Sie sind auf Seite 1von 1

The objective of the experiment was to study the voltage and current of -Y connection.

We also try
to learn about the transformer exciting currents, voltampere capacity and the short circuit current.
With this we will able to find the relations between line to line parameters and phase parameters.
Based on the theory, the star connection has 3 phase that is Ac circuit, line voltage equal to 1.732
times of the phase voltage and the line current equal to the phase current. (V L= 3 V Ph; , I Line=I Ph
). As for the Delta connection, it also has 3 phases that is delta connection line current equal to 1.732 times of
the phase current and line voltage is equal to phase voltage. (I L= 3 I Ph; , V Line= V Ph ).

The experiment was begin with the start connection being connect to the voltmeters and ammeters and the
reading is recorded in the table. Then same steps is repeated for the delta connection. Based on the data table
for the delta connection of resistor, the voltage line to line result has differences for each line. This is because
some line has problem with the neutral connection that result to data. The conductor current, phase voltage
and phase current one after another reading also was affected by the neutral connection that either the line
was connected to the earth connection or not. The data that was obtained can be related to the theory as it
achieved the theory concept. The power for each line is calculated and the total Power is calculated by using
the equation given.

However, there were several problems while we conduct the experiment. The voltmeter and the ammeter
reading wasnt placed properly inside its position, thus the accurate reading cannot be determine properly.

Das könnte Ihnen auch gefallen