Beruflich Dokumente
Kultur Dokumente
Explanation
Every production process involves a combination of 3 elements, i.e. man, material and machine. It is
not possible to make any part precisely to a given dimension. Even if by chance the part is made
exact it is possible to measure it accurately enough to prove it. If attempts are made to achieve
perfect size the cost of production will increase tremendously. Therefore, some permissible
variation has to be allowed.
Limits:
The dimension of a manufactured part can only be made to lie between max and min limits.
Tolerance:
The permissible variation in size or dimension is tolerance. The difference between the upper limit
and lower limit of a dimension represents the margin for variation and is called as tolerance zone.
Also it is the amount by which the amount is allowed to go away from accuracy without causing any
functional trouble when assembled.
2. Bilateral Tolerance:
The dimension of a part is allowed to vary on both the sides of basic size.
Terminologies:
Shaft: It not only refers to the diameter of circular shaft but also to any external dimension of a
component.
Hole: it not only refers to diameter of circular hole but also to any internal dimension of a
component.
Basic Size: it is the standard size of a part which refers to which the limits of variations of a size are
determined.
Actual Size: dimension as measured on manufactured part.
Zero Line: the straight line drawn to represent the basic size.
Deviation: The algebraic difference between the actual size and corresponding basic size.
Upper Deviation: The algebraic difference between max limit of size and corresponding basic size.
Lower Deviation: The algebraic difference between min limit of size and corresponding basic size.
Fundamental Deviation: it is that one of the 2 deviations either upper or lower which is the
nearest to the zero line for either hole or a shaft. For hole FD is denoted by capital letters A, B,
C.ZA, ZB, ZC, and for shaft by small letters a, b, c.za, zb, zc.
Tolerance Grade: is an indication of degree of accuracy of manufacture and is designated by IT
followed by a number. IT stands for international tolerance grade.
Fit: it the degree of tightness or looseness between 2 mating parts.
1. Clearance Fit: It is obtained when shaft is always smaller than hole.
2. Interference Fit: the minimum permissible diameter of the shaft is always greater than the
maximum allowable diameter of hole. Elastic strains are developed on the mating surfaces
during the process of assembly and prevent relative measurement of the mating part.
3. Transition Fit: it lies mid-way between clearance and interference fit.
Allowance: It is the term given to the minimum clearance called positive allowance or maximum
interference called negative clearance. Also it is the clearance or interference which gives the
tightest possible fit between the mating parts.
The Indian standard consists of 18 grades of fundamental tolerances or the grades of accuracy for
manufacture and 25 types of FD. The fundamentals tolerances are designated as IT01, IT0, IT1, IT2,
IT3.IT16.
And fundamental tolerances for holes are designated by
A,B,C,D,..ZA,ZB,ZC.
Similarly funadamental tolerances for shaft are designated by
A,b,c..za,zb,zc.
Innumerable fits ranging from external clearance to those of external interference can be obtained
by a suitable combination of FD and tolerance. Each of 25 holes have the choice of 18 tolerances. The
numerical values of standard tolerances are determined in terms of standard tolerance unit, i in
microns.
3
i = 0.45 D + 0.001 D M icrons
Analytic Keyword
Tolerance, bilateral, unilateral, allowance, metrology, interference fit, transition fit, IT grade.