Beruflich Dokumente
Kultur Dokumente
Facility
A A
Beam
36ft
Girder
6.5ft 26ft
Metal Deck
Criteria: Methodology:
To be able to carry construction deal and From VULCRAFT
live loads and resist large deflections Lightweight concrete, slab depth, clear span
to carry load
Constraints:
AISC Specification Section I1.3, I3.2c and Design Decision:
I8 1.5VL22
Beams
Criteria:
Carry dead and Live Loads
Assumptions:
Simply Supported
36ft
fc=4ksi
A-A
Beams
Methodology: Available Flexural Strength
Pre Compostie Condition Compression Block Depth
Calculated Flexural Strength based on LRFD AISC Manual Table 3-19
Selected beam based on AISC Manual Table 3-2
Number and Spacing of Anchors
Composite Condition Shear Studs
Calculated Required Flexural Strength Depends on kips/anchor and composite load
Effective width of concrete
Check Shear Strength
Beams
Design Decisions:
Based on Calculations and loads
Large loads pick a beam one size bigger
than what was calculated
Design for worst case scenario
Girders
Criteria:
Carry dead and Live Loads
Assumptions:
Simply Supported
fc=4ksi 26ft
Fy=50ksi
Cb=1.0
Unbraced length = *girder length
Girders
Methodology:
Pre Compostie Condition Available Flexural Strength
Calculated Flexural Strength based on LRFD Compression Block Depth
AISC MAnual Table 3-2: choose girder AISC Manual Table 3-19
Check the Flexural strength of beam selected
Number and Spacing of Anchors
Design Composite Section: AISC Specification Section I8.2A
Shear Studs
Calculated Required Flexural Strength
Effective width of concrete
Check Shear Strength
Girders
Design Decisions:
Based on Calculations and loads
Large loads pick a beam one size bigger
than what was calculated
Design for worst case scenario
Framing Plans
Second Floor Third Floor
Hanger
Design
Location
Steel Rod Pipe Tension
Connections
Bolt Type
All Bolts: ASTM A36
Bolts
5/16 Angle Thickness
N Thread Count
First Floor
Slab-On-Grade
Design
Slab Thickness = 6
Teel Fiber Reinforcement = 1 Cubic Yard
Sawcuts
Columns
Column
Design Criteria:
Methodology:
To be able to carry all loads and transfer
them into floor Sum all girder loads the column will carry
and treat as a point load
Calculate compressive strength
Assumptions:
Using KL=17ft, pick column from AISC
Both ends of column are pinned therefore
Manual Table 4-1
K=1
Calculate the y-y axis effective length
Choose column where available compressive
strength is bigger than required
51.5 ft
17ft
Shear Wall
Shear Wall
Design
Criteria
Location
Reinforcement
Foundation
Foundation
Design:
Criteria
Footing Dimensions
Reinforcement
Cost Analysis
Steel 90 tons
Concrete 2,000 CY
Description Cost
Metal $1,700,000
Concrete $850,000