Beruflich Dokumente
Kultur Dokumente
(CLO3)
1. AIM
2. OBJECTIVES
3. EQUIPMENT
1. Oscilloscope.
2. Function generator(FG).
3. Multimeter.
4. DC power supply.
5. Project Breadboard.
6. Resistor ok 1K Ohm and 100K Ohm.
7. Diode 1N4001.
8. Capacitor.
9. Connection Wires and coaxial probes.
4.0 PROCEDURERS
1. Use IN4001 Si Diode and constructed the circuit shown in Figure 4.2(a)
3. ON the function generator, then 8VP-P was setup the source voltage and
sinusoidal is 100Hz.
4. Measured and recorded the VS from CH1 and VO from CH2 in table 4.1.
5. In table 4.1 sketched output of CH2 on the respective grids. (Note: input
coupling switch of the oscilloscope was set up to DC coupling mode)
6. Function generator was in OFF condition and the DC power supply was
insert as shown in figure 4.2(b)
1. Figure 4..3(a) show the construct circuit using by reversing the diode of
the previous circuit
2. The VS from CH1 and VO from CH2 was recorded and measured by using
Oscilloscope.
3. Table 4.2 was sketch the output of CH2 on the respective grids (Noted:
Set the input coupling and oscilloscope were in OFF situation to the DC
coupling mode)
4. The function generator were in OFF condition and DC power supply was
insert.
5. The DC power supply and function generator was ON and insert DC
voltage to 2V. Then repeated step 2.
6. DC power supply and function generator was switched OFF ,after
finished.
B-1 diode clamper (positive clamper)
QUESTION
1. Refer to the output waveform obtained from circuit in Figure
4.2(a) and 4.3(a). Discuss the difference between the two output
in terms of diode biasing.