Beruflich Dokumente
Kultur Dokumente
61SiCr7 All
General Information
61SiCr7 is a Silicon Manganese alloy steel mainly used for heavy duty springs, but also used for tooling where impact resistance is of importance.
As-quenched hardness is expected to fall within a range of about 58 - 63 HRC. Hardenability is considered fairly high.
Similar designations
1.7108, 60SiCr7 DIN 17221, 9260H, ASTM 9260, SB9064 - 61Si7 EN10027
Chemical composition
Variant Cast Weldability C% Si % Mn % P% S% Cr %
CEV 0.83max Min 0.57 1.60 0.70 - - 0.20
61SiCr7 EN10089:2002 CC
Pcm 0.74max Max 0.65 2.00 1.00 0.025 0.025 0.45
Mechanical Properties
Variant
Rp0.2 * Reh, ** Rel
Transformation temperatures
Temperature C
MS 238
AC1 772
AC3 814
Tempering +QO Tempering at min.150oC immediately after the temperature after hardening has reached 40 -50oC In air
Hardenability
70
65
60
Hardness [HB]
55
50
45
40
35
30
10 20 30 40 50
Distance [mm]
61SiCr7 EN10089:2002
Contact us
Would you like to know more about our offers? Dont hesitate to contact us:
Via e-mail: info@ovako.com
Via telephone: +46 8 622 1300
For more detailed information please visit http://www.ovako.com/en/Contact-Ovako/
Disclaimer
The information in this document is for illustrative purposes only. The data and examples are only general recommendations and not a warranty or a guarantee.
The suitability of a product for a specific application can be confirmed only by Ovako once given the actual conditions.The purchaser of an Ovako product has
the responsibility to ascertain and control the applicability of the products before using them. Continuous development may necessitate changes in technical
data without notice. This document is only valid for Ovako material. Other material, covering the same international specifications, does not necessarily comply
with the properties presented in this document.