Beruflich Dokumente
Kultur Dokumente
Separately the body pit code inside the indoor machine(or whole
type)
3. INSTALLATION
BASIC ACCESSORIES
This Installation section explains how and where to connect this new air conditioner. Please read make sure all accessories are
included as shown below and read manual thoroughly. This Installation section is provided to assist the person knowledgeable in
air conditioner installation and should not be installed by anybody who is not thoroughly familiar with this type of installation.
Please contact a professional installer if necessary.
Outdoor Units
SEE OF REMOTE CONTROLLER
NOTE:
Above figure shows all indications for the purpose of explanation, but
practically only the pretinent .
The set RUN mode remains after the unit is OFF, and next time when "ON / OFF" button
Is pressed, the set mode remains the same.
Before installation:
Selection of installation positions for indoor unit
To be installed at the position where the air delivered from the unit can reach every corner of the room
Avoid to biockage the air inlet or outlet of the indoor nit
To avoid too much oil smoke or steam
Avoid possible generation infiow, lingering or leakage of flamm gasee
Avoid high-frequency facilities (such as high frequency arc welders etc.)
Not to install a fire alarm near the air outlet.
To avoid the places where acid solutions are frequently used
Attention:lf there are some additional function devices to install on the air conditioner,Besure add to the
installation space for the function devices
Table 1.2-1
Part No. Qt
No. Description
KF-23G/Ec KFR-23G/Ec KF-25G/Ec KFR-25G/Ec y
1 Louver 391190002 391190002 391190004 391190004 1
2 Swing Louver 100420009 100420009 100420009 100420009 10
3 Connecting rod 100420062 100420062 391200002 391200002 1
4 Outlet part 100090115 100090115 100090114 100090114 1
5 Display box cover 100410027 100410027 100410012 100410012 1
6 Display box 100410028 100410028 100410004 100410004 1
7 Fan Bearing 110010605 110010605 110010605 110010605 1
8 Ring of Bearing ------ ------ ------ ------
9 Base 391060100 391060100 391060105 391060105 1
10 Guide Water Board 391990109 391990109 391990110 391990110 1
11 Cross flow fan 100010001 100010001 100010019 100010019 1
12 Evaporator assembly 960900007 960900007 990112505 990112505 1
13 Electric heater ------ ------ ------ ------
14 Screw cover 109990239 109990239 109990086 109990086 3
15 Middle frame 100080004 100080004 100080014 100080014 1
16 Cold Catalyst 119990003 119990003 119990003 119990003 2
17 Air Filter 100190104 100190104 100190106 100190106 2
18 Front Panel 391022111 100070168 391022076 391022076 1
19 Middleframecoverplate 100080036 100080036 100080036 100080036 1
20 Insert Block 079990240 079990240 079990240 079990240 1
21 Copper pipeof sensor 079990030 079990030 079990030 079990030 1
Room temp. Sensor
22 100280105 100280105 100280105 100280105 1
Holder
23 Motor Clamp 100130024 100130024 100130024 100130024 1
24 Motor 030020115 030020115 030020169 030020169 1
25 Maintenance plate 109990090 109990090 109990090 109990090 1
26 Electric box cover 029994104 029994104 100100039 100100039 1
27 Transformer 030180061 030180061 030180013 030180013 1
343100021 343100021 343100021 343100021
343100022 343100022 343100022 343100022
28 Connecting Wire 1
343100023 343100023 343100023 343100023
343100024 343100024 343100024 343100024
29 Display lamp panel 331800142 331800005 331800011 331800012 1
30 Electric control plate 040010132 040010134 040010149 040010151 1
31 Room Temp. Sensor
049990012 049990012 049990012 049990012 1
32 Tube Temp. Sensor
33 Electric Box 100100010 100100010 100100010 100100010 1
34 Wire Clip 391110016 391110017 391110016 100430084 1
35 Power Cord 050010026 050010042 050010042 050010042 1
36 Terminal Board 030090004 030090005 030090004 030090005 1
37 Connecting Cable 342100026 342100030 050020005 050020014
38 Pipe Clamp 100430027 100430027 100430027 100430027 1
39 Screw 150010018 150010018 150010018 150010018 1
40 Wall-mounting frame 020100008 020100008 020100009 020100009 1
41 Step motor 320273001 320273001 030020401 030020401 1
42 Thermal insulation pipe 099990080 099990080 099990080 099990080 1
43 Remote controller 336815005 336825002 040080019 040080020 1
Table 1.2-2
Part No. Qt
No. Description
KF-32G/Ec KFR-32G/Ec y
1 Louver 391190004 391190004 1
2 Swing Louver 100420009 100420009 10
3 Connecting rod 391200002 391200002 1
4 Outlet part 100090114 100090114 1
5 Display box cover 100410013 100410013 1
6 Display box 100410005 100410005 1
7 Fan Bearing 110010605 110010605 1
8 Ring of Bearing ------ ------
9 Base 391060105 391060105 1
10 Guide Water Board 391990110 391990110 1
11 Cross flow fan 100010019 100010019 1
12 Evaporator assembly 972900514 972900514 1
13 Electric heater ------ ------
14 Screw cover 109990086 109990086 3
15 Middle frame 100080014 391070004 1
16 Cold Catalyst 119990003 119990003 2
17 Air Filter 100190106 100190106 2
18 Front Panel 100070046 391022076 1
19 Middleframecoverplate 100080036 100080036 1
20 Insert Block 079990240 079990240 1
21 Copper pipeof sensor 079990030 079990030 1
Room temp. Sensor
22 100280105 100280105 1
Holder
23 Motor Clamp 100130024 100130024 1
24 Motor 030020115 030020115 1
25 Maintenance plate 109990090 109990090 1
26 Electric box cover 100100039 100100039 1
27 Transformer 030180061 030180061 1
343100021 343100021
343100022 343100022
28 Connecting Wire 1
343100023 343100023
343100024 343100024
29 Display lamp panel 331800004 331800003 1
30 Electric control plate 040012590 040012592 1
31 Room Temp. Sensor
049990012 049990012 1
32 Tube Temp. Sensor
33 Electric Box 100100010 100100010 1
34 Wire Clip 391110016 391110018 1
35 Power Cord 050010026 050010027 1
36 Terminal Board 030090004 030090005 1
37 Connecting Cable 342100026 342100030
38 Pipe Clamp 100430027 100430027 1
39 Screw 150010018 150010018 1
40 Wall-mounting frame 020100009 020100009 1
41 Step motor 320273001 320273001 1
42 Thermal insulation pipe 099990080 099990080 1
43 Remote controller 336811005 336815006 1
KFR-23253235GW/A51GW/B series
4.2.1 Explosive view of indoor unit
18
41
17
16
15
14
19
20
13
12 22
23
11
24
10 25
9
26
8 27
7 28
6 29
30
31
32
4 33
3 34
2
35
1
40 39 38 37 36
4.2.2 Spare parts list of indoor unit
Table 2.2-1
Part No. Qt
No. Description
KF-23G/A KFR-23G/A KF-25G/A KFR-25G/A y
1 Louver A 391190015 391190015 100420083 100420083 1
2 Louver B 391190014 391190014 100420003 100420003 1
3 Swing Louver 391190016 391190016 100420007 100420007 12
4 Connecting rod 391200019 391200019 100420072 100420072 3
5 Outlet part 100090106 100090106 100090110 100090110 1
6 Left angle plate 100360005 100360005 100360001 100360001 1
7 Base 100060129 100060129 100060108 100060108 1
8 Cross flow fan 100010016 100010016 100010016 100010016 1
9 Fan Bearing 401000006 401000006 401000006 401000006 1
10 Evaporator assembly 990112508 990112508 972900499 972900499 1
11 Evaporator left fixed plate 109990237 109990237 029993988 029993988 1
12 Screw cover 391990094 391990094 109990023 109990023 2
13 Middle frame 100080015 100080015 391070007 391070007 1
14 Air Filter 100190112 100190112 100190127 100190127 2
15 Display box cover 100410020 100410020 100410009 100410009 1
16 Display lamp plate 331800023 331800023 331800004 337000041 1
17 Display box 100410019 100410019 100410001 100410001 1
18 Front Panel 100070037 391022223 391022026 391022026 1
19 Sponge bar ------ ------ 386100008 386100008
20 Connecting Cable 342100026 342100032 342100026 342100030 1
21 Power Cord 050010042 050010042 050010042 050010042 1
22 Middle frame coverplate 100430025 100430025 100430025 100430025 1
23 Room temp. Sensor Holder 109990109 109990109 109990109 109990109 1
24 Pipe Clamp 100430049 100430049 100430025 100430025 1
25 Evaporator right fixed plate 109990238 109990238 109990109 109990109 1
26 Motor platen 100130013 100130013 100130003 100130003 1
27 Motor 030020173 030020173 320204004 320204004 1
28 Electric box cover 391100011 391100011 391100011 391100011 1
29 Electric control plate 331100056 331300105 331200083 331400083 1
30 Transformer 030180059 030180059 321620014 321620014 1
31 Terminal Board 030090009 030090001 321000022 030090241 1
32 Electric box 100100019 100100019 391100011 391100011 1
33 Screw 150010058 150010058 150010058 150010058 2
34 Wire Clip 100430050 100430050 391110057 391110057 1
35 Right angle plate 100300013 100300013 100300003 100300003 1
36 Wall-mounting frame 020100002 020100002 020100010 020100010 1
37 Step motor 320273001 320273001 320273001 320273001 1
38 Step Motor plate 391200020 391200020 391200050 391200050 1
39 Crank connecting rod 391200019 391200019 100420082 100420082 1
40 Thermal insulation pipe 099990080 099990080 099990080 099990080 1
41 Remote controller 336821005 336815006 336821050 336821049 1
Table 2.2-2
Part No. Qt
No. Description
KF-32G/A KFR-32G/A KF-35G/A KFR-35G/A y
1 Louver A 100420083 100420083 100420083 100420083 1
2 Louver B 100420003 100420003 100420003 100420003 1
3 Swing Louver 100420007 100420007 100420007 100420007 12
4 Connecting rod 100420072 100420072 100420072 100420072 3
5 Outlet part 100090110 100090110 100090110 100090110 1
6 Left angle plate 100360001 100360001 100360001 100360001 1
7 Base 100060108 100060108 391060127 391060127 1
8 Cross flow fan 100010026 100010026 100010016 100010016 1
9 Fan Bearing 401000007 401000007 401000007 401000007 1
10 Evaporator assembly 972900477 972900477 972900977 972900977 1
11 Evaporator left fixed plate 029993988 029993988 029993926 029993926 1
12 Screw cover 109990023 109990023 109990023 109990023 2
13 Middle frame 391070007 391070007 100080022 100080022 1
14 Air Filter 100190127 100190127 100190127 100190127 2
15 Display box cover 100410009 100410009 100410009 100410009 1
16 Display lamp plate 331800004 337000041 331800004 337000041 1
17 Display box 100410001 100410001 100410001 100410001 1
18 Front Panel 391022026 391022026 391022026 391022026 1
19 Sponge bar 386100008 386100008 386100008 386100008
20 Connecting Cable 342100026 342100030 342100028 342100034 1
21 Power Cord 050010042 050010042 050010027 050010027 1
22 Middle frame coverplate 100430025 100430025 100080034 100080034 1
23 Room temp. Sensor Holder 109990109 109990109 100280105 100280105 1
24 Pipe Clamp 100430025 100430025 100430025 100430025 1
25 Evaporator right fixed plate 109990109 109990109 029993926 029993926 1
26 Motor platen 100130003 100130003 391990210 391990210 1
27 Motor 320204004 320204004 030020173 030020173 1
28 Electric box cover 391100011 391100011 100100041 100100041 1
29 Electric control plate 331200083 331400083 040010178 040010179 1
30 Transformer 321620014 321620014 030180061 030180061 1
31 Terminal Board 321000022 030090241 030090004 030090005 1
32 Electric box 391100011 391100011 100100035 100100035 1
33 Screw 150010058 150010058 150010058 150010058 2
34 Wire Clip 391110057 391110057 391110017 391110017 1
35 Right angle plate 100300003 100300003 100300003 100300003 1
36 Wall-mounting frame 020100010 020100010 020100010 020100010 1
37 Step motor 320273001 320273001 320273001 320273001 1
38 Step Motor plate 391200050 391200050 100420002 100420002 1
39 Crank connecting rod 100420082 100420082 100420082 100420082 1
40 Thermal insulation pipe 099990080 099990080 099990080 099990080 1
41 Remote controller 336821050 336821049 336811005 336811006 1
Table 2.2-3
Part No. Qt
No. Description
KF-51G/B KFR-51G/B y
1 Louver A 100420088 100420088 1
2 Louver B 100420087 100420087 1
3 Swing Louver 100420007 100420007 12
4 Connecting rod 100420048 100420048 3
5 Outlet part 100090129 100090129 1
6 Left angle plate 100360002 100360002 1
7 Base 100060138 100060138 1
8 Cross flow fan 391050015 391050015 1
9 Fan Bearing 401000007 401000007 1
10 Evaporator assembly 960400217 960400217 1
11 Evaporator left fixed plate 029993926 029993926 1
12 Screw cover 109995908 109995908 2
13 Middle frame 100080012 100080012 1
14 Air Filter 100190139 100190139 2
15 Display box cover 100410009 100410009 1
16 Display lamp plate 331800004 337000041 1
17 Display box 100410001 100410001 1
18 Front Panel 391022150 391022150 1
19 Sponge bar 386100031 386100031
20 Connecting Cable 050020015 342200038 1
21 Power Cord 050010027 050010027 1
22 Middle frame coverplate 100080034 100080034 1
23 Room temp. Sensor Holder 100280105 100280105 1
24 Pipe Clamp 100430025 100430025 1
25 Evaporator right fixed plate 029993926 029993926 1
26 Motor platen 391990210 391990210 1
27 Motor 030020173 030020173 1
28 Electric box cover 100100041 100100041 1
29 Electric control plate 040012722 040010179 1
30 Transformer 030180061 030180061 1
31 Terminal Board 030090004 030090005 1
32 Electric box 100100035 100100035 1
33 Screw 150010058 150010058 2
34 Wire Clip 391110017 391110017 1
35 Right angle plate 100300026 100300026 1
36 Wall-mounting frame 020100011 020100011 1
37 Step motor 320273001 320273001 1
38 Step Motor plate 100420002 100420002 1
39 Crank connecting rod 100420082 100420082 1
40 Thermal insulation pipe 099990080 099990080 1
41 Remote controller 336825001 336825002 1
4.2.3 Explosive view of outdoor unit for 1HP
4.2.4 Spare parts list of outdoor unit
Part No. Qt
No. Description
KF-23W/A KFR-23W/A KF-25W/A KFR-25W/A y
1 Front Grill 393990022 393990022 393990022 393990022 1
2 Grill Clip 020120002 020120002 020120002 020120002 8
3 Front Plate 020070001 020070001 020070001 020070001 1
4 Small handle 100050001 100050001 100050001 100050001 1
5 Nut 150020019 150020019 150020019 150020019 1
6 Gasket 150030016 150030016 150030016 150030016 1
7 Axial flow fan 100030013 100030013 100030013 100030013 1
8 Motor 030020201 030020201 030020201 030020201 1
9 Motor support 020040029 313040004 020040029 313040004 1
10 PE Sponge PE 382100010 382100010 382100010 382100010 1
11 Base 020010112 020010112 313221003 020010111 1
Anti-vibration pad for the
12 010010980 010010980 010010980 010010980 3
compressor
13 Compressor 301109004 301109004 010010923 010010923 1
14 Gasket 150030010 150030010 150030010 150030010 3
15 Nut 150020003 150020003 150020003 150020003 3
16 Top panel 020080001 020080001 020080001 020080001 1
17 Partition board 020030001 020030001 020030001 020030001 1
18 PU Sponge 090020226 090020226 090020226 090020226 1
19 Electric installation board 313120027 313120027 313120027 313120027 1
20 Compressor Capacitor 030010028 030010028 030010015 030010015 1
21 Capacitor Clamp 020140007 020140007 020140006 020140006 1
22 Terminal Board 321000025 321000025 321000025 030090025 1
23 Fan Capacitor 030010005 030010005 030010005 030010005 1
24 Wire Clip 321100011 321100011 321100011 321100011 1
25 PU Sponge ------ ------ ------ ------
26 Rear Grill 020110001 020110001 020110001 020110001 1
27 Span Pipe ------ ------ ------ ------
28 Span Pipe 070050020 070050020 070050020 070050020 1
29 3-way Pipe 070130100 070130101 070130100 070130101 1
30 Condenser 372100126 372100045 372200076 372100045 1
31 4-way Valve ------ 961300017 ------ 961300026 1
Intake pipe for the
32 360420005 070030277 360420005 070030277 1
condensor
33 Capillary Assy 990070051 960800127 960800168 960800183 1
34 Damping rubber 110030017 110030017 110030017 110030017 1
35 Filter 070190038 070190038 070190007- 070190007 1
36 Right panel 020060004 020060004 020060004 020060004 1
37 Large handle 100040001 100040001 100040001 100040001 1
38 Valve installation plate 020020001 020020001 020020001 020020001 1
39 High-pressure valve 060020092 060020092 060020092 060020092 1
40 Low-pressure valve 060020095 060020095 060020095 060020095 1
41 Screw 150010048 150010048 150010048 150010048 4
42 Drainpipe for the 070040097 070040097 070040097 070040097 1
condensor
43 Discharge pipe 070040097 070010551 360220096 360220093 1
44 Damping block 110020002 110020002 110020005 110020005 4
45 Suction pipe 360120095 360120072 360120096 360120092
46 Damping rubber 110030020 110030023 110030020 110030023 1
050030044 050030044 050030044 050030044
47 Connecting Wire 1
345200094 345200094 345200094 345200094
Table 2.6-2
Part No. Qt
No. Description
KF-51W/B KFR-51W/B y
1 Front Grill 020120015 020120015 1
2 Grill Clip 393990022 393990022 8
3 Front Plate 020070056 020070056 1
4 Small handle 100050021 100050021 1
5 Nut 150020003 150020003 1
6 Gasket ------ ------ 1
7 Axial flow fan 393010015 393010015 1
8 Motor 320222014 320222014 1
9 Motor support 020040045 020040045 1
10 PE Sponge PE 382100010 382100010 1
11 Base 313011091 313011091 1
Anti-vibration pad for the
12 010010980 010010980 3
compressor
13 Compressor 301109007 301109007 1
14 Gasket 150030010 150030010 3
15 Nut 150020003 150020003 3
16 Top panel 020080002 020080002 1
17 Partition board 313030027 313030027 1
18 PU Sponge 090020027 090020027 1
19 Electric installation board 313120025 313120025 1
20 Compressor Capacitor 030010020 030010020 1
21 Capacitor Clamp 020140010 020140010 1
22 Terminal Board 321000025 030090025 1
23 Fan Capacitor 030010007 030010007 1
24 Wire Clip 321100013 321100013 1
25 PU Sponge ------ ------
26 Rear Grill 020110002 020110002 1
27 Span Pipe ------ ------ 1
28 Span Pipe ------ ------ 1
29 3-way Pipe 070130108 070130108 1
30 Condenser 372200065 372100070 1
31 4-way Valve ------ 973500052 1
KF(R)-5161GW/c66GW/B serieses
4.3.1 Explosive view of indoor unit
4.3.2 Spare parts list of indoor unit
Table 3.2-1
Part No. Qt
No. Description
KF-51G/c KFR-51G/c KF-61G/c KFR-61G/c y
100420012 100420012 100420012 100420012
(A2) (A2) (A2) (A2)
1 Swing Louver 14
100420041 100420041 100420041 100420041
(B12) (B12) (B12) (B12)
2 Connecting rod 100420061 100420061 100420061 100420061 4
3 Guide Louver Bearing A A 109990468 109990468 109990468 109990468 2
4 Guide Louver Bearing B B 109990472 109990472 109990472 109990472 1
5 Outlet part 100090107 100090107 100090107 100090107 1
6 Louver 100390005 100390005 100390005 100390005 1
7 Base 100060118 100060118 100060118 100060118 1
8 Left fixed plate 109990310 109990310 109990310 109990310 1
9 Cross flow fan 100010003 100010003 100010003 100010003 1
10 Fan Bearing 110010202 110010202 110010202 110010202 1
11 Ring of Bearing
12 Evaporator assembly 980280057 980280057 980280010 980280010 1
13 Electric heater
14 Screw cover 109990079 109990079 109990079 109990079 3
15 Middle frame 100080007 100080007 100080007 100080007 1
16 Cold Catalyst 119990011 119990011 119990011 119990011 1
17 Air Filter 100190118 100190118 100190118 100190118 2
18 Display box cover 100410010 100410010 100410010 100410010 1
19 Display box 100410002 100410002 100410002 100410002 1
391022095 391022095 391022095 391022095
() () () ()
20 Front Panel 1
100110038 100110038 100110038 100110038
() () () ()
21 Room temp. Sensor Holder 100280105 100280105 100280105 100280105 1
22 Insert Block 079990240 079990240 079990240 079990240 1
23 Copper pipe of sensor 079990030 079990030 079990030 079990030 1
24 Water-resistant board 109990392 109990392 109990392 109990392 1
25 Motor platen 100130004 100130004 100130004 100130004 1
26 Motor fixed-board 100130026 100130026 100130026 100130026 1
27 Motor 030020109 030020109 030020176 030020176 1
28 Electric box small cover plate 020160029 020160029 020160029 020160029 1
29 Electric box cover 020160016 020160016 020160016 020160016 1
30 Wire Clamp 100430022 100430022 100430022 100430022 1
31 Connecting Wire 050030014 050030014 050030014 050030014
32 Electric box Panel 1 1 100430014 100430014 100430014 100430014 1
33 Electrical box 020150034 020150034 020150034 020150034 1
34 Electric box Panel 2 2 100430015 100430015 100430015 100430015 1
35 Electric box Panel 3 3 100430016 100430016 100430016 100430016 1
36 Display lamp panel 331800095 331800077 331800095 331800077 1
37 Tube Temp. Sensor 049990017 049990017 049990017 049990017 1
38 Electric control plate 040012639 040012641 331100117 331300086 1
39 Room Temp. Sensor 049990017 049990017 049990017 049990017 1
40 Power Cord () 050010027 050010027 050010017 050010017 1
41 Terminal Board 030090004 030090004 030090004 030090004 1
42 Connecting Cable 050020015 050020015 050020015 050020015 1
43 Screw 150010057 150010057 150010057 150010057 2
44 Step motor 030020406 030020406 030020406 030020406 1
45 Thermal insulation pipe 099990080 099990080 099990080 099990080 1
46 Pipe Clamp 100430026 100430026 100430026 100430026 1
47 Wall-mounting frame 020100003 020100003 020100003 020100003 1
48 Remote controller 336811001 336821002 336811001 336821002 1
Table 3.2-2
Part No. Qt
No. Description
KF-66G/B KFR-66G/B y
100420012 100420012
(A2) (A2)
1 Swing Louver 14
100420041 100420041
(B12) (B12)
2 Connecting rod 100420061 100420061 4
3 Guide Louver Bearing A A 109990468 109990468 2
4 Guide Louver Bearing B B 109990472 109990472 1
5 Outlet part 100090107 100090107 1
6 Louver 100390005 100390005 1
7 Base 100060118 100060118 1
8 Left fixed plate 109990310 109990310 1
9 Cross flow fan 100010003 100010003 1
10 Fan Bearing 110010202 110010202 1
11 Ring of Bearing
12 Evaporator assembly 980280010 980280010 1
13 Electric heater
14 Screw cover 109990079 109990079 3
15 Middle frame 100080007 100080007 1
16 Cold Catalyst 119990011 119990011 1
17 Air Filter 100190118 100190118 2
18 Display box cover 100410010 100410010 1
19 Display box 100410002 100410002 1
391022095 391022095
() ()
20 Front Panel 1
100110038 100110038
() ()
21 Room temp. Sensor Holder 100280105 100280105 1
22 Insert Block 079990240 079990240 1
23 Copper pipe of sensor 079990030 079990030 1
24 Water-resistant board 109990392 109990392 1
25 Motor platen 100130004 100130004 1
26 Motor fixed-board 100130026 100130026 1
27 Motor 030020176 030020176 1
28 Electric box small cover plate 020160029 020160029 1
29 Electric box cover 020160016 020160016 1
30 Wire Clamp 100430022 100430022 1
31 Connecting Wire 050030014 050030014
32 Electric box Panel 1 1 100430014 100430014 1
33 Electrical box 020150034 020150034 1
34 Electric box Panel 2 2 100430015 100430015 1
35 Electric box Panel 3 3 100430016 100430016 1
36 Display lamp panel 331800095 331800077 1
37 Tube Temp. Sensor 049990017 049990017 1
38 Electric control plate 331100117 331300086 1
39 Room Temp. Sensor 049990017 049990017 1
40 Power Cord () 050010028 050010028 1
41 Terminal Board 030090004 030090004 1
42 Connecting Cable 050020015 050020015 1
43 Screw 150010057 150010057 2
44 Step motor 030020406 030020406 1
45 Thermal insulation pipe 099990080 099990080 1
46 Pipe Clamp 100430026 100430026 1
47 Wall-mounting frame 020100003 020100003 1
48 Remote controller 336811001 336821002 1
4.3.3 Explosive view of outdoor unit for 2HP
4.3.4 Spare parts list of outdoor unit
Part No. Qt
No. Description
KF-51W/Bc KFR-51W/Bc KF-61W/Bc KFR-61W/Bc y
1 Front Grill 313110001 313110001 313110001 313110001 1
2 Grill Clip 393990022 393990022 393990022 393990022 8
3 Front Plate 313070009 313070009 313070009 313070009 1
4 Nut 150020019 150020019 150020019 150020019 1
5 Gasket 150030007 150030007 150030007 150030007
6 Axial flow fan 100030005 100030005 100030005 100030005 1
7 Motor 320222015 320222014 320222015 320222015 1
8 Motor support 313040024 313040024 313040011 313040011 1
9 Left protect net 313990020 313990020 313990020 313990020 1
10 Pillar 313990021 313990021 313990021 313990021 2
11 PE Sponge PE 382200002 382200002 382200002 382200002 1
12 Partition board 313030028 313030028 313030028 313030028 1
13 Small handle 100050018 100050018 100050018 100050018 1
14 Top panel 313080002 313080002 313080002 313080002 1
15 Electric box 313990007 313990007 313990007 313990007 1
16 Compressor Capacitor 030010020 030010020 030010019 030010019 1
17 PU Sponge 090020332 090020332 090020150 090020150
18 Condenser 372200097 372100070 372200088 372100163 1
19 Capacitor clamp 313130006 313130006 313130006 313130006 1
20 Fan Capacitor 030010009 030010007 030010009 030010009 1
21 Terminal Board 321000025 030090025 321000025 321000025 1
22 Wire Clip 321100013 321100003 321100013 321100013 1
23 Four-way valve assembly ----- 973500052 ----- 973500203 1
Intake pipe for the
24 070030017 360450012 070030247 070030247 1
condensor
25 Rear Grill 313100005 313100005 313100010 313100010 1
Damping rubber for
26 110030017 110030017 110030015 110030017 1
capillary
27 Capillary Assy 971900373 971900243 971900377 971900359 1
Drainpipe for the
28 070040030 070040030 070040030 070040030 1
condensor
29 Discharge pipe 360230183 360230092 360230198 360230198 1
30 Damping rubber 110030023 110030023 110030023 110030023 2
31 Suction pipe 360130206 360130126 360130191 360130191 1
32 Valve cover
33 High-pressure valve 060020009 060020009 060020102 060020102 1
34 Low-pressure valve 060020089 060020089 060020145 060020145 1
35 Valve installation plate 313020001 313020001 313020001 313020001 1
36 Large handle 100040004 100040004 100040004 100040004 1
37 Right panel 313060007 313060007 313060007 313060007 1
345200020 345200020 345200020 345200020
38 Power cord 050040064 050040064 050040064 050040064 1
345100010 345100010 345100010 345100010
39 Anti-vibration pad for the 010010980 010010980 305146007 305146007 3
compressor
40 Compressor 301109007 301109007 301114034 301114034 1
41 Gasket 150030010 150030010 150030010 150030010 3
42 Nut 150020003 150020003 150020003 150020003 3
43 Base 313012003 313011091 313012005 313012005 1
KF(R)-70GW/c serieses
4.4.1 Explosive view of indoor unit
4.4.2 Spare parts list of indoor unit
Part No. Qt
No. Description
KF-70G/c KFR-70G/c y
1 Wall-mounting frame 020100016 020100016 1
2 Base 100060127 100060127 1
3 Left angle plate 391990039 391990039 1
4 Front angle plate 391990040 391990040 1
5 Cross flow fan 100010025 100010025 1
6 Fan Bearing 401000059 401000059 1
7 Ring of Bearing ----- ----- 1
Room temp. Sensor
8 0
Holder
9 Evaporator Assy 972900247 972900247 1
10 Evaporator fixed plate 109990264 109990264 1
11 Electric heater ----- ----- 1
12 Outlet part 391080006 391080006 1
13 Louver A 391190023 391190023 1
14 Louver B 391190024 391190024 1
15 Left Connecting rod A A 391200035 391200035 1
16 Guide Louver Bearing A A 391200029 391200029 3
17 Step motor left support 391200044 391200044 2
391190025 391190025
18 Swing louver 391190026 391190026 2
391190027 391190027
19 Swing louver right support 391200041 391200041 1
Swing louver middle
20 391200040 391200040 1
support
21 Swing louver left support 391200039 391200039 1
22 Air outlet protect net 311030006 311030006 1
23 Middle frame 391070026 391070026 1
24 Screw cover 109990257 109990257 3
25 Cold Catalyst 119990011 119990011 1
26 Air filter 100190120 100190120 2
27 Display box cover 391140018 391140018 1
28 Display box 391130021 391130021 1
29 Front Panel 391022270 391022270 1
30 Right angle plate 391990038 391990038 1
31 Motor holder 100130015 100130015 1
32 Fan motor 030020168 030020168 1
33 Motor cover 100130016 100130016 1
34 Electrical box 020150086 020150086 1
35 Hook for the wire 391110015 391110015 1
36 Wire Clamp 391110015 391110015 1
37 Electric box Panel 1 1 100430080 100430080 1
38 Electric box Panel 2 2 100430081 100430081 1
39 Display lamp plate 331800096 331800097 1
40 Room Temp. Sensor
338000009 338000009 1
41 Tube Temp. Sensor
42 Electric control plate 331100178 331100178 1
43 Power cord 050010028 050010028 1
44 Terminal Board 030090006 030090006 1
45 Connecting cable 050020057 050020057 1
46 Thermal insulation pipe 099990080 099990080 1
47 Left Connecting rod B B 391200037 391200037 1
Left middle Connecting
48 391200033 391200033 1
rod
Right middle Connecting
49 391200034 391200034 1
rod
50 Right Connecting rod B B 391200038 391200038 1
51 Right Connecting rod A A 391200036 391200036 1
Right small Connecting
52 391200043 391200043 1
rod
53 Step motor right support 391200045 391200045 3
320273013 320273013
54 Step motor 320273014 320273014 1
320273015 320273015
55 Guide Louver Bearing B B 391200030 391200030 1
56 Wire Clip 391110015 391110015 1
57 Water-resistant board 100120008 100120008 1
58 Remote controller 336821047 336821046 1
KF(R)-88CH3-Q serieses
4.5.1 Explosive view of indoor unit
4.5.2 Spare parts list of indoor unit
Part No. Qt
No. Description
CS-88C3-Q CS-88CH3-Q y
1 Swing louver 391200095 391200095 20
391200086 391200086
391200087 391200087
391200088 391200088
391200089 391200089
2 Connecting rod 1 1 1
391200090 391200090
391200091 391200091
391200096 391200096
391200097 391200097
391200092 391200092
3 Connecting rod 2 2 391200093 391200093 1
391200094 391200094
320273013 320273013
4 Step motor 320273014 320273014 1
320273015 320273015
5 Step motor bearing A A 391200082 391200082 1
6 Step motor fixing A A 391200081 391200081 1
391190050 391190050
7 Louver 1
391190051 391190051
8 Outlet part 391800030 391800030 1
9 Base 391060109 391060109 1
10 Cross flow fan 100010018 100010018 1
11 Evaporator fixed plate 391990164 391990164 1
12 Evaporator assembly 972900689 972900689 1
13 Screw cover 391990157 391990157 3
14 Middle frame 391070065 391070065 1
15 Reveal eyeglass 391040047 391040047 1
16 Display box 391130004 391130004 1
17 Display lamp panel
18 Front Panel 391022228 391022228 1
Middle fram small
19 391220064 391220064 1
cover board
20 Evaporator right plate
21 Water-resistant board 391990162 391990162 1
22 Motor cover 391990161 391990161 1
23 Motor 320202003 320202003 1
24 Motor holder 391990160 391990160 1
25 Electric box cover 311020006 311020006 1
26 Electric box 020150086 020150086 1
27 lamp rack Assembly1 1 100430080 100430080 1
28 lamp rack Assembly 2 2 100430081 100430081 1
29 lamp rack Assembly 3 3 391110014 391110014 1
30 ngle plate 391250003 391250003 1
31 Step motor Connecting 391200084 391200084 1
rod
32 Step motor bearing B B 391200083 391200083 1
33 Step motor bearing C C 391200084 391200084 1
34 Step motor fixing B B 391200081 391200081 1
35 Louver bearing 391200085 391200085 1
5. Operation principle
i ndoor uni t
11
10
9
i ndoor f an
8
connecti on pi pe 12 connecti on pi pe
2
15 outdoor uni t 7
1
5
13 6
14
3 16
1.compressor 2. 4-way value 3.condenser 4.flow divider for condenser 5.Non-return valve 6.auxiliary capillary 7.cooling capillary
8.high-pressure valve 9.flow divider for evaporator 10.evaporator 11. pipe temp. sensor for evaporator 12.low-pressure valve 13.Vapor
liquid separator 14.low-pressure switch 15. high-pressure switch 16pipe temp. sensor for condenser
Cooling cycly compressor4-way valuecondenserflow divider for condenserNon-return valvecooling capillaryhigh-pressure valve
flow divider for evaporatorevaporatorlow-pressure valve4-way valueVapor liquid separatorcompressor.
Heating cyclycompressor4-way valuelow-pressure valveevaporatorflow divider for evaporatorhigh-pressure valvecooling capillary
auxiliary capillaryflow divider for condensercondenser4-way valueVapor liquid separatorcompressor.
NoteTo the model of RF or LF beginning, use outdoor unit model to express the whole unit.
Temperature of condenser
Experiment 50.9 46.2 48.6 47.3
middle/exit
parameter
Evaporator of condenser
middle
high pressure/low pressure MPa /
ZKF-35GW/E ZKFR-35GW/E
PCB model ZGCA-77-3E ZGHA-77-3E
72-F 72-F
Electric fittings
Transformer model EI-41 EI-41 EI-41 EI-41
Fuse model/fuse current A 50CT/3.15 50CT/3.15 50CT/3.15 50CT/3.15
Remote controller type Eidolon currency Eidolon currency Eidolon currency Eidolon currency
Brilliant variety 3 Brilliant variety
Display mode More variety More variety
lamp 3 lamp
horizontal(a
Mauley move Mauley move Mauley move Mauley move
uto/manual)
swing
function
vertical(aut
oneself oneself oneself oneself
o/manual)
MC/
on
Australian energy
Energy consumption/European
consumption energy
consumption/DOE/other
RoHs
Table6-2
Model KF-25GW/Ac KF-25GW/Ec CS-25C3-U27AB KFR-25GW/Ac
pattern NO. 27
Capacity W 2643/2800
Input W 872/850
Heating
Rated current A 3.9/3.8
Brand W 40 40 40 40
Fan motor
Capacitor uF 1.2 1.2 1.2 1.2
Hydrophile foil
Hydrophile foil karat Hydrophile foil Hydrophile foil karat
Evaporator Fin type (code) karat window
window finned karat window finned window finned
finned
7/ inner groove 7/ inner groove 7/ inner groove 7/ inner groove
Tube outside dia.and type mm
copper pipe copper pipe copper pipe copper pipe
747.2250.519
Dimension (W*H*D) mm 795270200 747.2250.5197 795270200
7
Packing (W*H*D) mm 860350260 820325255 820325255 860350260
Net/Gross weight Kg 10/10.5 8.5/10 10/10.5 10/10.5
Input W 60 60 60 60
Fan motor
Capacitor uF 2 2 2 2
Liquid pipe/ gas pipe dia./length mm 6.35/9.52 /3500 6.35/9.52 /3500 6.35/9.52 /3500 6.35/9.52 /3500
cable spec.(dia./quantity/length) mm/ /m 1.0 /3 /4000 1.0 /3 /4000 1.0 /3 /4000 1.0 /5 /4000
Remote controller type Eidolon currency Eidolon currency Eidolon 1 mark Eidolon currency
Brilliant variety 3 Brilliant variety 3
Display mode More variety More variety
lamp lamp
horizontal(auto/m
Mauley move Mauley move Mauley move Mauley move
anual)
swing
units vertical(auto/man
oneself oneself oneself oneself
ual)
Health function (anion/cold catalyst/light
cataly/Plasma/air cleaner)
Special function(soft start/power cut
memory/hard start/other)
Safety
certification
CE/CB/GS/SAA/UL/SASO/EMC/
certification
Energy Australian energy consumption/European
consumption energy consumption/DOE/other
RoHs
Table 6-3
Model KFR-25GW/Ec CS-25H3-U27AB KF-32GW/Ac KF-32GW/Ec
pattern NO.
Capacitor uF 30 30 30 35
SUNISO SUNISO SUNIDO
NAPHTHENE(SU
Refrigerant oil ml 4GSD/ATMOS 4GSD/ATMOS 4GSD/ATMOS
NISO 4GSI)/440
NM56EP/400 NM56EP/400 NM56EP/480
Model YDK-14-4 YDK-16-4 YDK-16-4 YDK-14-4
Brand W 40 40 40 40
Fan motor
Capacitor uF 1.2 1.2 1.2 1.2
W 60 60 65 65
uF 2 2 2 2
circuitsNumber of circuits
Tube pitch row pitchFin
mm 2113.41.4 2113.41.4 2112.71.56 2112.71.56
spacing
Hydrophile foil
Condenser Hydrophile foil karat Light foilkarat Light foilkarat
Fin type (code) karat window
window finned window finned window finned
finned
7/ inner groove 7/ inner groove 7/ inner groove 7/ inner groove
Tube outside dia.and type mm
copper pipe copper pipe copper pipe copper pipe
Liquid pipe/ gas pipe dia./length mm 6.35 /9.52 /3500 6.35 /9.52 /3500 6.35 /12.7 /3500 6.35 /12.7 /3500
connecting
Max pipe length/ Max pipe high m 4 4 4 4
pipe/cable
cable spec.(dia./quantity/length) mm/ / 1.0 / 5 /4000 1.0 / 5 /4000 1.0 / 3 /4000 1.0 / 3 /4000
discharge gas
temperature/suction gas 75.4/8.9 75.0/8.4 89.7/11.2 81.8/4.1
temperature
Experiment
Temperature of condenser
parameter 50.3 49.4 48.5 47.7
middle/exit
Evaporator of condenser middle
high pressure/low pressure MPa
ZKFR-25GW/E
PCB model ZKFR-25GW/A 27/1 ZGCA-77-3E ZKF-35GW/E 72-F
72-F
Electric fittings
Transformer model EI-41 EI-41 EI-41 EI-41
Remote controller type Eidolon currency Eidolon 1 mark Eidolon currency Eidolon currency
Brilliant variety 3
Display mode More variety More variety More variety
lamp
horizontal(auto/man
Mauley move Mauley move Mauley move Mauley move
ual)
function
swing
vertical(auto/manual
oneself oneself oneself oneself
)
Health function (anion/cold catalyst/light
cataly/Plasma/air cleaner)
Special function(soft start/power cut
memory/hard start/other)
Safety
CE/CB/GS/SAA/UL/SASO/EMC/
certification
certification
Energy Australian energy
consumpti consumption/European energy
on consumption/DOE/other
RoHs
Table 6-4
Model KFR-32GW/Ac KFR-32GW/Ec KF-35GW/Ac CS-35C3-U27AH1B
NO. 27
Brand W 40 40 40 35
Fan motor
Capacitor uF 1.2 1.2 1.2 1.2
Coil length x height x width mm 647X 197 579X 249 645X281 645X 230
Input W 65 65 65 60
Capacitor uF 2 2 2 2
Speed r/min 900 900 900 890/ /
Fan motor diameterheight mm 401115 401115 401115 401X 115
Number of rowsNumber of circuits
1X 12 X2 1X 2 X2 1X 12 X1 1X 12 X1
Number of circuits
Tube pitch row pitchFin spacing mm 25X 22 X1.47 25X 22 X1.47 21X 12.7 X1.56 21X 12.7 X1.56
Coil length x height x width mm 610X 228 X505 610X 228 X505 610X 230 X505 610X 230 X505
Liquid pipe/ gas pipe dia./length mm 6.35/12.7 /3500 6.35/12.7 /3500 6.35/12.7 /3500 6.35/12.7 /3500
connecting
Max pipe length/ Max pipe high m 4 4 4 4
pipe/cable
cable spec.(dia./quantity/length) mm/ /m 1.0/5 /4000 1.0/5 /4000 1.5/3 /4000 1.5 /3 /4000
Remote controller type Eidolon currency Eidolon currency Eidolon currency Eidolon 1 mark
Brilliant variety 3 Brilliant variety 3
Display mode More variety More variety
lamp lamp
horizontal(auto/ma
Mauley move Mauley move Mauley move Mauley move
nual)
function
swing
vertical(auto/manu oneself oneself
units oneself oneself
al)
Health function (anion/cold catalyst/light
cataly/Plasma/air cleaner)
Special function(soft start/power cut
memory/hard start/other)
Safety
certification
CE/CB/GS/SAA/UL/SASO/EMC/
certification
Energy Australian energy consumption/European energy
consumption consumption/DOE/other
RoHs
Table 6-5
Model KFR-35GW/Ac CS-35H3-U27AH1A KF-51GW/Bc KF-51GW/c
pattern NO. 27
Capacitor uF 30 35 50 50
Brand W 40 35 40 56
Fan motor
Capacitor uF 1.2 1.2 1.2 1.8
Evaporator
finned finned finned finned
70.25+0.18/ 70.25+0.18/
7/ inner groove 7/ inner groove
Tube outside dia.and type mm inner groove copper inner groove copper
copper pipe copper pipe
pipe pipe
Input W 65 50 80 80
Qtyper 40HQ
Remote controller type Eidolon currency Eidolon 1 mark Eidolon currency Eidolon currency
Brilliant variety 3 Brilliant variety 3 Brilliant variety 3
Display mode More variety
lamp lamp lamp
horizontal(auto/ma
Mauley move Mauley move Mauley move Mauley move
nual)
function
swing
vertical(auto/manu
units Oneself Oneself Oneself Oneself
al)
Health function (anion/cold catalyst/light
cataly/Plasma/air cleaner)
start/other)
Safety
certifi
cation
certifica CE/CB/GS/SAA/UL/SASO/EMC/
tion
Energy
Australian energy consumption/European
consumpti
energy consumption/DOE/other
on
RoHs
Table 6-6
Model KFR-51GW/Bc KFR-51GW/c KF-61GW/c KFR-61GW/c
Pattern NO.
Capacitor uF 50 50 45 45
SUNISO-4GSI SUNISO SUNISO
NAPHTHENE(SUNISO
Refrigerant oil ml FREOL-K5GJ OR 4GSD/ATMOS 4GSD/ATMOS
4GSI)/520
EQUIVALENT/600 NM56EP\950 NM56EP\950
Model YDK-16-4 YDK-26-4 YDK-26-4 A6 YDK-26-4 A6
Brand W 40 56 56 56
Fan motor
Indoor unit
Condenser
Fin type (code) karat window karat window karat window
window finned
finned finned finned
7/ inner groove 9/ inner groove 8/ inner groove 8/ inner groove
Tube outside dia.and type mm
copper pipe copper pipe copper pipe copper pipe
Remote controller type Eidolon currency Eidolon currency Eidolon currency Eidolon currency
Brilliant variety 3 Brilliant variety 3 Brilliant variety 3 Brilliant variety 3
Display mode
lamp lamp lamp lamp
horizontal(auto/m
Mauley move Mauley move Mauley move Mauley move
anual)
swing
function
vertical(auto/man
Oneself Oneself Oneself Oneself
units ual)
Health function (anion/cold
catalyst/light cataly/Plasma/air
cleaner)
Special function(soft start/power cut
memory/hard start/other)
Safety
certification
certifica CE/CB/GS/SAA/UL/SASO/EMC/
tion
Energy
Australian energy consumption/European
consumpti
energy consumption/DOE/other
on
RoHs
Table 6-7
Model CS-66C3-N**AS CS-66H3-N**AS KF-70GW/c KFR-70GW/c
pattern NO.
Brand W 56 56 70 70
Fan motor
Capacitor uF 1.8 1.8 3.5 3.5
Capacitor uF 4 4 4 4
Condenser
Fin type (code) karat window karat window
window finned window finned
finned finned
8/ inner groove 9.52/ inner 9.52/ inner 9.52/ inner
Tube outside dia.and type mm
copper pipe groove copper pipe groove copper pipe groove copper pipe
discharge gas
temperature/suction gas 84.3/6.1 83.2/4.4 88.1/8.2 97.7/16.4
temperature
Experiment
Temperature of condenser
parameter 49.7 50.2 49.1 53.0
middle/exit
Evaporator of condenser middle
high pressure/low pressure MPa
PCB model ZGCN-77-4E2 ZGHN-77-4E2 ZGCS-77-4E ZGHS-77-4E
Electric
Transformer model
fittings
Fuse model/fuse current A
Remote controller type Eidolon currency Eidolon currency Eidolon currency Eidolon currency
c
t
Brilliant variety 3 Brilliant variety 3 Brilliant variety 3 Brilliant variety 3
Display mode
lamp lamp lamp lamp
horizontal(auto
Mauley move Mauley move Mauley move Mauley move
/manual)
swing
vertical(auto/m
Oneself Oneself Oneself Oneself
anual)
Health function (anion/cold
catalyst/light cataly/Plasma/air cleaner)
Special function(soft start/power cut
memory/hard start/other)
Safety
certification
certificati CE/CB/GS/SAA/UL/SASO/EMC/
on
Energy Australian energy consumption/European
consumption energy consumption/DOE/other
RoHs
Table 6-8
Model CS-88C3-Q**AT CS-88H3-Q**AT
pattern NO.
Capacity W 8934/9200
Input W 3270/3190
Heating
Rated current A 14.9/13.0
Brand W 80 80
Fan motor
Capacitor uF 3.5 3.5
Hydrophile foil
Evaporator Hydrophile foil karat
Fin type (code) karat window
window finned
finned
7/ inner groove 7/ inner groove
Tube outside dia.and type mm
copper pipe copper pipe
Capacitor uF 4 4
cable
mm/ /m 1.5/5/6000 1.5/3/6000
spec.(dia./quantity/length)
discharge gas
temperature/suction gas 90.1/10.5 79.9/7.2
temperature
Experiment
Temperature of condenser
parameter 49.3 49.8
middle/exit
Evaporator of condenser middle
high pressure/low pressure MPa
PCB model ZGCS-79-4E2 ZGHS-79-4E2
Electric
Transformer model
fittings
Fuse model/fuse current A
swing
vertical(auto/manua
units Oneself Oneself
l)
Health function (anion/cold catalyst/light
cataly/Plasma/air cleaner)
Special function(soft start/power cut
memory/hard start/other)
Safety
Certification
certifica CE/CB/GS/SAA/UL/SASO/EMC/
tion
Energy
Australian energy consumption/European
consumpti
energy consumption/DOE/other
on
RoHs
7.Wiring diagrams
7.1 KF-23GW/EcKF-25GW/EcKF-32GW/EcKF-23GW/AcKF-25GW/AcKF-32GW/AcKF-35GW/Ac
KF-51GW/Bc
Indoor unit:
outdoor unit:
Indoor unit:
outdoor unit:
7.3 KF-51GW/cKF-61GW/c
Indoor unit:
outdoor unit:
7.4 KFR-51GW/cKFR-61GW/c
Indoor unit:
outdoor unit:
7.5 CS-66C3-N**A-S
Indoor unit:
outdoor unit:
7.6 CS-66CH3-N**A-S
Indoor unit:
outdoor unit:
7.7 KF-70GW/c
Indoor unit:
outdoor unit:
7.8 KFR-70GW/c
Indoor unit:
outdoor unit:
7.9 CS-88C3-Q**AT
Indoor unit:
outdoor unit:
7.10 CS-88H3-Q**AT
Indoor unit:
outdoor unit:
8PCB principle chart
KF(R)-23/25/30/32GW/E(D)KF(R)-25GW/A(D) MITSUBLSHL(37544)47212730
CNB
CNC
B
R22
IC5 7805 +5 JS2-B47aC-M01A/2
N1
C1
T
1 Vin OUT 3
N ZR 621-10-126 104/275V AC D1-D4 AC.ZERO
22/2W
GND
D5
E1 C13 C21
C14 E7 E6
IN4007 104 104 104
L FUSE IN4001 100uF/16V
1000UF/35V 220UF/16V
2
D D
F3.15A 250VAC
COM
U1 B
+5 GND
C4 104
CNM
5 B E2
47uF/25V
COM MC2003 R18
GND 9 4.7K
CM CN 52C-1A 1 D14 4148 D15 4148 D16 4148
IC3 10 4 23 28 P05 +5
P00
HSTP.0 / TYPE1.0 R44 R45
2 11 5 heat/cool 4.7K 4.7K
25
HEAT
P02 D7 4148
1 P12 D11 4148 D9 4148
52X6A 3 12 6 26
/ TYPE1.1
P03 HSTP.1
27 dhon/off
U1 4 13
20S X2A 7
P04 2 P13 D12 4148 D10 4148 D8 4148 L1 L15
- - -
B
A
C14102
14 7 L2 L14
3
B
C6 102
X2B P23 L3 L13
C
C7 102
C 8 21 P34 STB +5 CNE L4 L12 C
FS-ZG26
X1A 15 2
D
FMO P24 1 C15102
DCP
52X6B R50 220 L5 L11
BCLK S 2
20 P33
E
FMC C9 102
9 GND 3 L6 L10
16 1 R48 220 4
F
52CB P25 BDA 5 C10 102
19 P32 6 L7 L9
8
G
C11 102
JZC-7F*2 IC1 R49 220 L8
+5V GND
H
C23 C25 C24 XH-6A
GND
CNU X1B 37544 4.7K
102 102 102
GND
C2 L1 12 CNVSS
104/275V U1 D13 GND GND GND R4 R5 R6 R7
N
R25 P11 32 R60
5 IN4148 GND
+5 10K 10K 10K 51K
+5 Q2 4.7K
CFI R1 1 IC4 R1 220
IC6
1.2uF 220
C1815
+5 IC6 DA
3 R21 GND R35 4.7K R424.7K AT24C028 1 2 3 E6 R2 220
OSC 1 OSC GND 28 GND
390 P07 47uf/25V CLK
1 2 BCR 30 6 7
C3 IC2 R414.7K 4 R3 220
DIN/OUT
2 DIN/DOUT GR1 27 L1
473/275V 4 1 +5 5 STB
R2 3306 18 GND CLK 3 CLK GR2 26 L2
3 2 P31 GNDC2 C3 C4
Q4 R26 17 P30 3 GND C1 STB 4 25 GND
MC3021 1815 +5V 102 102 102 STB VSS
GND 10K 104
2 S K1 5 24 L3
100 R9
R7 P06 E1 K1 GR3
29 GND
1 +5V 100F/16VR8 K2 6 23
B SW1 C26 4.7K 51 K2 GR4 L4 C12 B
B GND 102 P22 CNP RMT VCC 7 22 104GND
R5 R8 10K 3 VCC VSS1
+ -
Q6 GND 1 C13
BZ 6 C5 C8 2 L118 21 VCC
2K
C1815 +5
C18
2 1 SG1/KS1 VDD
R20 S 104
R274.7K P01 24 C16 4.3K 104 XH-2A 102
104 E3 L129 20 L5
E2 SG2/KS2 GR5
102 PWM 104 HS0038 22UF/16VL13
R61 C12 GND GND 22UF/16V GND 10 SG3/KS3 GR6 19 L6
10K GND 104 GND GND
GND R10
L1411 SG4/KS4
SG12/GR7 18 L7
10K GND R24 510 C15 /RESET
R9 11 L1512 SG5/KS5
SG10/KS10 17 L8
+5 2K
Q1 Xin
14 +5 13 16 L9
CNG E3 10 VREF SG6/KS6
SG9/KS9
TEMP 9012
1uf/50V XL R23 13 Vcc 14 15 L10
SG7/KS7
SG8/KS8
2
Tp C8 3754447212730
C10 R37 C20 R19 102 -
104 4.3k 104 GND
4
E5 10K
A C28 GND GND R17 INT10 +5 CNW A
47uf/25V 104 GND C1815 +5
Q3 C29 10K P37 22 R6
100F/16V
3
R4 2K C7 10K
GND AC..ZERO 102 102 CNTR0 R114.7K E4
C22
2
3 104
R3 GND 16 P14
1
10K C11 C6
103 GND Vss
102
GND GND
GND GND GND
1 2 3 4 5 6 7 8
KF(R)-32/51GW/A(D) 38 style MITSUBLSHL37544PCB principle chart
1 2 3 4 5 6 7 8
CNB B R1 51/1W
IC4 7805 +5 JS2-B38aC-M15A/0
N1
N L3 T
AC.ZERO 1 Vin OUT 3
ZR D1-D4
GND
JLC0301 D5
E1 E2
C21 C22 C1 C2 C3 E3
471 10A
104/275V 104/275 104 220UF/35V 104 104
U FUSE
L2 IN4001 1000UF/35V 220UF/16V 3
2
Q6 A
U1 JLC0301
U2
D F3A 250V B
CN4T
+5 D
E4 Q0 E
COM 22UF/25F +5 GND
Q1 D
5 IC7 R12 R11
C13 8 1 2 3 7
CN1 Q7- F
104 10K 10K
COM
C17 9 MC2003 4 AT24C02 4 Q2
CM CN 52C-1A 1 10 P04 +5 R28 4.7K 6 5 CLOCK
104 7 27 GND Q4
R29 4.7K 5 DATA Q3
GND
2 11 6 P05 28 C28 Q5
102 C3 C2
18 P31 102 102
CNM R27 51
CN 52X6A 3 12 5 P06 29 19 P32 GND CLOCK 5
P33 R26 51 DATA
2
1
8
9
20 4 GND
U1 13 P07 30
C15 C16 +5
Q4 Vss
CLK
B
A
MR
20S X3A 4 4 102 102
IC1 14
B HSTP.0GND / TYPE1.0 R8 R9 +5
heat/cool 4.7K 4.7K 74ALS164
Q0
Q1
Q2
Q3
Q5
Q6
Q7
16 P03
1
52X6B 26 D7 4148
1 P12 D11 4148 D9 4148
3
4
5
6
10
11
12
13
C 15 C
FMO X4A 2 P11 32 HSTP.1 / TYPE1.1
52X4B
dhon/off
R7
R4
R8
510*8
R3
R2
R9
R6
R5
FMC
14 3 P10 31 P13 D12 4148 D10 4148 D8 4148
+5
52X5B 2
8 8 COM1 LED2
JZC-7F*2 Q4
7 P23 R10
9012
GND 4.7K LED1
52CB
COM1 LED6
D6 R13 4.7K 1 D1
P02 25 +5
BZ Q3 R32
IN4148 Q2 Q6 4.7K
1815 R12 LED7 LED4
9013 P25 9012
R33 GND 9
R7 4.7K BUZZ
2K 4.7K
P01 24 COM3
3 LED3
D2 LED5
CNU
C23
B C24
L1 102 +5 R30
N 104/275V U2 GND GND 6
4.7K COM3
5 Q5
P24 R11
CFI
+5 8 9012
C20 1 IC6
4.7K
1.2uF 473/275V 3 R14 e d c b g h a f
B R6 4.7K COM2 B
1 390 P00 23 6 P22 a a LED
2 BCR IC5 DPY-8*2
1 f b f b
R36 4 R31 g g
220
R37 330
+5 e c
6 4.7K 2 7 COM2 dp e c dp
3
2 +5 13 Vcc d d
MC3021 Q7 GND C4 104
+5 1815 R16 GND
com2
com1
10K 10
E5
R34 E8 SW1
2K 1uF/50V P34
21 2 S
Q8 10uf/16F CND RMT
C14 R35 +5 S 3
9012 GND 102 12 +5V 3 2
4.7K
-+
R25 GND GND R24 10K
1 GND 1 HS0038
/RESET 11
R39 P30 R23 4.7K S 2
10K R38 510 17 3 +5V R1 51
10K E1 22UF/16V
C12 +5 GND 1
102 R22
CNG +5
3
Xout GND
TEMP 15 3 P14 R21 10K GND
2
GND C19
R19 510 XL R15 104
1
4.7K
Tp INT0 R4 10K 102 4.7K
Vss 16 22
C7 R18 C6
P37
4
6.3A 250V
621-10-126 U1
B +5
U
FUSE
L1
1 2 C14
CNB
TRANS CNC 1
IC3
Vin OUT
7805
3 JS2-B68aC-S01A/1
GND
ZR C2
C3
S
4 3 E1
C1 E3 104 E2 104
1000UF/35V
JLB1109 104/275VAC
IN4001 104 470UF/25V 220UF/25V C21 B
2
D1--D4 GND
D B 104
D
C9 104
IC1GND 4.7K*12 8
IC6
CLAMP
COM 9
CNM1
IC4 P4.0 25 R8 7 IN
OUT
7 7 10 5
CN COM 9 CLAMP
COM 8 P4.1 26 R7 6 IN
OUT
6 6 11 4
U 52X6B P4.2 27 R6 5 IN
OUT
5 5 12 3
B GND P4.3 28 R5 4 IN
OUT
4 4 13 2
L 10 7 R41 4.7K 41 P6.0 3 14
52X6A OUTIN
7 7 P4.4 R50 2 IN
OUT
3 3 15 B 1
P4.5
29
1 IN
OUT
2 2 16 E10
30 R49 IN
OUT
1 1
11 6 R40 4.7K 36 22UF/25V
OUTIN
6 6 P5.3 VDD 11 +5
52CA 2003
CN1
1
2
C4 E4
12 5 R38 4.7K 35 P5.2 100UF/16V C7 B
X2A
OUTIN
5 5 104 GND CNMR
VSS 12
8
9
MR
CLK
C1 C2 19 P2.3 FEED
14
GND 4.7k GND
GND C15
104
COM36 4 COM1 100 R26
Q0
Q1
Q2
Q3
Q4
Q5
Q6
Q7
102
C3 GND 20 P2.2
+5V 2K R25
R244.7K
GND P0.3 6 Q1 B
3
4
5
6
10
11
12
13
4.7K Q5
R30 21 P2.1 C10 1815
9012 R28 102
510*R1-R8
LED2 4.7k
C16 GND GND
COM25 5 COM2 102 BZ
R3 220 10 P1.3/AD3
+5V GND
4.7K Q6
LED1
e d c b g h a f
R31 9012 R29
(9228)82682-
a a LED
A f b f b DPY-8*2 4.7k A
g g C17
COM14 6 COM3 102
e c dp e c dp D9 D8 D7
GND
d d
3 3 GND
+5V 4.7K R4 4.7K IN4148 IN4148 IN4148
*
2 1 +5V +5
com2
com1
C25
S 104 R32 *
1 2 S
GND GND
1 2 3 4 5 6 7 8
9. Part list of PCB
Display panel
only two LED
running lamp(green)power on light, flash one time/ one second during anti cooled wind.
eleven LED
running lamp(green)power on light, flash one time/ one second during anti cooled wind.
temperature lamp(green)1631 set temp. and room temp. display, light is set temp. flash is set temp.
running lamp(green)power on light, flash one time/ one second during anti cooled wind.
8LED display set temp., also it can display timer time and failure code.
running timer
running lamp(green)power on light, flash one time/ one second during anti cooled wind.
8LED display set temp., also it can display timer time and failure code.
fan running.
LCD display
according to display mode: dehumidification, cooling, ventilation, heating, auto, sleep, fan speed, swing, timer, indoor
fan running.
Cooling
Start up the compressor: when the room temperature is more than Ts+1, compressor start-up
Shut down the compressor: when the room temperature is less than or equal to the set temperature Ts-1,
compressor shutdown
When the temperature of coil pipe of the indoor units is less than or equal to 1 for one minute and the
compressor has continuous run for more than ten minutes, the compressor and outdoor blower fan shut down
through the electric control board and the indoor blower fan is running at low speed.
When the temperature of coil pipe of the indoor units is more than or equal to 7 and the compressor has
shutdown for more than three minutes, the compressor and outdoor blower fan start to run and the indoor blower
fan is running at set speed.
When the temperature of coil pipe of the indoor units is equal to or less than 10 for three minutes in the
compressor has continuous run for three minutes, the compressor, indoor and outdoor blower fans and swinging
wind shut down. Restart up six minutes later; if the above situations appear again within six minutes, all the
outputs are shut down through the electric control board and display failure.
When you press turbo button of remote, the air conditioner enter turbo running, compressor and outdoor blower
fan turn on all along, indoor blower fan run at high speed, turbo indication is light.
After the compressor runs five minutes, the lamp flashes 4 times per six seconds or display E4 if the temperature
of indoor coil pips is more than 25 in the continuous 20 minutes. The controller will automatically shut down if
the temperature of indoor coil pips is more than 25 in another continuous 20 minutes, that is the abnormality
protection of outdoor units and the indicator lamp keeps its former state of flashing. If the temperature of indoor
coil pips is less than 25 in the second 20 minutes or the compressor shuts down, the electric control board will
store to the normal display and the time is restarted when starting up the compressor next time.
Tr
7
C
1
C
-10
C
c
o
m
p
r
e
s
s
o
r
ob
ul
t
do
ow
oe
rr
f
a
n
dl
oo
ow
re
b
r
f
a
n
Tr
c
o
m
p
r
e
s
s
o
r
d
oo
o
re
b
l
w
r
f
a
n
Heating (only applicable to heat pump units)
Start up the compressor: when the room temperature is less than Ts-1, compressor start-up
Shut down the compressor: when the room temperature is more than or equal to the set temperature Ts+3,
compressor shutdown
The electric heating start-up in the heating mode shall meet the following conditions: start up the compressor
and indoor blower fan none defrost TP1< 49 Tr 20.
The electric heating shutdown in the heating mode shall meet one of the following conditions: shutdown
indoor blower fan Tr 23 TP150.
In the heating mode, the indoor flower fan can be set as high/ medium/ low /automatic running mode by remote
control however the anti cool air function is prior. In the heating mode, the anti cool air control function is to
control shutdown of the indoor blower fan by detecting the temperature of coil pipe of evaporator so as to attain
the purpose of preventing cold air from blowing.
For the waste heat emission function in the heating mode, in principle, the indoor blower fan shall be on for
fifteen seconds after the electric heating is closed.
When the temperature of coil pipe of indoor units is more than or equal to 56, the outdoor blower fan shuts
down and it enters the overload protection; when the temperature of coil pipe of indoor units is less than or equal
to 52, the outdoor blower fan starts up and it exit the overload protection.
When the temperature of coil pipe of indoor units rises to 63, the compressor and outdoor blower fan are closed
and two minutes later, the change valve is closed. The indoor blower fan is running at the set speed. Restart up six
minutes later; if the above situations appear again within ten minutes, all the outputs are shut down through the
electric control board and display failure.
When you press turbo button of remote, the air conditioner enter turbo running, compressor ,outdoor blower fan
and four-way valve turn on all along, indoor blower fan run at high speed and it must meet start condition, turbo
indication is light.
After the compressor runs five minutes, the lamp flashes 4 times per six seconds or display E4 if the temperature
of indoor coil pips is less than 30 (heating) in the continuous 20 minutes. The controller will automatically shut
down if the temperature of indoor coil pips is less than 30 in another continuous 20 minutes, that is the
abnormality protection of outdoor units and the indicator lamp keeps its former state of flashing.
Tr
Tr
+ -
3 1
over 6 MIN
COMPRESSOR st ar t - up st ar t - up st ar t - up
out door
st ar t - up st ar t - up st ar t - up
bl ower f an
l ower l ow l ow l ower l ow
speed speed speed speed speed
Tr
36
c
o
m
p
r
e
s
s
o
r
dl
oo
o
re
b
w
r
f
a
n
In the heating mode, the electric control board checks and compares the temperature of indoor room and indoor coil
pipe after the compressor works for a while; judge whether the outdoor heat exchanger part is frosted or not according to
conditions such as the change of indoor coil pipe temperature; if it is judged as frosted, it automatically enters defrosting
process. When defrosting, close the indoor and outdoor blower fan and four-way valve.
Tr
TP2
c
o
m
p
r
e
s
s
o
r
ob
ul
to
dw
oe
or
r
f
a
n
dl
oo
ow
re
b
r
f
a
n
TP2
Tr
Tr
TP2
r
o n
a n
a
n s
s rrf f
r
o a n
a e o rer
s rrf f r o
d e
w o w
s
e o
o e rer p
m t o o
d o
r
p d w o
o w o u
o l
b l
b
m
o
c
t
u
o
o
l
b
d o
l
b
c
Tr
TP2
r
f
a
n
def r ost
compressor st ar t - up shut down st ar t - up shut down st ar t - up
out door
st ar t - up shut down st ar t - up
bl ower f an
our - way
val ve st ar t - up shut down st ar t - up
dl
oo
ow
re
b
r
f
a
n
st ar t - up shut down st ar t - up
Dehumidification
Dehumidification running is to eliminate the water vapor in the air by using the cool circulating capacity, but the
dehumidification will not decrease the indoor temperature in great deal. The air conditioner automatically repeats on
and off circulation according the room temperature, which is shown in the following figure.
Tr
C
Tr 10
i ndoor
l ow speed
bl ower f an
f or bi d
dehumi di f y
st ar t - upshut down st ar t - up shut down shut down st ar t - up shut down st ar t - up shut down
dw
oe
or
rf
b
l
o
a
n
st ar t - upshut down st ar t - up shut down shut down st ar t - up shut down st ar t - up shut down
shut down
In the dehumidification mode, the indoor fan is running at the low speed for twenty seconds at first, then it select
working mode.
In the ventilation mode.When ventilating, the compressor, outdoor blower fan, four-way valve and electric heating are
all closed and the indoor blower fan is running at the set speed.
Tr
c
o
m
p
r
e
s
s
o
r
ob
ul
to
dw
oe
or
r
f
a
n
dl
oo
ow
re
b
r
f
a
n
Automatic mode
Conditions for entering the automatic running mode are: After power-up for the first time, start up and select the
automatic operating mode of remote or press emergency key, the working mode depends on Tr and if the working
mode had set , it doesnt change by Tr and the default set temperature is 25 .
T
r
26
C
2
1
2
5
m
o
d
e
When the time on or time off is used, the clock of remote controller shall be corresponding to the current clock and the
timing times is less than or equal to 24 hours, when the timing time is reached, unit will start-up or shutdown.
Sleep function
When the sleep key is press, air conditionerenter sleep state, indoorblower fan running at low speed, only sleep
indication display.
There is a forcible execution key on the panel of indoor units and the air conditioner can run by pressing the key when
the remote control is out of work or missing.
When pressing down the forcible execution key, then power up and enter the self-check program.
Failure display
Display state
Indoor unit
Outdoor unit
light
1 Outdoor TEMP. sensor failure Flash 1 time/8 SEC E2
light
2 Outdoor coil pipe TEMP. sensor failure Flash 2 time/8 SEC E3
light
3 Over current protect of compressor Flash 3 time/8 SEC E7
light
4 TEMP. sensor of exhaust failure Flash 4 time/8 SEC E1
light
5 Communicate failure Flash 6 time/8 SEC E6
light
6 Module protection Flash 7 time/8 SEC E5
11. TROUBLE
SHOOTING
Indoor Tr sensor
error
NO
Is CN (Tr sensor connector)
Connect CN properly.
connected properly?
YES
YES
NO
Is CN (TP1 sensor connector)
Connect CN properly.
connected properly?
YES
NO
Is TP1 sensor resistance value
Replace TC sensor.
(5KO at 25? ) normal?
YES
Does
compressor YES
continue to
operate?
NO Is it possible to detect AC
220V between NO Replace main
pin(high/middle/low) and
P.C. board.
Start to operate indoor pin(common) of motor
unit in cooling connector .
operation at airflow
level LOW ,wait
three minutes..
YES
NO Replace
Is capacitor of indoor fan ok?
capacitor
YES
Does OPERATION NO
Check power supply.
indication indicate?
YES
Is it possible to detect AC
220-240V on terminal NO Microcontroller is defective or
Replace P.C. board.
block or contactor of miniature relay is defective..
compressor?
YES
YES
Is compressor motor NO
winding normal?(Check Compressor is defective. Replace compressor.
winding resistor.)
YES
Is capacitor for NO
Capacitor is defective. Replace capacitor.
compressor normal?
YES
NO Replace overload
Is overload relay normal? Overload relay is defective.
relay.
YES
NO
Does compressor start? Compressor is defective. Replace compressor.
YES
YES
YES
YES
Compressor is defective. Replace compressor.
Press START/STOP The unit does not beep at all.
button. OPERATION indication on
indoor unit is not indicated.
Is transmission NO
mark indicated?
YES
YES
Does indoor unit
Is there any thyristor NO NO operate when
fluorescent light moving remote
nearby? control near receiver
YES or indoor unit?
YES
YES Press START/STOP
button.
Batteries are
exhausted.
YES
Does radio sound is
affected by remote
control when a NO
signal is transmitted
at distance of 5 cm
from radio?
YES
Remote control is
defective.
P.C. board is
defective.
YES YES
Does outdoor unit run? Is the power normal? check NO Check the wiring of indoor and
the voltage between L&N of
outdoor
terminal block
YES
NO Check the
Does the YES
compressor ,wires
compressor run and it s Does the control NO
normally? Press the power ON/OFF button
capacitor. ok?
of wire control or remote control
YES
YES Does the beeper NO
Does the indoor Normal Control failure
unit run? beep?
YES
NO YES Does the control
PCB ok?
Check the failure code NO Is the display all
according to the failure off?
table
YES
NO
Check the connector on display
PCB connected to control PCB Control PCB failure
Check the display PCB itself
Indoor unit and outdoor unit don t operate
YES NO
Find the reason and NO Is the insulation of Press emergency key, does Replace remote
YES
replace the failure indoor unit and outdoor the air conditioner receiver or display
componet. unit no problem? running? panel.
YES
NO
YES
NO
NO Is the resistance of each NO
Rreplace the failure Does the transformer has
main component no Replace transformer.
componet. output?
problem?
YES
YES
normal