Beruflich Dokumente
Kultur Dokumente
BOTTOM 1. F'F IP No marking of "left and right" on the IP mold. Add the marking of lett and right on the mold.
2. F'F O/S tip Color bleeding issue. Repair tip mold to make it 0.5mm deeper.
triangle(lat)
3. E/T shank Exposed line between thick and thin point area.(Design issue) Repair mold.(Add smooth taper to minimize the line)
exposed line
4. Heel counter Small gap between heel counter bottom & heel pu part. Repair PU mold to create 1:1 fit.
5. Duraron & Minor gap in the groove area. Recheck mold and update it if needed.
F'F IP fit
6. F'F IP & Visible parting line in the med side area.(doesn't look good) 1) Repair mold for model size trial.(to invisible look)
Heel PU parting 2) Move back the parting line by 3mm after model
trial.
line
7. Heel PU logo Bubble issue on the surface. Add radius a bit more and stir enough by hand.
8. Heel PU 1) Bubble issue on the bottom shank area. 1) Add radius a bit more on the mold.
bottom 2) Narrow margin on the lat bottom shank area. 2) Repair pu mold to get more margin.
Also, hand-cut the tpu edge margin as much as
repaired in pu mold for model trial.
OTHERS
A Maddie Max - KDC SP'05
6/18/03
HISTORY
Sample UPPER BOTTOM SCHEDULE
History Lasted Collar Sample Wear test
Revision SRF Crispin # Revision 2D (PDF) 3D Actual part 3D File #
Board Upper Height ETC ETC
Pre-MM
MM
Coreline
SS
KEY PERFORMANCE
Title Component Issues Action Plan ETC
UPPER
BOTTOM