Beruflich Dokumente
Kultur Dokumente
W2003778
Contents
Special Tools, page 2
MID 128 Engine Control Module, Fault Codes, page 3
Fault Code Table, page 3
FMI Codes, page 5
PV776-89057972
USA53530 English
Printed in USA
Volvo Trucks North America Date Group No. Release Page
Service Bulletin 5.2012 284 05 2( 6 )
Tools
Special Tools
The following special tools are used with VCADS Pro to diagnose engine faults. For special
tools ordering instructions, refer to tool information in group 08.
J-39200
Multimeter
Volvo Trucks North America Date Group No. Release Page
Service Bulletin 5.2012 284 05 3( 6 )
Troubleshooting
MID 128 Engine Control Module, Fault Codes
See also:
You must read and understand the precautions and
Fault Codes, EECU, MID 128, page 1 guidelines in Service Information, group 20, "General
Diagnostic Information, group 28 Safety Practices, Engine" before performing any fault
tracing. If you are not properly trained and certified in
this procedure, ask your supervisor for training before
you perform it.
Definitions
MID Message Identification Description (identification SID Subsystem Identification Description (identification
of ECU) of component)
PID Parameter Identification Description (identification PSID Proprietary Subsystem Identification Description
of parameter (value)) (Volvo-unique identification of component)
PPID Proprietary Parameter Identification Description FMI Failure Mode Identifier (identification of fault type);
(Volvo-unique identification of parameter (value)) see also FMI Codes, page 5
FMI Codes
SAE Standard
FMI Display text SAE text
0 Too high value Data valid, but above normal work range
1 Too low value Data valid, but below normal work range
2 Incorrect data Data erratic, intermittent, or incorrect
3 Electrical fault Voltage above normal or shorted high
4 Electrical fault Voltage below normal or shorted low
5 Electrical fault Current below normal or open circuit
6 Electrical fault Current above normal or grounded circuit
7 Mechanical fault Mechanical system not responding properly
8 Mech. or electrical fault Abnormal frequency, pulse width, or period
9 Communication fault Abnormal update rate
10 Mech. or electrical fault Abnormal rate of change
11 Unknown fault Failure mode not identifiable
12 Component fault Bad intelligent device or component
13 Incorrect calibration Out of calibration
14 Unknown fault Special instructions
15 Unknown fault Reserved for future assignment by SAE Data Format Subcommittee
Freeze Frames
The information shown in the freeze frames panel of Example:
VCADS Pro is an overview of values when certain fault If the value is near the alarm limit for a while before the fault
codes become active. These values (before, during, and code becomes active, this may indicate contamination of
after the fault code appears) can be helpful to trace the certain filters or liquids.
problem.
If the value suddenly increases or decreases before the
Freeze frames are active only when a fault code indicating fault code becomes active, this may indicate an open circuit
a mechanical fault is set. Check the values that refer to or short circuit.
the fault code.
T2019376