Beruflich Dokumente
Kultur Dokumente
1. The two parallel and coplanar shafts are connected by gears having teeth parallel to the axis of the
shaft. This arrangement is called
(a) spur gearing (b) helical gearing (c) bevel gearing (d) spiral gearing
2. The type of gears used to connect two non-parallel non-intersecting shafts are
(a) spur gears (b) helical gears (c) spiral gears (d) none of these
3. An imaginary circle which by pure rolling action, gives the same motion as the actual gear, is called
(a) addendum circle (b) dedendum circle (c) pitch circle (d) clearance circle
5. The radial distance of a tooth from the pitch circle to the bottom of the tooth, is called
(a) dedendum (b) addendum (c) clearance (d) working depth
9. If the module of a gear be m, the number of teeth T and pitch circle diameter D, then
(a) m = D/T (b) D = T/m (c) m = D/2T (d) none of these
15. The maximum length of arc of contact for two mating gears, in order to avoid interference, is
(a) (r + R) sin (b) (r + R) cos (c) (r + R) tan (d) none of these
where r = Pitch circle radius of pinion, R = Pitch circle radius of driver, and Pressure angle.
16. When the addenda on pinion and wheel is such that the path of approach and path of recess are half of their maximum
possible values, then the length of the path of contact is given by
18. The ratio of face width to transverse pitch of a helical gear with as the helix angle is normally
(a) more than 1.15/tan (b) more than 1.05/tan
(c) more than 1/tan (d) none of these
20. For a speed ratio of 100, smallest gear box is obtained by using
(a) a pair of spur gears
(b) a pair of helical and a pair of spur gear compounded
(c) a pair of bevel and a pair of spur gear compounded
(d) a pair of helical and a pair of worm gear compounded