1. A type of deliverability test conducted in gas wells to generate a stabilized gas
deliverability curve (IPR is 2. A technique for measuring the effect of pits and holes in the inner wall of a casing on a high-frequency electrical signal induced in the casing is 3. A vessel, with its cylindrical axes parallel to the ground, that is used to separate oil, gas and water from the produced stream is called 4. An artificial-lift system that operates using a downhole pump is called 5. A process used to remove hydrogen sulfide [H2S] and carbon dioxide [CO2] from a gas stream is 6. Name A type of streamlined flow for single-phase fluids in which the fluid moves in parallel layers 7. A vessel placed in a flowline through which liquids or gases are flowed to neutralize sudden pressure surges 8. A multiphase flow regime in pipes in which one fluid moves as small dispersed bubbles through a continuous fluid is 9. A multiphase flow regime in which the lighter fluid flows in the center of the pipe, and the heavier fluid is contained in a thin film on the pipe wall. 10. change in temperature observed when a gas expands while flowing through a restriction without any heat entering or leaving the system is phenomenon called 11. A tubular placed at the bottom of the subsurface sucker-rod pump and inside the gas anchor to drive the formation fluid with little or no gas into the pump is called 12. Mention three kind of well stimulation ? 13. Identify yhe classifications of produced hydrocaron liquids and their associated API gravity rankings. 14. What is the ratio of the mole fraction of a component in vapor phase to the mole fraction of the same component in liquid phase called? 15. A homogeneous gas reservoir that has been producing gas (but no water) yields the following plot. What causes the curve to deviate upwards? 16. name the two types of displacement in oil-well pumps 17. name four of the five types of reservoirs by fluid type. 18. Name the two-phase flow correlation that was developed for vertical, upward flow and recommeded only for near-vertical wellbores. 19. What is the primary function of solvent in the EOR process? 20. What equation represents Boyle's Law? 21. Flow after flow 22. Eddy-current measurement 23. Horizontal separator 24. Hydraulic pumping 25. Sweetening 26. Laminar flow 27. Surge Tank 28. Bubble flow 29. Annular flow 30. Joule thompsons effect 31. Mosquito Bill 32. Acidizing, explosive fracturing, hydraulic fracturing 33. Light: API>31.1 Medium: 22.3<API<31.1 Heavy: 10<API<22.3 Extra Heavy or Bitumen: API<10 34. K value 35. Water Influx 36. Positive, Dynamic 37. Black/dead/non-volatile oil reservoirs. Volatile/live oil reservoirs. Condensate reservoirs. Wet gas reservoirs. Dry gas reservoirs. 38. Hagedorn and Brown 39. Decreases the interfacial tension between the oil and the other phases 40. P1V1=P2V2