Beruflich Dokumente
Kultur Dokumente
For quick and accurate measurement of resistivity of a sample of soil, water, or other electrolyte. For
use in the field or laboratory.
For quick and accurate measurement of resistivity of a sample of soil, water, or other electrolyte. For
use in the field or laboratory.
M. C. Miller soil boxes can be used to satisfy both the ASTM (G57) and AASHTO (T-288) Standard
methodologies. The M. C. Miller soil boxes have a 1cm multiplier value if used in the 4 electrode
configuration (ASTM Standard) and multiplier values of 0.67cm and 0.57cm for the small and large
boxes, respectively, in the case of the two electrode configuration (AASHTO Standard).
Megger.
Made of Plexiglass, with rounded corners for easy cleaning. orners - Rounded for easy cleaning
Inside Dimensions
Large:
1.5 wide by 8.75 long by 1.25 deep
3.937cm wide x 22.23cm long x 3.190cm deep
Small:
1.16 wide x 4.39 long x .94 deep
2.946cm wide x 11.15cm long x 2.3876 deep
Soil Resistivity:
The dimensions of each box and the pin spacings have been chosen so that the soil resistivity value (expressed in Ohm-centimeter), is the same as the
measured soil resistance value (in Ohms). When used with any MCM multi-combination meter (or separate volt and ammeter), and external battery, the
resistivity of the sample can be determined as follows:
RESISTIVITY = [(Change in Potential Between Pins, or Delta V) / (Change in Current, or Delta l)] x 1cm
Corrpro Companies
7000 B Hollister
Houston, TX 77040
Phone: 713-460-6000
Call: 1-866-CORRPRO
Aegion Corporation
Soil Box Test Leads:
Set consisits of four(4) 2-foot long cables:
2 Black
2 Red
Notes:
1. When using multimeters, be sure readings on both meters are obtained simultaneously.
2. Readings must be in volts and current must be in amps (or mV and mA) to obtain result in ohm-cm.
4. When used with the Miller 400A Resistance meter or Megger, no calculations are necessary because the multiplication factor is 1cm. Therefore, the resistivity value of the
sample can be read directly off the meter dial. Refer to the instruction sheet included with each meter for additional information.
Description
Specifications
Ordering Information
Corrpro Companies
7000 B Hollister
Houston, TX 77040
Phone: 713-460-6000
Call: 1-866-CORRPRO
Aegion Corporation