Beruflich Dokumente
Kultur Dokumente
PIONEERPRO
CONCRETE EPOXY 10HV
PRODUCT DESCRIPTION Table 2: Physical Properties: CURED STATE
PIONEERPRO CONCRETE EPOXY 10HV is a Parameters Results Remarks
thermosetting type of concrete adhesive specially Tensile Strength 3,000 500psi ASTM 638
designed to have the following advantages: Flexural Strength 7,000 500psi ASTM D79
1. It cures on damp or dry conditions. Compressive Strength 8,500 500psi ASTM D695
2. No sagging when applied on vertical or slop- Hardness 80-90 Shore D
ing surfaces, up to 1/8 thick films. Shrinkage negligible
3. When cured, it exhibits tough, hard, durable
and infusible bond between concrete and Note: Two independent testing laboratories, U.P.
wood, metal, masonry or asbestos. Industrial Research Center and Philippine Rock
Laboratory, tested its binding and flexural strength
TYPICAL USES properties, respectively; U.P. Industrial Research
As an Epoxy Adhesive: Center binding test indicated that at 10,150 ft. lbs.
bending moment, cracks occurred on concrete outside
1. Bonding old concrete to freshly poured con- epoxy bindings. (Specimen: PIONEERPRO
crete topping, thus eliminating cold joints CONCRETE EPOXY 10HV joint concrete beam).
between old and new concrete.
2. Replaces cement in bonding pre-cast, con- Philippine Rock Laboratory tested for the
crete structural units such as concrete de- suitability of PIONEERPRO CONCRETE EPOXY
cors under damp or dry conditions. 10HV as a bonding agent in concrete structures using
3. Bonding wood or metal to concrete surfaces their testing methods, results showed that the flexural
such as anchoring machinery to a concrete strength of PIONEERPRO CONCRETE EPOXY 10HV
floor. over concrete is superior, at 545 psi, concrete failed,
4. Anchoring and grouting concrete or ceramic away from the joint.
floor tiles over cement, wood or steel.
INSTRUCTION FOR USE
As an Epoxy Mortar: SURFACE PREPARATION:
1. Patching spalled and damaged areas in Concrete surface must be free of dirt, paint, oil grease,
concrete structures. lose materials and other contaminants. On oil
As a tack coat or primer before pouring surfaces, wash with soap and water or acid etching
fresh concrete topping when bringing low (10% muriatic acid or hydrochloric acid) is
areas to proper grade. recommended.
HEALTH PRECAUTIONS:
PACKAGING
PIONEERPRO CONCRETE EPOXY 10HV is
available in gallon and quart can sets.