Beruflich Dokumente
Kultur Dokumente
In this post I will configure my lab to use frame relay in a point to point configuration.
Below is a diagram of the lab I will be using.
R0
R0#configure terminal
Enter configuration commands, one per line. End with CNTL/Z.
R0(config)#interface serial 0/0
R0(config-if)#encapsulation frame-relay
R0(config-if)#exit
1
R0(config-subif)#frame-relay interface-dlci 101
R0(config-fr-dlci)#exit
R0(config-subif)#exit
R1
R1(config)#interface serial 0/0
R1(config-if)#encapsulation frame-relay
R1(config-if)#exit
R2
2
R2(config)#interface serial 0/0
R2(config-if)#no shutdown
Show Commands
R2#show frame-relay pvc
PVC Statistics for interface Serial0/0 (Frame Relay DTE)
3
Num Status Enq. Sent 25 Num Status msgs Rcvd 26
Num Update Status Rcvd 0 Num Status Timeouts 0
Last Full Status Req 00:00:56 Last Full Status Rcvd 00:00:56
After configuring frame relay I am able to ping routers on the same network but not the
other networks, so currently R2 cannot talk to R1.
R2#ping 192.168.1.1
Type escape sequence to abort.
Sending 5, 100-byte ICMP Echos to 192.168.1.1, timeout is 2
seconds:
.....
Success rate is 0 percent (0/5)
R2#sh ip route
Codes: C - connected, S - static, R - RIP, M - mobile, B - BGP
D - EIGRP, EX - EIGRP external, O - OSPF, IA - OSPF inter area
N1 - OSPF NSSA external type 1, N2 - OSPF NSSA external type 2
E1 - OSPF external type 1, E2 - OSPF external type 2
i - IS-IS, su - IS-IS summary, L1 - IS-IS level-1, L2 - IS-IS
level-2
ia - IS-IS inter area, * - candidate default, U - per-user
static route
o - ODR, P - periodic downloaded static route
Gateway of last resort is not set
4
C 192.168.2.0/24 is directly connected, Serial0/0.300
To fix this problem I enable EIGRP on all my routers using the config below.
R2#conf t
Enter configuration commands, one per line. End with CNTL/Z.
R2(config)#router eigrp 10
R2(config-router)#network 192.168.0.0 0.0.255.255
R2(config-router)#end
R2#show ip route
Codes: C - connected, S - static, R - RIP, M - mobile, B - BGP
D - EIGRP, EX - EIGRP external, O - OSPF, IA - OSPF inter area
N1 - OSPF NSSA external type 1, N2 - OSPF NSSA external type 2
E1 - OSPF external type 1, E2 - OSPF external type 2
i - IS-IS, su - IS-IS summary, L1 - IS-IS level-1, L2 - IS-IS
level-2
ia - IS-IS inter area, * - candidate default, U - per-user
static route
o - ODR, P - periodic downloaded static route
Gateway of last resort is not set
D 192.168.1.0/24 [90/2681856] via 192.168.2.1, 00:01:20,
Serial0/0.300
C 192.168.2.0/24 is directly connected, Serial0/0.300