mm) fin spacing Cu tubes Al fins
Condenser Coil Type ft- 19.4 19.4 24.4 Propeller direct24.4
drive 1150 RPM 24.4 24.4 29.3
Face Area
Code / Qty. m- 628/2
1.8 628/2
1.8 723/2
2.3 723/2
2.3 723/2
2.3 723/2
2.3 823/2
2.7
Condenser Fan
Type cfm- 11200 10820 15660 15660
Propeller direct drive 1150 RPM 15660 15660 21760
Air Flow Rate
Code / Qty. l/s- 628/2
5286 628/2
5106 723/2
7391 723/2
7391 723/2
7391 723/2
7391 823/2
10270
Condenser Fan
cfm 11200 10820 15660 15660 15660 15660 21760
Type
Air Flow Rate - Totally enclosed, air over Class F insulation, 6-pole, IP-55
Condenser Motor l/s 5286 5106 7391 7391 7391 7391 10270
Size / Quantity kW 0.55/2 0.55/2 1.1/2 1.1/2 1.1/2 1.1/2 2.2/2
Type - Totally enclosed, air over Class F insulation, 6-pole, IP-55
Condenser Motor
Refrigerant (R - 134a) Operating lbs 9.7 14.8 18.3 9.3/9.3 18.3 11.6/8.9 11.5/11.5
Size / Charge
Quantityper kW 0.55/2 0.55/2 1.1/2 1.1/2 1.1/2 1.1/2 2.2/2
Circuit (A/B/C/D) (3) kg
lbs 4.4
9.7 6.7
14.8 8.3
18.3 4.2/4.2
9.3/9.3 8.3
18.3 5.3/4.0
11.6/8.9 5.2/5.2
11.5/11.5
Refrigerant (R - 134a) Operating Charge per
Number of Refrigerant
Circuit (A/B/C/D) (3) Circuits kg- 1
4.4 1
6.7 1
8.3 2
4.2/4.2 1
8.3 2
5.3/4.0 2
5.2/5.2
Number of Refrigerant Circuits lbs- 1
816 1
895 1
1142 2
1169 1
1142 2
1213 2
1319
Unit Operating Weight lbs 816 895 1142 1169 1142 1213 1319
Unit Operating Weight kg 370 406 518 530 518 550 598
kg 370 406 518 530 518 550 598
9
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
ENGINEERING SPECIFICATIONS - 60 HZ
Model
Model ACUV ACUV 62063-S 62063-S 62071-S 62071-S 63076-S 63076-S63085-S 63085-S
63094-S 63094-S
63100-S 63100-
BTUH BTUH 740000 740000 825000 825000 895000 895000 990000 990000
1095000 1095000
1165000 116500
CoolingCapacity
Cooling Capacity (1) (1)
W 216882 216882
W 241794 241794 262309 262309 290152 290152
320926 320926
341442 34144
BTUH BTUH 654050 654050 731700 731700 787200 787200 876100 876100
969850 969850
1027950 102795
CoolingCapacity
Cooling Capacity (2) (2)
W W 191691 191691 214449 214449 230715 230715 256770 256770284247 284247
301275 30127
TypeType - - Hermetic
Hermetic Scroll Compressor Scroll Compressor
Quantity
Quantity - - 4 4 4 4 6 6 6 6 6 66 6
Compressor
Compressor
Oil Charge
Oil Charge per Circuit
per Circuit US Gal US Gal 3.0/3.0 3.0/3.0 3.6/3.6 3.6/3.6 2.1/2.1/2.1 2.1/2.1/2.1
2.5/2.5/2.5 2.5/2.5/2.5
3.0/3.0/2.5 3.0/3.0/2.5
3.6/3.0/3.0 3.6/3.0/3
(A/B/C/D)
(A/B/C/D) Liter Liter 11.5/11.5 11.5/11.5 13.6/13.6 13.6/13.6 7.9/7.9/7.9 7.9/7.9/7.9
9.3/9.3/9.3 9.3/9.3/9.3
11.5/11.5/9.3 11.5/11.5/9.3
13.6/11.5/11.5 13.6/11.5/
Type Type - - Air cooled 3 or 4Airrows
cooled
14 FPI3 or
(1.84 mm)
rowsfin14spacing
FPI (1.8
Cu mm)
tubesfin spacing Cu tubes Al fins
Al fins
Condenser
Condenser CoilCoil ft ft 72.0 72.0 72.0 72.0 97.5 97.5 97.5 97.5 97.5 97.5
97.5 97.5
FaceFace
Area Area
m m 6.7 6.7 6.7 6.7 9.1 9.1 9.1 9.1 9.1 9.19.1 9.1
TypeType - - Propeller direct drive Propeller
1150 RPMdirect drive 1150 RPM
CodeCode
/ Qty. / Qty. - - 829/4 829/4 829/4 829/4 823/6 823/6 823/6 823/6829/6 829/6
829/6 829/6
Condenser
Condenser FanFan
cfm cfm 51760 51760 49560 49560 66840 66840 66840 6684072000 72000
72000 72000
Air Flow Rate Rate
Air Flow
l/s l/s 24428 24428 23390 23390 31545 31545 31545 3154533980 33980
33980 33980
TypeType - - Totally enclosed,Totally
air overenclosed,
Class F insulation,
air over 6-pole,
Class FIP-55
insulation, 6-pole, IP-55
Condenser
Condenser Motor
Motor
Size Size
/ Quantity
/ Quantity kW kW 2.2/4 2.2/4 2.2/4 2.2/4 2.2/6 2.2/6 2.2/6 2.2/62.2/6 2.2/6
2.2/6 2.2/6
Refrigerant
Refrigerant - 134a)
(R (R Operating
- 134a) ChargeCharge
Operating per per lbs lbs 31.9/31.9 31.9/31.9 35.9/35.9 35.9/35.928.8/28.8/28.8 28.8/28.8/28.8 28.8/28.8/28.8 28.8/28.8/28.8
35.7/35.7/35.7 35.7/35.7/35.7
35.7/35.7/35.7 35.7/35.7/
Circuit
Circuit(A/B/C/D)
(A/B/C/D)(3) (3) kg kg 14.5/14.5 14.5/14.5 16.3/16.3 16.3/16.313.1/13.1/13.1 13.1/13.1/13.1 13.1/13.1/13.1 13.1/13.1/13.1
16.2/16.2/16.2 16.2/16.2/16.2
16.2/16.2/16.2 16.2/16.2/
Number of Refrigerant Circuits
Number of Refrigerant Circuits - - 2 2 2 2 3 3 3 3 3 33 3
lbs lbs 3625 3625 3850 3850 6139 6139 6536 6536 6787 6787
6787 6787
Unit
UnitOperating
OperatingWeight
Weight
kg kg 1644 1644 1746 1746 2784 2784 2964 29643078 3078
3078 3078
Model
Model ACUV ACUV 63102-S 63102-S 64113-S 64113-S 64126-S 64126-S64132-S 64140-S
64132-S 64140-S
BTUH BTUH 1195000 1195000 1335000 1335000 1475000 14750001540000 1640000
1540000 1640000
Cooling
CoolingCapacity
Capacity (1) (1) W W 350234 350234 391266 391266 432298 432298 451348 480657
451348 480657
BTUH BTUH 1056450 1056450 1179850 1179850 1303000 13030001361050 1446000
1361050 1446000
Cooling
CoolingCapacity
Capacity (2) (2) W 309628 309628 345794 345794 381887 381887 398901 398901423798 423798
W
TypeType - Hermetic Scroll Compressor
Hermetic Scroll Compressor
-
6 8 8 8
Compressor
Quantity
Quantity -
- 6 8 8 8 8 8
Compressor Oil Charge per Circuit US Gal 3.6/3.6/3.0 2.5/2.5/2.5/2.5 3.0/3.0/3.0/2.5 3.6/3.0/3.0/3.0 3.6/3.6/3.6/3.6
Oil Charge per Circuit US Gal 3.6/3.6/3.0 2.5/2.5/2.5/2.5 3.0/3.0/3.0/2.5 3.6/3.0/3.0/3.0 3.6/3.6/3.6/3.6
(A/B/C/D) Liter 13.6/13.6/11.5 9.3/9.3/9.3/9.3 11.5/11.5/11.5/9.3 13.6/11.5/11.5/11.5 13.6/13.6/13.6/13.6
(A/B/C/D) Liter 13.6/13.6/11.5 9.3/9.3/9.3/9.3 11.5/11.5/11.5/9.3 13.6/11.5/11.5/11.5 13.6/13.6/13.6/13.6
Type - Air cooled 3 or 4 rows 14 FPI (1.8 mm) fin spacing Cu tubes Al fins
Type - Air cooled 3 or 4 rows 14 FPI (1.8 mm) fin spacing Cu tubes Al fins
Condenser Coil ft 97.5 130.0 130.0 130.0 130.0
Condenser Coil Face Area ft 97.5 130.0 130.0 130.0 130.0
Face Area m 9.1 12.1 12.1 12.1 12.1
m 9.1 12.1 12.1 12.1 12.1
Type - Propeller direct drive 1150 RPM
Type - Propeller direct drive 1150 RPM
Code / Qty. - 829/6 829/8 829/8 829/8 829/8
Condenser Fan Code / Qty. - 829/6 829/8 829/8 829/8 829/8
Condenser Fan cfm 72000 100880 96000 96000 96000
Air Flow Rate cfm 72000 100880 96000 96000 96000
Air Flow Rate l/s 33980 47610 45307 45307 45307
l/s 33980 47610 45307 45307 45307
Type - Totally enclosed, air over Class F insulation, 6-pole, IP-55
Condenser Motor Type - Totally enclosed, air over Class F insulation, 6-pole, IP-55
Condenser Motor Size / Qty. kW 2.2/6 2.2/8 2.2/8 2.2/8 2.2/8
Size / Qty. kW 35.7/35.7/35.7 2.2/6 31.3/31.3/31.3 2.2/838.8/38.8/38.8/38.8 2.2/8 38.8/38.8/38.8/38.8
2.2/8
38.8/38.8/38.8/38.8
2.2/8
Refrigerant (R - 134a) Operating Charge per lbs
Refrigerant
Circuit (A/B/C/D)(R - 134a)
(3) Operating Charge per kg lbs 16.2/16.2/16.2 35.7/35.7/35.7 31.3/31.3/31.3 38.8/38.8/38.8/38.8 38.8/38.8/38.8/38.8 38.8/38.8/38.8/38.8
14.2/14.2/4.2/14.2 17.6/17.6/17.6/17.6 17.6/17.6/17.6/17.6 17.6/17.6/17.6/17.6
Circuit (A/B/C/D) (3) kg 16.2/16.2/16.2 4 14.2/14.2/4.2/14.2 4 17.6/17.6/17.6/17.6 17.6/17.6/17.6/17.6 17.6/17.6/17.6/17.6
Number of Refrigerant Circuits - 3 4 4
Number of Refrigerant Circuits - 6787 3 8370 4 8630 4 8630 4 8630 4
lbs
Unit Operating Weight 6787 8370 8630 8630 8630
Unit Operating Weight kg lbs 3078 3796 3914 3914 3914
kg 3078 3796 3914 3914 3914
Table 2 ends
1). Cooling capacity at 95F (35C) ambient temperature according to AHRI-365.
2). Cooling capacity at Gulf conditions : 115F (46.1C) condenser entering air temperature & 45F (7.2C) SST.
3). Operating charge is approximate for condensing unit only and does not include refrigerant lines and evaporator coil.
4). Condensing units are shipped with nitrogen holding charge only.
10
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
CAPACITY RATINGS - 50 H Z
Condenser Entering Air Temperature
Model SST 95F (35C) 105F (40.6C) 115F (46.1C) 125F (51.7C)
ACUV Total Capacity PI* Total Capacity PI* Total Capacity PI* Total Capacity PI*
F C MBh kW kW MBh kW kW MBh kW kW MBh kW kW
35 1.7 72.4 21.2 5.5 67.4 19.8 6.3 62.0 18.2 7.0 56.5 16.6 7.8
40 4.4 79.0 23.2 5.6 73.7 21.6 6.3 67.9 19.9 7.1 62.1 18.2 7.9
51008-S
45 7.2 85.9 25.2 5.7 80.2 23.5 6.4 74.0 21.7 7.2 68.0 19.9 7.9
50 10 93.1 27.3 5.8 86.9 25.5 6.5 80.4 23.6 7.2 74.1 21.7 7.8
35 1.7 93.1 27.3 7.4 86.7 25.4 8.3 79.5 23.3 9.3 72.3 21.2 10.3
40 4.4 102.1 29.9 7.5 95.4 28.0 8.5 87.9 25.8 9.5 80.6 23.6 10.4
51010-S
45 7.2 111.6 32.7 7.7 104.5 30.6 8.6 96.8 28.4 9.6 89.4 26.2 10.6
50 10 121.6 35.6 7.8 114.1 33.4 8.8 106.3 31.1 9.8 98.7 28.9 10.8
35 1.7 119.6 35.1 9.6 112.4 32.9 10.8 105.0 30.8 12.2 97.5 28.6 13.6
40 4.4 132.6 38.9 9.8 124.7 36.5 11.0 116.6 34.2 12.4 108.6 31.8 13.8
51013-S
45 7.2 146.5 42.9 10.1 137.9 40.4 11.4 129.1 37.8 12.7 120.4 35.3 14.1
50 10 161.4 47.3 10.4 152.0 44.6 11.7 142.5 41.8 13.1 133.1 39.0 14.4
35 1.7 142.8 41.9 11.3 132.7 38.9 12.8 121.8 35.7 14.4 111.0 32.5 15.9
40 4.4 155.8 45.7 11.5 144.9 42.5 13.0 133.3 39.1 14.5 122.1 35.8 16.0
52015-S
45 7.2 169.2 49.6 11.7 157.5 46.2 13.2 145.3 42.6 14.6 133.6 39.1 16.1
50 10 183.2 53.7 11.9 170.7 50.0 13.3 157.8 46.3 14.7 145.6 42.7 16.0
35 1.7 144.6 42.4 12.6 135.8 39.8 14.2 126.9 37.2 15.9 118.0 34.6 17.6
40 4.4 160.1 46.9 12.9 150.5 44.1 14.5 140.7 41.2 16.3 131.1 38.4 18.0
51016-S
45 7.2 176.7 51.8 13.3 166.1 48.7 14.9 155.4 45.6 16.7 144.9 42.5 18.3
50 10 194.2 56.9 13.7 182.9 53.6 15.4 171.5 50.3 17.1 160.3 47.0 18.7
35 1.7 160.3 47.0 13.7 148.4 43.5 15.4 135.7 39.8 17.1 123.7 36.2 18.8
40 4.4 175.2 51.3 14.0 162.6 47.6 15.7 149.5 43.8 17.4 137.2 40.2 19.1
52017-S
45 7.2 190.6 55.9 14.3 177.3 52.0 16.0 163.8 48.0 17.7 151.3 44.3 19.3
50 10 206.8 60.6 14.5 192.8 56.5 16.2 178.9 52.4 17.9 166.1 48.7 19.4
35 1.7 183.4 53.8 15.1 170.2 49.9 17.0 155.8 45.7 19.0 141.7 41.5 21.0
40 4.4 201.1 58.9 15.5 187.3 54.9 17.4 172.4 50.5 19.4 158.1 46.3 21.3
52019-S
45 7.2 219.6 64.4 15.8 205.0 60.1 17.8 189.8 55.6 19.7 175.5 51.4 21.6
50 10 239.0 70.0 16.2 223.8 65.6 18.1 208.3 61.1 20.2 193.7 56.8 22.0
35 1.7 206.5 60.5 17.9 192.5 56.4 20.1 177.9 52.1 22.6 163.7 48.0 24.8
40 4.4 227.4 66.7 18.4 212.5 62.3 20.7 197.1 57.8 23.1 182.3 53.4 25.3
52022-S
45 7.2 249.6 73.1 19.0 233.6 68.5 21.3 217.5 63.7 23.6 202.1 59.2 25.8
50 10 273.0 80.0 19.6 256.1 75.1 21.9 239.1 70.1 24.2 223.0 65.4 26.3
35 1.7 236.7 69.4 19.6 222.2 65.1 22.0 207.4 60.8 24.8 192.5 56.4 27.6
40 4.4 262.1 76.8 20.1 246.3 72.2 22.6 230.3 67.5 25.4 214.3 62.8 28.1
52025-S
45 7.2 289.4 84.8 20.7 272.2 79.8 23.3 254.7 74.7 26.1 237.5 69.6 28.7
50 10 318.6 93.4 21.4 299.8 87.9 24.0 280.9 82.3 26.8 262.3 76.9 29.3
35 1.7 261.3 76.6 22.6 245.3 71.9 25.5 229.0 67.1 28.6 212.7 62.4 31.7
40 4.4 289.3 84.8 23.2 271.7 79.6 26.2 254.0 74.4 29.3 236.4 69.3 32.3
52028-S
45 7.2 319.1 93.5 23.9 300.0 87.9 26.9 280.6 82.2 30.1 261.6 76.7 33.0
50 10 350.9 102.8 24.8 330.2 96.8 27.8 309.5 90.7 30.9 289.1 84.7 33.6
35 1.7 285.3 83.6 25.8 267.7 78.5 29.1 250.0 73.3 32.6 232.4 68.1 35.9
40 4.4 315.7 92.5 26.5 296.4 86.9 29.9 277.0 81.2 33.4 257.9 75.6 36.6
52030-S
45 7.2 348.0 102.0 27.3 326.8 95.8 30.8 305.6 89.6 34.2 284.9 83.5 37.3
50 10 382.1 112.0 28.3 359.6 105.4 31.7 337.0 98.8 35.1 314.9 92.3 38.0
35 1.7 361.8 106.1 31.0 334.9 98.1 34.8 306.1 89.7 38.8 278.6 81.6 42.7
40 4.4 396.5 116.2 31.9 368.2 107.9 35.7 338.7 99.3 39.6 311.0 91.2 43.3
52036-S
45 7.2 432.5 126.8 32.6 403.1 118.1 36.4 373.1 109.3 40.4 345.3 101.2 44.0
50 10 470.4 137.9 33.3 439.9 128.9 37.3 409.3 120.0 41.2 381.2 111.7 44.7
35 1.7 413.6 121.2 35.8 385.5 113.0 40.2 356.3 104.4 45.0 327.9 96.1 49.6
40 4.4 455.5 133.5 36.8 425.5 124.7 41.3 394.8 115.7 46.0 365.2 107.0 50.5
52043-S
45 7.2 499.8 146.5 37.8 467.9 137.1 42.4 435.6 127.7 47.1 404.7 118.6 51.4
50 10 546.8 160.3 39.0 512.9 150.3 43.7 479.0 140.4 48.3 446.7 130.9 52.5
Table 3
Notes :
* Power input mentioned in this page should not be used for cable or fuse selection. MCA and MFA values given in the electrical data
pages (18 - 20) should be referred for the same.
Computer Print outs for matched ratings with SKM Air Handling Units are available.
11
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
CAPACITY RATINGS - 50 H Z
Condenser Entering Air Temperature
Model SST 95F (35C) 105F (40.6C) 115F (46.1C) 125F (51.7C)
ACUV Total Capacity PI* Total Capacity PI* Total Capacity PI* Total Capacity PI*
F C MBh kW kW MBh kW kW MBh kW kW MBh kW kW
35 1.7 461.1 135.1 41.2 432.0 126.6 46.4 402.5 118.0 52.0 373.4 109.4 57.1
40 4.4 509.5 149.3 42.4 478.0 140.1 47.7 446.2 130.8 53.3 414.9 121.6 58.2
52048-S
45 7.2 561.3 164.5 44.0 527.0 154.5 49.3 492.7 144.4 54.7 459.0 134.5 59.5
50 10 616.5 180.7 45.6 579.3 169.8 51.0 542.3 158.9 56.3 506.2 148.4 60.9
35 1.7 512.8 150.3 46.9 480.6 140.9 52.9 448.1 131.3 59.2 416.1 122.0 65.0
40 4.4 566.7 166.1 48.3 531.7 155.8 54.4 496.5 145.5 60.7 462.0 135.4 66.2
52053-S
45 7.2 624.2 183.0 50.0 586.0 171.7 56.1 547.7 160.5 62.3 510.5 149.6 67.6
50 10 685.2 200.8 51.9 644.1 188.8 58.0 603.3 176.8 63.9 563.4 165.1 69.0
35 1.7 570.7 167.3 51.6 535.5 157.0 58.2 499.9 146.5 65.2 464.8 136.2 71.8
40 4.4 631.3 185.0 53.0 592.8 173.8 59.8 554.0 162.4 66.8 515.8 151.2 73.2
52060-S
45 7.2 695.9 204.0 54.7 653.6 191.6 61.5 611.2 179.2 68.5 569.9 167.0 74.6
50 10 764.2 224.0 56.6 719.1 210.8 63.5 674.1 197.6 70.2 629.8 184.6 76.0
35 1.7 621.1 182.1 53.5 579.1 169.7 60.2 535.2 156.9 67.4 492.5 144.3 74.3
40 4.4 684.1 200.5 55.0 639.2 187.4 61.8 593.1 173.8 68.9 548.6 160.8 75.6
53064-S
45 7.2 750.7 220.0 56.6 702.9 206.0 63.5 654.4 191.8 70.6 608.0 178.2 77.1
50 10 821.4 240.8 58.3 770.6 225.9 65.3 719.6 210.9 72.3 671.1 196.7 78.6
35 1.7 686.1 201.1 62.7 642.4 188.3 70.6 598.3 175.4 79.0 554.9 162.6 86.5
40 4.4 757.7 222.1 64.7 710.4 208.2 72.7 663.0 194.3 80.9 616.4 180.7 88.2
53071-S
45 7.2 834.2 244.5 67.1 782.9 229.5 75.2 731.7 214.4 83.2 681.6 199.8 90.2
50 10 915.6 268.3 69.8 860.0 252.1 77.8 804.8 235.9 85.6 751.4 220.2 92.3
35 1.7 754.0 221.0 65.7 707.3 207.3 74.0 659.9 193.4 83.1 612.9 179.6 91.8
40 4.4 834.2 244.5 67.5 783.4 229.6 76.0 732.0 214.5 85.1 681.2 199.7 93.6
53079-S
45 7.2 920.1 269.7 69.7 864.5 253.4 78.4 808.6 237.0 87.4 753.7 220.9 95.6
50 10 1011.3 296.4 72.1 951.3 278.8 80.9 891.3 261.2 89.7 832.4 244.0 97.6
35 1.7 801.8 235.0 72.0 752.1 220.4 81.2 701.8 205.7 91.1 652.0 191.1 100.3
40 4.4 886.8 259.9 74.1 832.5 244.0 83.5 777.8 228.0 93.3 724.0 212.2 102.2
53084-S
45 7.2 977.5 286.5 76.5 918.0 269.1 86.1 858.4 251.6 95.7 800.2 234.5 104.3
50 10 1073.5 314.6 79.3 1009.8 296.0 88.8 946.2 277.3 98.2 883.8 259.1 106.4
35 1.7 825.4 241.9 75.3 774.1 226.9 84.9 722.4 211.7 95.1 671.3 196.8 104.6
40 4.4 912.7 267.5 77.5 856.7 251.1 87.3 800.4 234.6 97.5 745.0 218.4 106.6
53086-S
45 7.2 1005.7 294.8 80.1 944.3 276.8 90.0 882.9 258.8 100.0 823.0 241.2 108.7
50 10 1104.1 323.6 82.9 1038.5 304.4 92.9 973.2 285.2 102.5 909.1 266.5 110.8
35 1.7 922.9 270.5 82.2 864.6 253.4 92.6 805.6 236.1 103.8 747.4 219.1 114.2
40 4.4 1019.8 298.9 84.7 956.7 280.4 95.3 893.2 261.8 106.4 830.6 243.4 116.4
54095-S
45 7.2 1123.6 329.3 87.8 1055.0 309.2 98.5 986.3 289.1 109.3 918.9 269.3 119.0
50 10 1234.1 361.7 91.1 1159.7 339.9 101.8 1085.6 318.2 112.4 1013.5 297.1 121.7
35 1.7 1013.4 297.0 88.6 950.6 278.6 99.9 886.9 260.0 112.2 823.8 241.5 123.8
40 4.4 1121.2 328.6 91.1 1052.8 308.6 102.6 983.7 288.3 114.9 915.5 268.3 126.2
54106-S
45 7.2 1236.4 362.4 94.0 1161.7 340.5 105.8 1086.6 318.5 117.9 1012.7 296.8 128.9
50 10 1358.8 398.3 97.4 1278.3 374.7 109.1 1197.6 351.0 121.0 1118.5 327.8 131.6
35 1.7 1061.2 311.0 95.0 995.4 291.7 107.1 928.8 272.2 120.1 862.9 252.9 132.3
40 4.4 1173.8 344.0 97.7 1101.9 323.0 110.1 1029.5 301.8 123.0 958.3 280.9 134.9
54111-S
45 7.2 1293.8 379.2 100.9 1215.2 356.2 113.5 1136.4 333.1 126.2 1059.2 310.5 137.6
50 10 1421.1 416.5 104.5 1336.7 391.8 117.1 1252.5 367.1 129.5 1170.0 342.9 140.3
35 1.7 1131.7 331.7 104.8 1061.3 311.1 118.3 990.4 290.3 132.3 920.5 269.8 145.2
40 4.4 1251.2 366.7 108.0 1174.2 344.1 121.6 1096.9 321.5 135.6 1021.2 299.3 148.0
54118-S
45 7.2 1378.1 403.9 111.6 1293.7 379.2 125.3 1209.4 354.5 139.0 1127.6 330.5 150.9
50 10 1512.4 443.3 115.6 1422.5 416.9 129.3 1333.1 390.7 142.5 1245.3 365.0 153.6
Table 3 ends
Notes :
* Power input mentioned in this page should not be used for cable or fuse selection. MCA and MFA values given in the electrical data
pages (18 - 20) should be referred for the same.
Computer Print outs for matched ratings with SKM Air Handling Units are available.
12
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
CAPACITY RATINGS - 60 HZ
Condenser Entering Air Temperature
Model SST 95F (35C) 105F (40.6C) 115F (46.1C) 125F (51.7C)
ACUV Total Capacity PI* Total Capacity PI* Total Capacity PI* Total Capacity PI*
F C MBh kW kW MBh kW kW MBh kW kW MBh kW kW
35 1.7 86.2 25.3 6.9 79.6 23.3 7.7 72.8 21.3 8.6 66.0 19.3 9.5
40 4.4 94.4 27.7 7.0 87.7 25.7 7.9 80.6 23.6 8.8 73.7 21.6 9.7
61009-S
45 7.2 102.3 30.0 7.2 95.6 28.0 8.1 88.5 25.9 9.0 81.8 24.0 9.9
50 10 109.7 32.2 7.4 103.2 30.3 8.3 96.4 28.3 9.2 90.0 26.4 10.0
35 1.7 111.7 32.7 9.3 104.5 30.6 10.4 96.6 28.3 11.5 88.8 26.0 12.7
40 4.4 122.4 35.9 9.5 114.7 33.6 10.6 106.5 31.2 11.8 98.6 28.9 12.9
61011-S
45 7.2 133.7 39.2 9.8 125.6 36.8 10.9 117.0 34.3 12.0 108.8 31.9 13.1
50 10 145.5 42.6 10.1 136.9 40.1 11.2 128.0 37.5 12.3 119.6 35.1 13.4
35 1.7 142.8 41.9 12.2 134.4 39.4 13.6 125.9 36.9 15.2 117.4 34.4 16.8
40 4.4 158.1 46.3 12.5 148.9 43.6 14.0 139.6 40.9 15.6 130.4 38.2 17.2
61016-S
45 7.2 174.5 51.1 12.9 164.5 48.2 14.4 154.4 45.3 16.0 144.4 42.3 17.5
50 10 192.0 56.3 13.3 181.2 53.1 14.8 170.3 49.9 16.4 159.5 46.8 17.9
35 1.7 169.2 49.6 14.1 156.0 45.7 15.8 142.5 41.8 17.6 129.1 37.8 19.3
40 4.4 185.3 54.3 14.5 171.7 50.3 16.3 157.7 46.2 18.1 144.3 42.3 19.8
62018-S
45 7.2 201.0 58.9 14.9 187.3 54.9 16.7 173.3 50.8 18.5 160.3 47.0 20.2
50 10 215.7 63.2 15.3 202.4 59.3 17.1 189.1 55.4 18.9 176.9 51.8 20.5
35 1.7 171.9 50.4 15.9 161.7 47.4 17.8 151.5 44.4 19.8 141.3 41.4 21.7
40 4.4 190.2 55.7 16.3 178.9 52.4 18.3 167.7 49.1 20.3 156.5 45.9 22.2
61018-S
45 7.2 209.6 61.4 16.9 197.2 57.8 18.9 184.7 54.1 20.9 172.6 50.6 22.6
50 10 230.2 67.5 17.5 216.8 63.5 19.5 203.4 59.6 21.4 190.4 55.8 23.1
35 1.7 190.4 55.8 17.2 176.2 51.6 19.2 161.7 47.4 21.2 147.9 43.3 23.1
40 4.4 208.3 61.0 17.7 193.5 56.7 19.7 178.6 52.4 21.7 164.8 48.3 23.6
62020-S
45 7.2 226.5 66.4 18.2 211.3 61.9 20.3 196.3 57.5 22.3 182.7 53.5 24.0
50 10 244.8 71.8 18.8 229.5 67.3 20.8 214.5 62.9 22.8 201.5 59.0 24.4
35 1.7 219.5 64.3 19.1 204.6 60.0 21.4 188.9 55.4 23.7 173.8 50.9 26.0
40 4.4 240.3 70.4 19.7 224.6 65.8 21.9 208.3 61.1 24.2 193.0 56.6 26.4
62022-S
45 7.2 262.1 76.8 20.3 245.6 72.0 22.5 228.7 67.0 24.8 213.1 62.5 26.8
50 10 284.9 83.5 20.9 267.5 78.4 23.1 250.0 73.3 25.4 234.2 68.6 27.3
35 1.7 246.5 72.3 22.7 230.6 67.6 25.4 214.3 62.8 28.2 198.6 58.2 30.8
40 4.4 271.1 79.5 23.5 254.1 74.5 26.1 236.9 69.4 28.8 220.4 64.6 31.3
62026-S
45 7.2 297.2 87.1 24.2 279.0 81.8 26.9 260.8 76.4 29.6 243.6 71.4 31.9
50 10 324.7 95.2 25.0 305.3 89.5 27.7 286.1 83.9 30.4 268.3 78.6 32.6
35 1.7 282.4 82.8 24.9 265.6 77.8 27.9 248.6 72.9 31.1 231.7 67.9 34.2
40 4.4 312.4 91.6 25.6 294.1 86.2 28.6 275.6 80.8 31.8 257.2 75.4 34.9
62030-S
45 7.2 344.5 101.0 26.4 324.6 95.1 29.5 304.5 89.3 32.7 284.7 83.5 35.6
50 10 378.7 111.0 27.2 357.1 104.7 30.4 335.5 98.3 33.5 314.2 92.1 36.4
35 1.7 311.1 91.2 28.7 292.5 85.7 32.1 273.8 80.3 35.7 255.3 74.8 39.1
40 4.4 344.0 100.8 29.5 323.7 94.9 33.0 303.2 88.9 36.6 283.0 82.9 39.9
62033-S
45 7.2 379.1 111.1 30.5 356.8 104.6 34.0 334.4 98.0 37.6 312.5 91.6 40.8
50 10 416.3 122.0 31.6 392.1 114.9 35.1 368.1 107.9 38.6 344.7 101.0 41.7
35 1.7 339.1 99.4 32.6 318.7 93.4 36.5 298.3 87.4 40.5 278.1 81.5 44.2
40 4.4 374.7 109.8 33.6 352.3 103.2 37.6 329.9 96.7 41.6 307.9 90.2 45.1
62036-S
45 7.2 412.4 120.9 34.8 387.7 113.6 38.8 363.0 106.4 42.7 339.3 99.4 46.1
50 10 452.3 132.6 36.2 425.7 124.8 40.1 399.4 117.1 43.9 374.0 109.6 47.0
35 1.7 432.4 126.7 39.3 402.1 117.9 43.8 370.9 108.7 48.5 341.7 100.1 52.8
40 4.4 472.9 138.6 40.5 441.2 129.3 44.9 409.1 119.9 49.5 379.5 111.2 53.7
62043-S
45 7.2 515.6 151.1 41.7 482.3 141.4 46.2 449.2 131.7 50.6 419.3 122.9 54.6
50 10 559.9 164.1 43.0 525.0 153.9 47.5 491.0 143.9 51.9 461.0 135.1 55.5
35 1.7 493.8 144.7 45.4 461.9 135.4 50.7 429.3 125.8 56.2 397.9 116.6 61.4
40 4.4 543.1 159.2 46.8 509.0 149.2 52.1 474.6 139.1 57.6 441.6 129.4 62.6
62051-S
45 7.2 595.4 174.5 48.3 558.9 163.8 53.7 522.5 153.1 59.0 488.0 143.0 63.8
50 10 650.5 190.7 49.9 611.6 179.3 55.3 573.2 168.0 60.6 537.4 157.5 65.0
Notes : Table 4
* Power input mentioned in this page should not be used for cable or fuse selection. MCA and MFA values given in the electrical data
pages ( 18-20 ) should be referred for the same.
Computer Print outs for matched ratings with SKM Air Handling Units are available.
13
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
CAPACITY RATINGS - 60 H Z
Condenser Entering Air Temperature
Model SST 95F (35C) 105F (40.6C) 115F (46.1C) 125F (51.7C)
ACUV Total Capacity PI* Total Capacity PI* Total Capacity PI* Total Capacity PI*
F C MBh kW kW MBh kW kW MBh kW kW MBh kW kW
35 1.7 549.9 161.2 52.3 516.3 151.3 58.5 482.7 141.5 64.9 449.4 131.7 70.8
40 4.4 607.1 177.9 54.1 570.6 167.2 60.3 534.1 156.5 66.6 498.1 146.0 72.2
62058-S
45 7.2 668.1 195.8 55.9 628.5 184.2 62.2 589.1 172.7 68.4 550.6 161.4 73.8
50 10 732.8 214.8 58.0 690.1 202.3 64.3 647.7 189.8 70.3 606.7 177.8 75.3
35 1.7 609.5 178.6 59.6 572.4 167.8 66.6 535.3 156.9 73.8 498.6 146.1 80.2
40 4.4 672.8 197.2 61.6 632.3 185.3 68.7 591.8 173.4 75.8 552.1 161.8 81.9
62063-S
45 7.2 740.1 216.9 63.8 695.6 203.9 71.0 651.6 191.0 77.8 609.0 178.5 83.6
50 10 811.2 237.8 66.3 763.4 223.8 73.4 716.3 209.9 80.0 670.9 196.6 85.4
35 1.7 680.0 199.3 64.9 639.3 187.4 72.6 598.4 175.4 80.7 557.9 163.5 88.0
40 4.4 751.5 220.3 66.9 706.7 207.1 74.8 661.8 194.0 82.8 617.7 181.1 89.9
62071-S
45 7.2 827.4 242.5 69.2 777.9 228.0 77.2 728.5 213.5 85.1 680.9 199.6 91.8
50 10 907.7 266.0 71.9 854.4 250.4 79.8 801.6 234.9 87.4 750.6 220.0 93.8
35 1.7 741.7 217.4 67.9 693.9 203.4 75.8 645.1 189.1 84.2 597.8 175.2 92.0
40 4.4 815.9 239.1 70.0 764.7 224.1 78.0 713.0 209.0 86.2 663.4 194.4 93.7
63076-S
45 7.2 894.6 262.2 72.2 839.9 246.2 80.3 785.1 230.1 88.3 733.3 214.9 95.5
50 10 977.5 286.5 74.6 919.1 269.4 82.7 861.4 252.5 90.7 807.5 236.7 97.4
35 1.7 817.1 239.5 79.9 766.8 224.8 89.2 716.5 210.0 98.7 666.9 195.5 107.3
40 4.4 901.4 264.2 82.6 846.9 248.2 92.0 792.4 232.3 101.3 738.9 216.6 109.5
63085-S
45 7.2 991.3 290.6 85.6 932.2 273.2 95.1 873.5 256.0 104.2 816.3 239.3 111.9
50 10 1086.6 318.5 88.8 1022.8 299.8 98.3 959.8 281.3 107.1 899.2 263.6 114.1
35 1.7 899.6 263.7 83.1 845.6 247.9 93.0 791.3 231.9 103.4 737.4 216.1 113.3
40 4.4 994.4 291.5 85.6 935.4 274.2 95.7 876.1 256.8 106.1 817.6 239.6 115.6
63094-S
45 7.2 1095.6 321.1 88.4 1031.0 302.2 98.7 966.4 283.3 109.0 903.2 264.7 118.1
50 10 1202.8 352.6 91.6 1133.1 332.1 101.9 1063.6 311.7 112.0 996.1 291.9 120.6
35 1.7 955.5 280.1 91.0 898.0 263.2 101.8 840.4 246.3 113.0 783.2 229.5 123.3
40 4.4 1055.7 309.4 93.8 992.7 291.0 104.9 929.5 272.4 116.0 867.5 254.3 126.0
63100-S
45 7.2 1162.3 340.7 97.1 1093.0 320.4 108.2 1023.9 300.1 119.2 956.9 280.5 128.6
50 10 1275.1 373.7 100.8 1200.4 351.8 111.8 1126.4 330.1 122.4 1054.8 309.2 131.4
35 1.7 983.1 288.1 95.0 923.8 270.8 106.3 864.5 253.4 117.9 805.6 236.1 128.4
40 4.4 1085.9 318.3 98.1 1020.8 299.2 109.5 955.8 280.1 121.0 892.0 261.4 131.2
63102-S
45 7.2 1195.1 350.3 101.5 1123.3 329.2 113.1 1052.0 308.3 124.3 983.3 288.2 133.9
50 10 1310.5 384.1 105.5 1233.3 361.5 116.9 1157.1 339.1 127.8 1083.6 317.6 136.8
35 1.7 1098.3 321.9 104.9 1031.2 302.3 117.3 963.9 282.5 130.1 897.4 263.0 141.8
40 4.4 1212.4 355.4 108.4 1139.5 334.0 120.9 1066.5 312.6 133.5 994.7 291.5 144.7
64113-S
45 7.2 1334.1 391.0 112.2 1255.1 367.9 124.8 1176.3 344.8 137.2 1099.3 322.2 147.8
50 10 1463.3 428.9 116.3 1377.8 403.8 129.0 1293.2 379.0 141.0 1211.4 355.0 150.8
35 1.7 1208.9 354.3 112.0 1136.3 333.1 125.4 1063.4 311.7 139.5 990.9 290.4 152.7
40 4.4 1336.2 391.6 115.5 1256.9 368.4 129.1 1177.2 345.0 143.1 1098.5 322.0 155.9
64126-S
45 7.2 1472.0 431.4 119.3 1385.2 406.0 133.1 1298.3 380.5 147.0 1213.4 355.6 159.2
50 10 1616.0 473.6 123.6 1522.2 446.1 137.5 1428.8 418.8 151.0 1338.0 392.2 162.6
35 1.7 1264.8 370.7 119.9 1188.7 348.4 134.2 1112.4 326.0 149.1 1036.7 303.8 162.8
40 4.4 1397.5 409.6 123.7 1314.1 385.2 138.3 1230.6 360.7 153.0 1148.4 336.6 166.2
64132-S
45 7.2 1538.8 451.0 128.0 1447.1 424.1 142.7 1355.7 397.4 157.2 1267.0 371.4 169.7
50 10 1688.3 494.8 132.8 1589.5 465.9 147.4 1491.5 437.2 161.5 1396.7 409.4 173.3
35 1.7 1347.1 394.8 132.1 1265.9 371.0 147.8 1184.5 347.2 163.7 1103.8 323.5 178.0
40 4.4 1487.6 436.0 136.5 1398.2 409.8 152.4 1308.9 383.6 168.2 1221.6 358.1 181.9
64140-S
45 7.2 1636.4 479.6 141.4 1537.6 450.7 157.4 1439.7 422.0 172.7 1345.8 394.4 185.6
50 10 1793.8 525.8 147.1 1687.7 494.7 162.8 1583.1 464.0 177.5 1482.7 434.6 189.6
Table 4 ends
Notes :
* Power input mentioned in this page should not be used for cable or fuse selection. MCA and MFA values given in the electrical data
pages ( 18-20) should be referred for the same.
Computer Print outs for matched ratings with SKM Air Handling Units are available.
1). Cooling capacity at 95F (35C) ambient temperature according to AHRI-365.
2). Cooling capacity at Gulf conditions : 115F (46.1C) condenser entering air temperature & 45F (7.2C) SST.
3). Operating charge is approximate for condensing unit only and does not include refrigerant lines and evaporator coil.
4). Condensing units are shipped with nitrogen holding charge only.
14
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
Capacity Control Steps
The Standard Capacity Control Steps are shown below.
Selection Procedure Actual capacity (at level) = Sea level capacity x altitude correction
factor (from Table 6).
Example
15
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
Field Connections
ACUV-S series self-contained heavy duty air cooled condensing units are designed for minimum field interaction.
Power hook-ups for AHU starter and fan interlock and control wiring of room unit as per Electrical hook-up diagram is all that is required
to electrically connect any model of ACUV-S series .
Every ACUV-Sseries condensing unit requires, at most, field installed fused disconnect switches or circuit breakers, and room unit.
Refer below for a schematic representation of required field electrical hook-ups for a standard ACUV-S series condensing unit.
All field wiring must be done in accordance with applicable local and national codes.
For maximum recommended fuse sizes and minimum circuit amps for cable sizing, see Page 18 - 20 of this bulletin.
3 PHASE,
3 WIRE SYSTEM
440V/3PH/50HZ CIRCUIT BREAKER
220V/3PH/60HZ OR FUSED CIRCUIT BREAKER
460V/3PH/60HZ DISCONNECT SWITCH OR FUSED
(NOT BY SKM) DISCONNECT SWITCH
(NOT BY SKM)
3 PHASE,
4 WIRE SYSTEM
380-415V/3PH/50HZ
L1
L2
380V/3PH/60HZ
L3
N
GROUND 3 PHASE,
4 WIRE SYSTEM
E
380-415V/3PH/50HZ
L1 380V/3PH/60HZ
L2
CUSTOMER SUPPLIED
EFM STARTER INTERLOCK TO AHU AND INSTALLED
AHU STARTER BOX FIELD ACCESSORY
(BY OTHERS)
(CONTACTOR, OVERLOAD
RELAY & ON/OFF CONTROL etc.)
DOL/STAR DELTA
FAN INTERLOCK FROM AHU
ROOM UNIT
(LOOSESUPPLY) U
V M
W 3~
+ -
E
CE+ CE-
CE-
2 CORE UNSCREENED TWISTED PAIR CABLE
AS PER KNX SPECIFICATION (BY OTHERS) LINE VOLTAGE
FIELD WIRING
AUMR
ACUV-S A-SERIES
SERIES
CONTROL PANEL LOW VOLTAGE
FIELD WIRING
REFER ACTUAL WIRING DIAGRAM
FURNISHED WITH THE UNIT FOR
EXACT IDENTIFICATION OF WIRE NUMBERS.
**ACUV
AUMR- S ASERIES
SERIES UNITS RATED FOR 440V/3PH/50HZ, 460V/3PH/60HZ, OR POWER SUPPLIES WITH OUT NEUTRAL
REQUIRE SEPARATE SOURCE OF CONTROL POWER SUPPLY THRU FIELD SUPPLIED & INSTALLED 15A/220V FUSED
CONTROL DISCONNECT SWITCH OR ORDER WITH FACTORY BUILT IN OPTION ' CXT '.
16
*L1*L1 POWER SUPPLYPOWERSUPPLY
** L2L2
L3L3
NN
F
C1 C2
MPCB1 MPCB2 MPCB3 MPCB4
N L1 MPCB1 MPCB2 MPCB3 MPCB4
I> I> I> I> I> I> I> I> I> I> I> I>
N L1
MPM1 MPM2 I> I> I> I> I> I> I> I> I> I> I> I>
2 L2
C1
* C2 L1 L L3
* L1 L3
C3 C4 C5 C6
T2 T1 M 1 M2 S1 S2 T2 T1 M 1 M2 S1 S2 C3 C4 C5 C6 VMM
CM1 CM2
A BC
MCB1 CM1 CM2 CFM1 CFM2 CFM3 CFM4 NC Com NO
MCB1 CFM1 CFM2 CFM3 CFM4 PROVIDE OVERCURRENT, EARTH FAULT PROTECTION, SHORT CIRCUITAND
** DISCONNECT MEANS AS REQUIRED BYLOCAL & NATIONAL ELECTRIC CODE.
CR1 CR2
NOTE:-
ROOM UNIT
(LOOSE SUPPLY)ROOM UNIT NO TE:- wiring diagram given here is for units with 380~ 415/3/50 or
* Typical
380/3/60, 4 wire power supplies.
(LOOSE SUPPLY) * Typical wiring diagramgivenhereis for units with 380~ 415/3/50 or
Wiring diagrams
* 380/3/60, for 440/3/50,
4 wirepower 220/3/60 or 460/3/60
supplies.
power supplies are available on request.
diagrams for 440/3/50, 220/3/60 or 460/3/60
Typical Wiring Diagram
* Wiring
For 440/3/50 or 460/3/60 or power supplies without neutral,
* power supplies areavailableonrequest.
G G + - CXT option is a must.
G G
I I CR6 CR7 CR4 CR5 CS CR8 * For 440/3/50 or 460/3/60 or power supplies without neutral,
I I CR1 CR2 CS CR6 + - CXToption is amust.
VMM
MP-1
MP-2
L EGEND
some small compressors.
LPS-1
LPS-2
OPS-1
OPS-2
2COREUNSCREENED * MPMModule is not availablein
LPS-1
LPS-2
TWISTED PAIR CABLE P PRESSURE ACTIVATED SWITCH OFH OIL FAILURE HEATER
RUN/STOP
AS PER KNXSPECIFICATON TFR TRANSFORMER OPS OIL PRESSURESWITCH
RUN/STOP
(BY OTHERS)
FAN INTERLOCK
(BY OTHERS)
CS CONTROL SWITCH MP MOTOR PROTECTOR
DISC. PRESSURE-2
DISC. PRESSURE-1
FAN INTERLOCK
TWISTED PAIR CABLE
2CORE UNSCREENED
C CONTACTOR MPCB MOTOR PROTECTOR CIRCUT BREAKER
L E GEN
DISC. PRESSURE-1
DISC. PRESSURE-2
CRANK CASE HEATER OL
CCH
DOVERLOADRELAY
MCB2
TFR
MCB TRANSFORMER
MINIATURECIRCUIT BREAKER VMMLSV VOLTAGEMON
LIQUID LINEITORINGMODULE
SOLENOID VALVE
CFM
CS CONTR OL SWITCH
CONDENSER FAN MOTOR MPM EVAPORATORFANMOTOR
EFM MOTOR PROTECTOR MODULE
CCM COMPRESSOR
CONTACTO R MOTOR MPCB CONTROL
CR MOTOR RELAY
PROTEC TORCIRCUT BREAKER
LPS
CCH LOW PRESSURE
CRANK SWITCH
CASE HEATER OL OVERLOADRELAY
FIELD WIRING
HPS
MC B HIGH PRESSURESWITCH
MINIATUREC IRCUITBREAKER LSV LIQUID LINESOLENOID VALVE
ACUV-S Series - R-134a
M
MCB2 FIELD WIRING
B1
HPS HIGH PRESSURESWITMATCHINGAHUF
CH OR
5V=
5V=
DU1
T1
T2
T3
T4
T5
T6
T7
B-CE+
MB3
M X1
M
M X5
M
MD1
M
24V=
24V=
X1
X2X3
X3
X4 M
X5
X6X7
X7
X8 M
B1 M
B2
B3 M
A+
D1
D2DG
DGA+
CE-
REFCE-
CE+
5V= M
5V= M
DU1
DU2 B-
T1 B2
T2 X2
T3 X6
T4 D2
T5 DU2
T6 REF
T7
24V=X4
24V=X8
MATCHING AHU FOR
CR3
INFO CR5
INFO
MICROPROCESSOR EFMSTARTER
CONTROLLER OK INTERLOCK
TFR MICROPROCESSSOR EFMSTARTER
OK INTERLOCK
CONTROLLER
220~ 240V
TFR
ESC
24V
220~ 240V24V
ESC
SKM Air Cooled Condensing Units
C1 C2 CR1 CR2
T8
C1 C2 CR3 CR4
24~_
G0
Q11
D02
T-HI
T8
T9 Q14
24~_ T9
G0 Q12
Q12 T10
Q11 Q22
Q14 Q21
Q22 Q33
Q21 Q34
Q24 Q43
Q33 Q44
Q34 T11
Q43 Q53
Q44 Q54
Q53 Q73
Q54 Q74
Q64 Q84
Q73 T12
Q74 C
Q84 D01
C T13
D01 DL1
D02 DN
DL1 T-IP
DN
DL2
T10 Q24
T11 Q64
T12
T13 DL2
T-IP
MP1 MP2
T-HI
L L
11 11 OPS1 OPS2
L 1 2 L 1 2 M M
N 12 14 N 12 14
M M
LSV-1 LSV-2
(BY OTHERS)
CCH1
CCH2
FAN INTERLOCK FROM AHU
HPS-1
HPS-2
R
R
E LSV-1 LSV-2
OFH-1
OFH-2
COMP.-1
LSV-1
COMP.-2
LSV-2
CFM1
CFM2
CFM3
CFM4
EFM
CCH1
CCH2
(BY OTHERS)
P P
HPS-1
HPS-2
COMP.-1
LSV-1
COMP.-2
LSV-2
CFM1
CFM2
CFM3
CFM4
EFM
17
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
ELECTRICAL DATA 380~415/3/50
380~415/3/50
Power Supply: 380-415V / 3Ph / 50Hz
Unit Characteristic
Unit Characteristic
Model Co
C om
mpprreesssso
orr Co
C on
nddeen
nsseerr F
Faan
nMMo
otto
orr
Model
ACUV
ACUV MFA
MFA MCA
MCA ICF
ICF QTY
QTY RLA
RLA LRA
LRA QTY
QTY FLA
FLA LRA
LRA
51008-S
51008-S 63
63 30
30 123
123 11 22
22 118
118 22 1.1
1.1 3.9
3.9
51010-S
51010-S 80
80 40
40 179
179 11 30
30 174
174 22 1.1
1.1 3.9
3.9
51013-S
51013-S 100
100 52
52 236
236 11 38
38 225
225 22 2.4
2.4 8.9
8.9
52015-S
52015-S 80
80 54
54 151
151 1
1+ + 11 22
22 ++ 22
22 118 + 118
118 + 118 22 2.4
2.4 8.9
8.9
51016-S
51016-S 125
125 60
60 283
283 11 44
44 272
272 22 2.4
2.4 8.9
8.9
52017-S
52017-S 100
100 64
64 207
207 11 ++ 11 30 +
30 + 22
22 174 +
174 + 118
118 22 2.4
2.4 8.9
8.9
52019-S
52019-S 125
125 75
75 225
225 11 ++ 11 30 +
30 + 30
30 174 +
174 + 174
174 22 3.9
3.9 17.2
17.2
52022-S
52022-S 125
125 85
85 276
276 11 ++ 11 38 +
38 + 30
30 225 +
225 + 174
174 22 3.9
3.9 17.2
17.2
52025-S
52025-S 160
160 97
97 288
288 11 ++ 11 38 +
38 + 38
38 225 +
225 + 225
225 33 3.9
3.9 17.2
17.2
52028-S
52028-S 160
160 105
105 335
335 11 ++ 11 44 +
44 + 38
38 272 +
272 + 225
225 33 3.9
3.9 17.2
17.2
52030-S
52030-S 160
160 111
111 341
341 11 ++ 11 44 +
44 + 44
44 272 +
272 + 272
272 33 3.9
3.9 17.2
17.2
52036-S
52036-S 200
200 139
139 289
289 22 ++ 22 30 +
30 + 30
30 174 +
174 + 174
174 33 3.9
3.9 17.2
17.2
52043-S
52043-S 200
200 161
161 352
352 2 + 22
2 + 38 + 30
38 + 30 225 + 174
225 + 174 44 3.9
3.9 17.2
17.2
52048-S
52048-S 250
250 177
177 368
368 22 ++ 22 38 +
38 + 38
38 225 +
225 + 225
225 44 3.9
3.9 17.2
17.2
52053-S
52053-S 250
250 191
191 421
421 2
2+ + 22 44 + 38
44 + 38 272 + 225
272 + 225 44 3.9
3.9 17.2
17.2
52060-S
52060-S 250
250 203
203 433
433 2 + 22
2 + 44 + 44
44 + 44 272 +
272 + 272
272 44 3.9
3.9 17.2
17.2
53064-S
53064-S 315
315 237
237 441
441 33 ++ 33 38 +
38 + 30
30 225 + 174
225 + 174 66 3.9
3.9 17.2
17.2
53071-S
53071-S 315
315 261
261 465
465 3 + 33
3 + 38 + 38
38 + 38 225 +
225 + 225
225 66 3.9
3.9 17.2
17.2
53079-S
53079-S 400
400 274
274 518
518 22 ++ 44 44 +
44 + 38
38 272 + 225
272 + 225 66 3.9
3.9 17.2
17.2
53084-S
53084-S 400
400 286
286 530
530 4 + 22
4 + 44 + 38
44 + 38 272 +
272 + 225
225 66 3.9
3.9 17.2
17.2
53086-S
53086-S 400
400 292
292 536
536 55 ++ 11 44 +
44 + 38
38 272 +
272 + 225
225 66 3.9
3.9 17.2
17.2
54095-S
54095-S 400
400 345
345 549
549 44 ++ 44 38 +
38 + 38
38 225 +
225 + 225
225 88 3.9
3.9 17.2
17.2
54106-S
54106-S 500
500 364
364 608
608 33 ++ 55 44 +
44 + 38
38 272 +
272 + 225
225 88 3.9
3.9 17.2
17.2
54111-S 500 376 620 55 ++ 33 44 ++ 38
38 272 +
+ 225
225 88 3.9 17.2
Table 7
54111-S 500 376 620 44 272 3.9 17.2
54118-S
54118-S 500
500 394
394 638
638 88 44
44 272
272 88 3.9
3.9 17.2
17.2
440-3-50
Power Supply: 440V / 3Ph / 50Hz
440-3-50
Unit Characteristic
Unit Characteristic
Model Co
C om
mpprreesssso
orr Co
C on
nddeen
nsseerr F
Faan
nMMo
otto
orr
Model
ACUV
ACUV MFA
MFA MCA
MCA ICF
ICF QTY
QTY RLA
RLA LRA
LRA QTY
QTY FLA
FLA LRA
LRA
51008-S
51008-S 63
63 30
30 123
123 11 22
22 118
118 22 1.1
1.1 3.9
3.9
51010-S
51010-S 80
80 40
40 179
179 11 30
30 174
174 22 1.1
1.1 3.9
3.9
51013-S
51013-S 100
100 53
53 237
237 11 38
38 225
225 22 2.8
2.8 9.2
9.2
52015-S
52015-S 80
80 55
55 152
152 11 + + 11 22 +
22 + 22
22 118 +
118 + 118
118 22 2.8
2.8 9.2
9.2
51016-S
51016-S 125
125 61
61 284
284 11 44
44 272
272 22 2.8
2.8 9.2
9.2
52017-S
52017-S 100
100 65
65 208
208 11 + + 11 30 +
30 + 22
22 174 +
174 + 118
118 22 2.8
2.8 9.2
9.2
52019-S
52019-S 125
125 76
76 226
226 1 + 11
1 + 30 + 30
30 + 30 174 + 174
174 + 174 22 4.3
4.3 17.6
17.6
52022-S
52022-S 125
125 86
86 277
277 11 + + 11 38 +
38 + 30
30 225 +
225 + 174
174 22 4.3
4.3 17.6
17.6
52025-S
52025-S 160
160 98
98 289
289 1 + 11
1 + 38 + 38
38 + 38 225 + 225
225 + 225 33 4.3
4.3 17.6
17.6
52028-S
52028-S 160
160 106
106 336
336 11 + + 11 44 +
44 + 38
38 272 +
272 + 225
225 33 4.3
4.3 17.6
17.6
52030-S
52030-S 160
160 112
112 342
342 1 + 11
1 + 44 + 44
44 + 44 272 + 272
272 + 272 33 4.3
4.3 17.6
17.6
52036-S
52036-S 200
200 140
140 290
290 22 + + 22 30 +
30 + 30
30 174 +
174 + 174
174 33 4.3
4.3 17.6
17.6
52043-S
52043-S 250
250 163
163 354
354 2 + 22
2 + 38 + 30
38 + 30 225 + 174
225 + 174 44 4.3
4.3 17.6
17.6
52048-S
52048-S 250
250 179
179 370
370 22 + + 22 38 +
38 + 38
38 225 +
225 + 225
225 44 4.3
4.3 17.6
17.6
52053-S
52053-S 250
250 192
192 423
423 22 + + 22 44 +
44 + 38
38 272 +
272 + 225
225 44 4.3
4.3 17.6
17.6
52060-S
52060-S 250
250 204
204 435
435 22 + + 22 44 +
44 + 44
44 272 +
272 + 272
272 44 4.3
4.3 17.6
17.6
53064-S
53064-S 315
315 239
239 443
443 33 + + 33 38 +
38 + 30
30 225 +
225 + 174
174 66 4.3
4.3 17.6
17.6
53071-S
53071-S 315
315 263
263 467
467 33 + + 33 38 +
38 + 38
38 225 +
225 + 225
225 66 4.3
4.3 17.6
17.6
53079-S
53079-S 400
400 277
277 520
520 22 + + 44 44 +
44 + 38
38 272 +
272 + 225
225 66 4.3
4.3 17.6
17.6
53084-S
53084-S 400
400 289
289 532
532 44 + + 22 44 +
44 + 38
38 272 +
272 + 225
225 66 4.3
4.3 17.6
17.6
53086-S
53086-S 400
400 295
295 538
538 5 + 11
5 + 44 + 38
44 + 38 272 + 225
272 + 225 66 4.3
4.3 17.6
17.6
54095-S
54095-S 400
400 348
348 552
552 44 + + 44 38 +
38 + 38
38 225 +
225 + 225
225 88 4.3
4.3 17.6
17.6
54106-S
54106-S 500
500 367
367 611
611 3 + 55
3 + 44 + 38
44 + 38 272 + 225
272 + 225 88 4.3
4.3 17.6
17.6
54111-S 500 379 623 55 + + 33 44 ++ 38
38 272 +
+ 225
225 88 4.3 17.6
Table 8
Table 9
64132-S 630 462 770 5+3 56 + 42 353 + 280 8 5.3 17.5
64140-S 630 504 812 8 56 353 8 5.3 17.5
220-3-60
ON BOTH SIDES
[1312]
LIQ.
51.65
MODEL CONNECTIONSIZE,
45 68
LIQ.
[1143]
ACUV-3 SUC. LIQ. DETACHABLE [1727] 1
DETACHABLE
PLATE FOR
[305]
PLATE FOR
CABLE ENTRY
51008S 1 5/8 5/8
12
A2 A4
[305]
CABLE ENTRY
12
4 ACCESS
[178]
[100]
3.94
6 RIGGING0.79
HOLES[20] 4 Nos.
7
[1312
45 68
51.6
LIQ.
[1312]
DETACHABLE
51.65
LIQ.
[305]
CABLE ENTRY
12
DETACHABLE 2
VENTILATION
PLATE FOR SUC.
[305]
CABLE ENTRY
ON BOTH SIDES
12
ACCESS
[1312]
51.65
[100]
3.94
4 LIQ.
[178]
6 RIGGING HOLES
7
ACCESS
[100]
0.79 [20] 4 Nos.
3.94
DETACHABLE 4 [152]
[178]
6 RIGGING HOLES
Dimensional Data
7
PLATE FOR
[305]
CABLE ENTRY [152] 0.79 [20] 4 Nos.
12
ACUV Models: 51013S-52022S & 61016S-62026S ACCESS
[100]
3.94
4
[178]
6 RIGGING HOLES
7
0.79 [20] 4 Nos.
ACUV Models - 51013S to 52022S & 61016S to 62026S [152]
ACUV Models - 51013S to 52022S & 61016S10to 62026S 10
10
10
[254] A3 [254]
[254] A3 [254]
A1 A1
DIMENSIONS CONNECTION SIZE,
DIMENSIONS CONNECTION SIZE,
MODEL ACUV Models - 51013S to CIRCUIT-1
MODEL 52022S & 61016S to 62026S
CIRCUIT-2 CIRCUIT-1 CIRCUIT-2
10 10
ACUV- L W H A BACUV- L W H A B
SUC.#1 LIQ.#1 SUC.#2 LIQ.#2 SUC.#1 LIQ.#1 SUC.#2[254]
LIQ.#2 A3 [254]
*
51013S 56 74 51.65 12.72 *-51013S 2
61016S[54]
1/8 56 7/8
[1422] [22]
74 51.65
-
[1880] [1312]
12.72
-
[323] - 2 1/8
[54] [22]
7/8 - -
61016S [1422] [1880] [1312] [323] A1
52015S 56DIMENSIONS 74 51.65 12 12CONNECTION
1 5/8 SIZE,
5/8 1 5/8 5/8
52015S 56 74 51.65 12 MODEL 1 5/8 5/8 1 5/8
1262018S [1422] [1880] [1312] [305] [305]5/8 CIRCUIT-1[41] CIRCUIT-2
[16] [41] [16]
62018S [1422] [1880] [1312] [305]
ACUV-[305] L [41] W56 [16] H76 [41]A B[16]
*51016S 51.65 12.72 SUC.#1- LIQ.#1 7/8
2 1/8 SUC.#2
[54] [22] LIQ.#2 - -
*
51016S 56 76 51.65 12.72
*51013S
61018S [1422] [1930] [1312] [323]
61018S2 1/8[1422] 7/8
- 56 [54]74 [22]
[1930] [1312] [323]
51.65
76 12.72
- - 1/8 7/8
51.65 -12 2[54] 1 5/8 -7/8 1- 5/8 5/8
61016S 52017S
[1422] 56 [1312]
[1880]
[1422] 7/8 [323]
[1930] 1[1312]
12 [22]
[305] [305] [41] [22] [41] [16]
52017S 56 76 51.65 1252015S 1262020S56 1 5/8 125/8 125/8
62020S [1422] [1930] [1312] [305] 52019S
[1422] [41]
62018S[305]
7456 51.65
[22]84 [305]
59.65
[41] 12 1 5/8
[16] 12 5/81 5/8 1[41]
5/8
7/8 5/8
1 5/8 7/8
62022S [1880]
[1422] [1312] [305] [41]
[2134] [1515] [305] [305] [16]
[41] [22] [16] [41] [22]
52019S 56 56 1 5/8
84 59.65 *1251016S 1252022S 7/884 12.72
7658 51.65 159.65
5/8 12.72-7/8 2 1/8
12 7/8
2 1/8 -7/8 1- 5/8 7/8 A4
62022S [1422] [2134] [1515] [305] [305] A2
61018S 62026S[41]
[1422] [1473] [22]
[1930] [2134] [41]
[1312] [323] [22] [305] [54] [22] [41] [22]
[1515] [323] [54] [22]
52022S 58 84 59.65 12.7252017S 12 56 2 1/8 76 51.65 127/8 1 5/8 7/8 1 5/8
1125/8 [305]
7/8 [305] A2 5/8 A4
* MODEL
[1422] [54]
62020S[305]
62026S [1473] [2134] [1515] [323] [1930]
WITH [1312] [41] [22] [41] [22] [41] [16]
ONE COMPRESSOR
[22]
52019S DIM.12"
56 INSTEAD
84 59.65OF 10"
12 & 4"12FOR ONE1 5/8 COMPRESSOR
7/8 1 5/8 MODEL 7/8
* MODEL WITH ONE COMPRESSOR62022S [1422]
52022S 58
[2134] [1515]
ALL DIMENSIONS
84
ARE[305]
59.65 12.72
[305][mm[41]
IN INCHES
12
] [22] [41] [22]
2 1/8 7/8 1 5/8 7/8 A2 A4
DIM.12" INSTEAD OF 10" & 4" FOR ONE[1473]
62026S COMPRESSOR
[2134] [1515] LMODEL
[323] [305] [54] [22] [41] [22] W
ALL DIMENSIONS ARE IN INCHES [mm ]
* MODEL 3WITH ONE COMPRESSOR
1
L DIM.12" INSTEAD OF 10" & 4" FOR ONE COMPRESSOR MODEL W
ALL DIMENSIONS ARE IN INCHES [mm ]
3 1 L W
SUCTION #2
3
VENTILATION 2 SUCTION #1
1
ON BOTH SIDES LIQUID #2
LIQUID #1
H
DETACHABLE SUCTION #2
ON BOTH SIDES VENTILATION
PLATE FO R 2 SUCTION #1 LIQUID #2
CABLE ENTRY
ON BOTH SIDES LIQUID #1
H
LIQUID #2
A
B
LIQUID #1 RIGGING HOLES
H
RIGGING HOLES
3.94
DETACHABLE 4 * 4 Nos.
0.794[20]
[100]
ACCESS
3.94
4*
[178]
[178]
PLATE FO R DETACHABLE
7
7
CABLE ENTRY PLATE FO R [101]
[101]
A
CABLE ENTRY
B
A
B
10 * 10 *
4 [254] * * [254]
4 ACCESS * ACCESS 4 4
4*
[178]
[178]
[178]
[178]
4
7
7
[101]
7
7
[101]
[101] [101]
ACUV Models:
ACUV Models 52025S-52036S
- 52025S & 62030S-
to 52036S & 62030S to 62043S62043S
10 * 10 *
10 * 10 *
[254] [254]
10 10 [254] [254]
[254] [254]
A1 A3
DIMENSIONS CONNECTION SIZE,
MODEL
ACUV- CIRCUIT-1 CIRCUIT-2
H A B
SUC.#1 LIQ.#1 SUC.#2 LIQ.#2
52025S 60.63 13.7 13.7 2 1/8 7/8 2 1/8 7/8 LEGEND
62030S [1540] [348] [348] [54] [22] [54] [22] 1 CONDENSER FAN
52028S 60.63 13.7 13.7 2 1/8 7/8 2 1/8 7/8 2
62033S [1540] [348] [348] [54] [22] [54] [22] CONDENSER COIL
52030S 60.63 13.7 13.7 2 1/8 7/8 2 1/8 7/8 3 CONTROL PANEL
62036S [1540] [348] [348] [54] [22] [54] [22] 4 COMPRESSOR
* 52036S 77.63 27.29 27.29 2 1/8 7/8 2 1/8 7/8
* 62043S [1972] [693] [693] [54] [22] [54] [22]
* MODEL WITH TANDEM COMPRESSOR
LINE SIZES ARE BASED ON 100f tEQUIVALEN T LENGTH
ALL DIMENSIONS ARE IN INCHES [mm]
A2 A4
76 88
[1930] [2235]
1
3
2 SUCTION#1 SUCTION #2
VENTILATION
ON BOTH SIDES LIQUID#1 LIQUID #2
H
[125]
4.92
DETACHABLE
PLATE FOR
A
CABLE ENTRY
4 4 ACCESS 4
[203]
[203]
[102] [102]
8
10 10
[254] [254]
21
ACUV Models - 52043S to 52060S & 62051S to 62071S
VENTILATION
ON BOTH SIDES LIQUID#1 LIQUID #2
H
[125]
4.92
DETACHABLE
B
CABLE ENTRY
4 4 ACCESS 4
[203]
[203]
[102] [102]
8
10 10
[254] [254]
Dimensional Data
ACUV Models - 52043S to 52060S & 62051S to 62071S
ACUV Models: 52043S-52060S & 62051S-62071S
10 10
[254] [254]
A1 A3
DIMENSIONS CONNECTION SIZE,
MODEL CIRCUIT-1 CIRCUIT-2
ACUV- H
SUC.#1 LIQ.#1 SUC.#2 LIQ.#2
52043S 77.63 2 5/8 1 1/8 2 5/8 1 1/8 LEGEND
62051S [1972] [67] [29] [67] [29]
1 CONDENSER FAN
52048S 85.63 2 5/8 1 1/8 2 5/8 1 1/8
62058S [2175] [67] [29] [67] [29] 2 CONDENSER COIL
52053S 85.63 2 5/8 1 1/8 2 5/8 1 1/8 3 CONTROL PANEL
62063S [2175] [67] [29] [67] [29] 4 TANDEM COMPRESSOR
52060S 85.63 2 5/8 1 1/8 2 5/8 1 1/8
62071S [2175] [67] [29] [67] [29]
LINE SIZES ARE BASED ON 100f tEQUIVALENT LENGTH
ALL DIMENSIONS ARE IN INCHES [mm]
A2 A4
84 88
[2134] [2235]
1
2
FILTERED SUCTION #1 SUCTION #2
VENTILATION
ON BOTH SIDES
H
LIQUID #1 LIQUID #2
DETACHABLE
[125]
4.92
PLATE FOR
[693]
[693]
27.29
27.29
CABLE ENTRY
ACCESS
4
[203]
[203]
8
8
RIGGING HOLES 4 4
.79[20] 4 Nos.
[102] [102]
10 10
[254] [254]
LEGEND
CIRCUIT-1
1 CONDENSER FAN CIRCUIT-2
2 CONDENSER COIL CIRCUIT-3
3 CONTROL PANEL
4 TANDEM COMPRESSOR
FILTERED
VENTILATION
ON BOTH SIDES
LIQUID
1 1/8[29]x 4Nos.
105.91
[2690]
[2420]
95.28
DETACHABLE
PLATE FOR
CABLE ENTRY
[750]
29.5
4
[125]
1
[
[
SKM Air Cooled Condensing Units
PLATE FOR
CABLE ENTRY
[750]
29.5
ACUV-S Series - R-134a 4
[125]
SUCTION RIGGING HOLES
4.92
2 5/8[67]x 4Nos. 7/8[22] x 4 Nos.
Dimensional Data
ACUV Models
ACUV Models: - 54095S to 54118S&
54095S-54118S & 64113S to 64140S
64113S-64140S
10 20 10
[254] [508] [254]
A1 A3 A5 A7
LEGEND
1 CONDENSER FAN CIRCUIT-1
CIRCUIT-2
2 CONDENSER COIL
CIRCUIT-3
3 CONTROL PANEL CIRCUIT-4
4 TANDEM COMPRESSOR
FILTERED
LIQUID VENTILATION
1 1/8[29]x 4Nos. ON BOTH SIDES
106.91
[2715]
[2420]
95.28
DETACHABLE
PLATE FOR
CABLE ENTRY
[750]
29.5
4
SUCTION RIGGING HOLES
[150]
5.91
23
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
LOADING POINTS - 50Hz
LOADING POINTS TOTAL
ACUV UNIT
A1 A2 A3 A4 A5 A6 A7 A8 WEIGHT
Ib. 781 1019 1200 1019 942 1180 - - 6139
53064-S
Kg. 354 462 544 462 427 535 - - 2784
Ib. 805 1094 1316 1094 968 1257 - - 6533
53071-S
Kg. 365 496 597 496 439 570 - - 2963
Ib. 838 1127 1349 1127 999 1288 - - 6727
53079-S
Kg. 380 511 612 511 453 584 - - 3051
Ib. 838 1127 1349 1127 999 1288 - - 6727
53084-S
Kg. 380 511 612 511 453 584 - - 3051
Ib. 838 1127 1349 1127 999 1288 - - 6727
53086-S
Kg. 380 511 612 511 453 584 - - 3051
Ib. 1111 882 875 1116 1111 882 1036 1279 8293
54095-S
Kg. 504 400 397 506 504 400 470 580 3761
Ib. 1144 913 908 1149 1144 913 1069 1310 8551
54106-S
Kg. 519 414 412 521 519 414 485 594 3878
Ib. 1144 913 908 1149 1144 913 1069 1310 8551
54111-S
Kg. 519 414 412 521 519 414 485 594 3878
Ib. 1144 913 908 1149 1144 913 1069 1310 8551
54118-S
Kg. 519 414 412 521 519 414 485 594 3878
Table 14
24
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
Location and Space Requirements ACUV A B C
51008-S 61009-S
Due to the vertical air flow discharge condenser design, it is recommended 42
that certain precautions are to be taken before installation. There should 51010-S 61011-S
be no obstruction on the air flow. 51013-S 61016-S
40 60
52015-S 62018-S
Orient the unit so that prevailing winds blow parallel to the unit length 51016-S 61018-S 50
thus minimizing the effects on condensing pressure. If it is not practical 52017-S 62020-S
to orient the unit in this manner, a wind deflecting shield should be
52019-S 62022-S
considered.
52022-S 62026-S 56
It is also necessary to provide adequate clearance on all sides of the unit 52025-S 62030-S 48 72
for service access and satisfactory performance. This will prevent excessive 52028-S 62033-S
66
condensing temperatures and enhance system performance and operating 52030-S 62036-S
economy. 52036-S 62043-S
64 96
52043-S 62051-S
A flat concrete foundation or floor which can support the weight of the
52048-S 62058-S
equipment must be provided as the unit must be level for proper operation 78
and functioning of controls. 52053-S 62063-S 72 108
52060-S 62071-S
Under certain critical conditions it is recommended that vibration isolators 53064-S 63076-S
of rubber-in-shear or spring type be installed under the base. 53071-S 63085-S
53079-S 63094-S
The isolators must be designed for the operating weight of the unit. For
53084-S 63100-S
operating load points refer to Loading Points Data (page No.23 & 24).
53086-S 63102-S 84 46 90
Correct selection of types of isolators depends upon application and
structure. 54095-S 64113-S
54106-S 64126-S
54111-S 64132-S
54118-S 64140-S
Table 16
*
A
B
A
A
*
A
B
B *
A
A
*
C
C
A
B
*
ACUV-51008S to 52060S A
ACUV-61009S to 62071S
ACUV-53064S to 54118S
ACUV-63076S to 64140S
26
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
Typical Refrigeration Piping
1
Legend 2
3
AIR
1. Expansion Valve 4
FLOW
5
2. Sight Glass AHU
3. Solenoid Valve
4. Filter Drier
5. Shut Off Valve
CONDENSING
UNIT
6
6. Liquid Line
7. Suction Line
1
2 7
7
3
AHU CONDENSING
similar. UNIT
DOTTED IN CASE OF
LEGEND
DOUBLE SUCTION RISER
1 EXPANSION VALVE
2 SIGHT GLASS
3 SOLENOID VALVE
4 FILTER DRIER
5 SHUT OFF VALVE
6 LIQUID LINE
7 SUCTION LINE
Refrigerant Piping
Correct design and size of refrigerant piping is necessary for c. Pressure drop due to vertical lift of liquid line for R-134a 1F
proper operation. The refrigerant piping generally should be (0.55C) sub cooling must be allowed for each 5.5 ft (1.7m)
designed to accomplish the following: vertical rise in order to avoid flash gas forming due to the weight
of the column of liquid refrigerant.
a. To ensure proper refrigerant feed to the evaporator.
b. To provide practical refrigerant line sizes without excessive SKM ACUV-S Series units are designed with a sub cooling circuit
pressure drop. enough to sub cool the liquid 12F (6.6 C), which gives the liquid
c. To maintain uniform return of lubricating oil to the maximum 66 ft. (20m) lift without additional sub cooling. Liquid
compressor. suction heat exchanger can be used for additional sub cooling
in order to avoid flash gas forming.
d. To prevent refrigerant from entering the compressor and
causing compressor damage due to "slugging".
27
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
Recommended Refrigerant Line Sizes - 50 Hz
SKM ACUV-S Series Condensing Units are designed for satisfactory operation with single suction line.
1. Suction Line sizing selection recommendation in Table 17 is based on 2F temperature drop.
2. Double suction risers, for applications with systems having large variations in capacity , are recommended to ensure proper
oil flow up and return to compressor.
3. Liquid line sizing selection recommendation in table 17 & 18 is based on 2F temperature drop.
4. Recommended line sizes in Table 17 are for guidance only. For detailed proper piping, consult recognized piping references
like ASHRAE Guide and Data Book for assistance.
5. Equivalent suction and liquid line lengths are shown in table 17 & 18.
SKM is not responsible for faulty or improper design or sizing of refrigerant lines. The above recommendations do not
incorporate necesarry slopes. etc. that may be required on horizontal risers, etc.
28
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
Recommended Refrigerant Line Sizes - 60 Hz
SKM ACUV-S Series Condensing Units are designed for satisfactory operation with single suction line.
1. Suction Line sizing selection recommendation in Table 18 is based on 2F temperature drop.
2. Double suction risers, for applications with systems having large variations in capacity , are recommended to ensure proper
oil flow up and return to compressor.
3. Liquid line sizing selection recommendation in table 18 is based on 2F temperature drop.
4. Recommended line sizes in Table 18 are for guidance only. For detailed proper piping, consult recognized piping references
like ASHRAE Guide and Data Book for assistance.
5. Equivalent suction and liquid line lengths are shown in table 17 &18.
SKM is not responsible for faulty or improper design or sizing of refrigerant lines. The above recommendations do not
incorporate necesarry slopes. etc. that may be required on horizontal risers, etc.
29
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
GUIDE SPECIFICATIONS
GENERAL FEATURES REFRIGERANT PIPING
Condensing units shall be composed of compressor(s), fan(s), The refrigerant circuit piping shall be fabricated from ACR grade
Coil(s), refrigerant piping, electrical components & enclosing copper piping, with 1, 2, 3, or 4 refrigeration circuits.The piping
cabinet in one piece. connections shall be terminated with sealed & soldered copper
pipe ends,which give much simplicity & ease to the installation.
Unit shall be factory assembled, internally wired, piping
connections terminated with sealed and soldered copper pipe
ends. Unit shall be shipped with nitrogen holding charge (actual
charging with refrigerant R-134a should be done at site). Unit CASING
shall be capable to operate from 50F (10C) to 125F (52C)
ambient temperature and shall be rated in accordance with Unit casing shall be made of zinc coated galvanized steel
AHRI-365 standard. sheets conforming to JIS-G3302 and ASTM A653 which shall
be phosphatized and then electrostatically dry powder coated
of approx.60 microns to provide an extremely tough, scratch
COIL(S) resistance, excellent anti-corrosive protection that can pass
1000 hrs in 5% salt spray testing at 95F (35C) and 95% relative
Coil shall be air cooled with integral sub-cooling circuit, constructed humidity as per ASTM B117.
of seamless copper tubes 3/8" OD mechanically bonded to Unit casing shall be provided with access panels for easy service
wavy Aluminium (Copper) fins with maximum14 FPI (1.8mm) and maintenance of all units parts.
spacing. Coil shall be tested against leakage by pressurizing
air at 450 psig (3100 kPa) in coil, under water, cleaned and
dehydrated at the factory.
CONTROL PANEL
COMPRESSOR(S) The unit mounted control panel enclosure shall be fabricated out
of heavy gauge sheet steel in phosphatized powder coated baked
finish. The enclosure shall conform to IP54 as per guidelines in
Compressor shall be hermetic scroll, refrigerant gas cooled IEC 529. A hinged access door and key-fastener shall be provided
furnished with internal overload protection device, crankcase for easy access and security. The panel shall be factory wired in
heater, and shall be mounted on rubber isolators. accordance with NEC 430 & 440, labeled, tagged and features
220V / 240V controls and shall include the following as minimum.
30
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
GUIDE SPECIFICATIONS
MICROPROCESSOR CONTROLLER DISPLAY INFORMATION
Condensing units shall be equipped with a full function Condensing units shall offer an LCD display which will allow
microprocessor based controller as a standard feature. The the operator to access different parameters of the unit. Operator
controller shall be factory programmed for the control of AHU shall be able to view and change the unit parameters. The display
fan motor, compressors and condenser fans. The controller information shall include:
shall come with a built in keypad and display for simple but
meaningful man machine interface. This controller shall provide Status
complete operational control for the unit and shall have built-in Outputs
auto diagnostic capability that can signal normal operation or Inputs
alarm conditions as well as shutting down the unit or system if Alarms
necessary. Set points
Password
The controller shall come with a loose supplied sleek and
elegant design room unit for installing in the conditioned space.
Communication between unit controller and room unit shall The intelligent microprocessor based controller shall monitor all the
be through two wire interface. The communication cable shall safeties related to the unit and makes the necessary protections, by
be 2 core, twisted pair, unscreened with stranded conductors. shutting down the entire unit or the effected circuit. The protections
Maximum distance between room unit and controller shall be 700 shall include:
meters. The room unit shall have a built in sensor for measuring
the room temperature. It shall transmit room temperature, set Low suction pressure.
point, unit operating mode, operating schedule etc. to the unit High discharge pressure.
controller. Control of the compressors shall be based on room High compressor motor temperature.
temperature and the set point, as standard. Control based on Compressor short cycling.
duct temperature shall be available if required.
Volt free contacts for run status, common fault status, auto mode
status and provision for remote on/off shall be available as option.
The Main Features of the controller shall be as follows:
In addition, the unit microprocessor shall be able to support the
Built in LCD display with back light. major BMS protocols such as BACnet, Modbus & LON as option
Built in keypad.
Battery backed up built in real time clock.
Multiple authorization level to provide tight security for the
control system.
Capacity control based on room temperature or return air
temperature.
Alarm history.
A sleek & elegant design room unit.
31
SKM Air Cooled Condensing Units
ACUV-S Series - R-134a
HEAD OFFICE
P.O Box: 6004
Sharjah, United Arab Emirates
Tel: +971 6 514 3333
Fax: +971 6 514 3300
Email: sales@skmaircon.com
Email: info@skmaircon.com
Service Centre
Email: aftersales.skm@skmaircon.com
REGIONAL OFFICES
United Arab Emirates
Abu Dhabi Dubai
P.O Box: 27788 P.O Box: 98822
Tel: +971 2 6445223 Tel: +971 4 2940900
Fax: +971 2 6445145 Fax: +971 4 2940029
Email: abudhabisales.skm@skmaircon.com Email: dubaisales.skm@skmaircon.com
Al Ain
Tel: +971 3 7619921 Kuwait
Fax: +971 3 7619941 Dasman
Email: alainsales.skm@skmaircon.com P.O Box: 1215-PC 15463
Tel: +965 2 2492200
Saudi Arabia (Production Facility) Fax: +965 2 2494400
Email: kuwaitsales.skm@skmaircon.com
SKM Air Conditioning Factory
Eastern province
AD Dammam Algeria
2nd industrial city Aissat Idir ( EX-ENMA) City
Abqiq main road Hail Street Bldg1, Flat 2, Dar El Beida Algiers
Tel: +966 3 8123332 / 4 / 5 Tel: +213 21 508197
Fax: +966 3 8123337 / +966 3 8123092 Fax: +213 21 508197
Email: saudifactory.skm@skmaircon.com Email: algeriasales.skm@skmaircon.com
32 067/2014 A
Supersedes # 067/2014