Beruflich Dokumente
Kultur Dokumente
Semana 10
Ejercicio 1
For the beam and loading shown, consider section n-n and determine a) the
largest shearing stress in that section, b) the shearing stress at point a.
Ejercicio 2
A timber beam AB of length L and
rectangular cross section carries a
uniformly distributed load w and is
supported as shown. a) Show that the ratio
m/m of the maximum values of the
shearing and normal stresses in the beam
is equal to 2h/L , where h and L are,
respectively, the depth and the length of
the beam. b) Determine the depth h and the width b of the beam, knowing that
L = 5m , w = 8 kN/m , m = 1.08 MP a , and m = 12 MP a.
Ejercicio 5.
Determine the maximum shear stress in
the T-beam at section C. Show the result
on a volume element at this point.
Respuesta: Mx = 3, 67 MP a
Ejercicio 6.
The beam is subjected to a shear of V = 2 kN.
Determine the average shear stress developed in
each nail if the nails are spaced 75 mm apart on
each side of the beam. Each nail has a diameter
of 4 mm.
.
Respuesta: n = 35, 2 MP a
Ejercicio 7
La viga mostrada en la
figura tiene una seccin
transversal como la
mostrada en la figura.
Determine los esfuerzos
mximos por flexin a
tensin y compresin en
la viga.
Ejercicio 8
Una viga de madera se fabric de una pieza de
madera de 28 in y dos piezas de madera de 2x6 in
para formar la seccin transversal mostrada en la
figura. Los patines de la viga estn unidos al alma
con clavos que pueden transmitir confiablemente
una fuerza cortante de 100 lb. Si la viga est
simplemente apoyada y soporta una carga de 1 000
lb en el centro del claro de 12 ft, determine: a) la
fuerza cortante transferida por los clavos del patn al
alma en una longitud de la viga de 12 in. b) La
separacin requerida entre los clavos.