Beruflich Dokumente
Kultur Dokumente
Intel
Operation guide
Al - customer line
ATS - automatic exchange
TA - telephone set
PDSV - detachable device for call signal duplication
1. General guidelines
Device (further in the text as PDSV) is designed for incoming telephone call signal
duplication.
2. Safety measures
During PDSV installation observe all the safety measures required for working with
voltage 220V. Connection of PDSV to ATS customer line and TA, as well as connection of
external calling device should be performed only when power is disconnected.
3. Technical characteristics
220V, 6A
ATS line TA line
Figure 1.
5. Wiring diagram
Fuses
220V, 6A TA line
ATS line
External calling device line
Relay
Figure 2.
6. Order of connection
PDSV is designed for wall mounting and is connected to customer line leading to
telephone set.
To connect PDSV you should unscrew two screws on the bottom of it and remove the
cover plate.
Disconnect the customer line from your telephone set and plug into ATS line jack (see
wiring diagram). Connect PDSV and your telephone set with loop extender of adequate length
with fork ends TP-6P4C (RJ-11).
Install the external calling device in a chosen place and connect it to PDSV with D cable
that has double insulation.
Connect the plug to PDSV 220V power line inputs using D cable. Cable length should be
sufficient for connection to the mains socket 220V, that should be installed in advance close to
PDSV location.
Replace the PDSV cover and fix it with two available screws.
Fix PDSV on the surface using two holes in its housing.
Check for fastening security of all PDSV elements and for breaks in cable insulation.
Connect plug to 220V power line.
Check for operability of PDSV and external calling device.
7. Acceptance certificate
__ _______________
(QC department stamp)
-4-
Address of manufacturer:
8. Manufacturer's warranty
Manufacturer guarantees the adequacy of detachable device for call signal duplication
upon condition of transport and storage conditions observance by customer.
Guarantee period is 12 months starting with date of sale.
Detachable devices for call signal duplication can be transported by all modes of
transportation and stored by temperature from minus 40 to +45C if they are protected from
mechanical damage and atmospheric condensation.