Beruflich Dokumente
Kultur Dokumente
13 10:42 AM A
KHS1822 / CH1822
HIGH
EFFICIENCY
KHS1822
CH1822
SERVICE MANUAL
KHS1822 / CH1822
(Basic Information)
ii WM 700796
92-267 S/M (Basic) 00.12.13 10:42 AM iii
For safe installation and trouble-free operation, you must: In a Ceiling or Wall
Make sure the ceiling/wall is strong enough to hold the
Carefully read this instruction booklet before beginning
units weight. It may be necessary to construct a strong
Follow each installation or repair step exactly as shown wood or metal frame to provide added support.
Observe all local, state, and national electrical codes In a Room
Pay close attention to all warning and caution notices Properly insulate any tubing run inside a room to prevent
given in this manual sweating that can cause dripping and water damage to
walls and floors.
This symbol refers to a hazard or
WARNING: unsafe practice which can result In Moist or Uneven Locations
in severe personal injury or Use a raised concrete pad or concrete blocks to provide a
death. solid, level foundation for the outdoor unit. This prevents
water damage and abnormal vibration.
This symbol refers to a hazard or
CAUTION: unsafe practice which can result In an Area with High Winds
in personal injury or product or Securely anchor the outdoor unit down with bolts and a
property damage. metal frame. Provide a suitable air baffle.
If Necessary, Get Help In a Snowy Area (for Heat Pump-type Systems)
These instructions are all you need for most installation Install the outdoor unit on a raised platform that is higher
sites and maintenance conditions. If you require help for a than drifting snow. Provide snow vents.
special problem, contact our sales/service outlet or your
certified dealer for additional instructions. When Connecting Refrigerant Tubing
Do not supply power to the unit until all wiring and tub- When Servicing
ing are completed or reconnected and checked.
Turn the power OFF at the main power box (mains)
Highly dangerous electrical voltages are used in this sys- before opening the unit to check or repair electrical parts
tem. Carefully refer to the wiring diagram and these and wiring.
instructions when wiring. Improper connections and inad-
equate grounding can cause accidental injury or death. Keep your fingers and clothing away from any moving
parts.
Ground the unit following local electrical codes. Clean up the site after you finish, remembering to check
Connect all wiring tightly. Loose wiring may cause over- that no metal scraps or bits of wiring have been left
heating at connection points and a possible fire hazard. inside the unit being serviced.
iii WM 700796
92-267 S/M (Basic) 00.12.13 10:42 AM iv
Table of Contents
Page
1. OPERATING RANGE............................................................................................................................... 1
2. SPECIFICATIONS .................................................................................................................................... 2
Unit Specifications ....................................................................................................................................... 2
5. HEATING CAPACITY.............................................................................................................................. 6
7. ELECTRICAL DATA................................................................................................................................ 9
Electrical Characteristics ....................................................................................................................... 9
Electric Wiring Diagram........................................................................................................................ 10
iv WM 700796
92-267 S/M (Basic) 00.12.13 10:42 AM 1
1. OPERATING RANGE
KHS1822 / CH1822
1 WM 700796
92-267 S/M (Basic) 00.12.13 10:42 AM 2
2. SPECIFICATIONS
Unit Specifications
2 WM 700796
92-267 S/M (Basic) 00.12.13 10:42 AM 3
3. DIMENSIONAL DATA
14-3/16
38-31/32 7-25/32
Rear panel
(Center point of gravity)
Wireless remote
control unit
6-7/64
1-61/64
21-3/16 5-3/4
Air intake
12-3/12
13-1/4
Air
intake
2-3/8
3-3/4
3/4
3 WM 700796
92-267 S/M (Basic) 00.12.13 10:42 AM 4
4. COOLING CAPACITY
230V
KHS1822 / CH1822
4 WM 700796
92-267 S/M (Basic) 00.12.13 10:42 AM 5
208V
KHS1822 / CH1822
5 WM 700796
92-267 S/M (Basic) 00.12.13 10:42 AM 6
5. HEATING CAPACITY
eater
30,000
ph
ac k-u
with b
p
pum
at-
He
25,000
24,120
acity
p cap
-pum
eat
Heating Capacity (BTU/h)
20,000 H
18,000
15,000
10,000
5,000
17 23 32 41 47 50 59 68 75F
(8.3) (5) (0) (5) (8.3) (15) (20) (23.7C)
6 WM 700796
92-267 S/M (Basic) 00.12.13 10:42 AM 7
30,000
eater
-u ph
ack
hb
p wit
25,000
-p um
H eat
22,640
a city
cap
Heating Capacity (BTU/h)
mp
20,000
at-pu
He
17,600
15,000
10,000
5,000
17 23 32 41 47 50 59 68 75F
(8.3) (5) (0) (5) (8.3) (15) (20) (23.7C)
7 WM 700796
92-267 S/M (Basic) 00.12.13 10:42 AM 8
Cooling Cycle
Wide tube
Compressor
service Accumulator
Wide tube valve
Disharge pressure
O.D. regulator
5/8" P
(15.88 mm)
Muffler
4-way
Muffler valve
Heat exchanger
Heat exchanger
Capillary
Narrow tube
Modulator
service
Narrow tube valve
Capillary Check
O.D. port
1/4" ( )
(6.35 mm) Strainer
Check Drier
valve
Indoor unit Outdoor unit
Heating Cycle
Wide tube
Compressor
service Accumulator
Wide tube valve
Disharge pressure
O.D. regulator
5/8" P
(15.88 mm)
Muffler 4-way
valve
Muffler
Heat exchanger
Heat exchanger
Capillary
Narrow tube
Modulator
service
Narrow tube valve
Capillary Check
O.D. port
1/4" ( )
(6.35 mm) Strainer
Check Drier
valve
Indoor unit Outdoor unit
8 WM 700796
92-267 S/M (Basic) 00.12.13 10:42 AM 9
7. ELECTRICAL DATA
Electrical Characteristics
KHS1822 / CH1822
Performance at Indoor Unit Outdoor Unit Complete Unit
230/208V 1 60Hz Fan Motor Max. Heat Fan Motor Compressor Heat-pump Max. Heat
Rating A 0.40 / 0.40 0.47 / 0.47 7.13 / 7.73 8.0 / 8.6
Cooling
Conditions W 90 / 81 105 / 95 1,595 / 1,564 1,790 / 1,740
Rating A 0.40 / 0.40 7.8 / 7.1 0.47 / 0.47 7.13 / 7.73 8.0 / 8.6 15.8 / 15.7
Heating
Conditions W 90 / 81 1,800 / 1,470 105 / 95 1.595 / 1.574 1,790 / 1,750 3,590 / 3,220
Locked-Rotor Amperes A 0.45 / 0.40 0.71 / 0.64 52
Remarks: Rating conditions are:
Cooling: Outside air temperature 95F DB/75F WB
Indoor unit entering air temperature 80F DB/67F WB
Heating: Outside air temperature 47F DB/43F WB
Indoor unit entering air temperature 70F WB
9 WM 700796
92-267 S/M (Basic) 00.12.13 10:42 AM 10
(Room)
FROM OUTDOOR UNIT
(Coil)
2 WHT S P
3 ORG
BLK
BLK
BLK
BLK
4 YEL
Noise
WHT
WHT
BRN
BRN
filter 3 1 3 2 1 1 2 1 2
WHT
BLK
3 1 3 2 1 1 2 1 2
1 1
SEC
G SG-OUT 3P 2P 2P
2P
BLU 1 1 2P SUP TH1 TH2 2 2
2 2 HR
PRY
4 3 5 1 1
ORG
2P
RY CONTROLLER
2 1 6 2 2
2 2 2P
Heater H. THERMO Switch
2 2
LM
1 1
2P
relay assy
FM H M L LL 1 1
BLK
BLK
1 9
GRY
GRY
WHT
BLK
Connector
2 1
WHT
ORG
GRY
YEL
VLT
2 1 1 9
Connector
1 9 1 2
BLK
BLK
YEL 1 2
Connector 1 2
Thermostat
YEL Switch
Connector
GRY
GRY
1 2 assy
1 2 3 4 1 2
1 2 3 4 1 2
Receiver Louver
WHT
GRY
YEL
VLT
LM
RED
RED
assy motor
Thermo Thermostat
Capacitor
fuse
BRN FM
Heater assy Resistor
PNK GRN
Fan
motor G
10 WM 700796
92-267 S/M (Basic) 00.12.13 10:42 AM 11
2P HI
BLK
power supply
L H FM PRS
208/230 volt
CM
1 2 1 2
1 2 1 2
BLU
Power BLU
relay
Crank case
COM
heater Capacitor
BLU
WHT
GRY
BRN
PNK
YEL
Starting NC NO
relay
GRY 6 5 4 3 2 1 Connector
1
RED 6 5 4 3 2 1
WHT
GRY
BRN
PNK
YEL
2 3
WHT
C
BLK Compressor
CM FM
motor
R S Fan motor
BLK BLK BLK
Capacitor Capacitor
WHT WHT
11 WM 700796
92-267 S/M (Basic) 00.12.13 10:42 AM 12
CORPORATION
In Canada SANYO Canada Inc.: Toronto, Ont. M4H 1M6
H408/12M
1991/Nov./12M Printed in
Printed in U.S.A.
U.S.A.
WM 700796