Beruflich Dokumente
Kultur Dokumente
SPLITTERS (PMR-CS)
PMR-CS-1
PMR-CS-5
PMR-CS-10
PMR-CS-20
PMR-CS-60
PMR-CS-120
DesignEngineerInstallMaintain PMR-CS-200
CONDENSATE Products Capacities
____________________
____________________
Modular Construction
Designation C after the model
number is for corrosive
environments.
www.proxionminirefineries.com
2
Process Description Standard Equipment
__________________________________________________________________________ _________________________
This PMR-CS is designed to separate the Condensate into several side cuts, an overhead Proxion Mini Refineries
and bottom stream. The streams will be cut according to the boiling points pre-determined to provides completely
meet the product specifications and standard. The design of the process will be to operate at assembled process modules
a continuous state to the capacity outlined in the scope of supply for 330 days per year while containing all the necessary
processing the condensate described in the assay provided. The plant will be modular and equipment, piping, electrical
skid mounted, incorporating the listed process equipment, piping, instrumentation and all and instrumentation compo-
electrical junction boxes located at the skid edge. The PMR-CS does not use steam for strip- nents.
ping, however steam stripping can be incorporated into the PMR-CS design as an add-on but
will be subject to design consideration and approval. On-Module equipment in-
cludes:
Condensate feedstock is delivered to the suction of the condensate charge pumps (by Buy- Heat Exchangers
ers pipeline) from the outside battery limits, at the required minimum flow and suction Furnace
(NPSH) as required by the pumps. The condensate charge pumps, then delivers the conden- Pumps (100% Spared)
sate to a pre-flash vessel where the light ends are flashed off and routed either to storage or Crude Tower
flare. The bottom liquid from the pre-flash vessel is delivered at the required pressure and Side Strippers (if
flow to the Atmospheric Distillation Column (ADU). The process in the column splits the con- necessary)
densate feed into the following products. Air Coolers
Accumulator Vessel
Naphtha Instrument Air
Kero/Jet Fuel Chemical Injection
Diesel Product Sample Cooling
Atmospheric Bottoms
The Process Control System,
The process is set up such that the side draw products will have a wide range of properties Safety Interlock System, and
(within limits) depending on the intended use. A side stream stripper might be envisaged for Motor Control Center is prefab-
the Naphtha, kerosene or diesel to remove the light ends from the products. The side stream ricated and installed on module.
strippers will be envisaged based on specification and intended use. The unit can be controlled
locally and/or from a remote
control room.
Additional draw offs can be added if required.
Addons
____________________
Desalter Modules
Extra Draws offs
Material upgrade for
corrosive crudes (C)
API Pumps
De-waxing units
Gasoline Upgrading
Desulpherization and
Merox units
www.proxionminirefineries.com
3
Manchester
__________________________
Trafford House
Chester Road, Manchester, UK
+44 (0) 161 8831706
info@proxionminirefineries.com
London
__________________________
100 Brompton Road
Knightsbridge, London, UK
+44 (0) 20 339 785 07
info@proxionminirefineries.com