Beruflich Dokumente
Kultur Dokumente
K6ROT
S-1
Defaults for SNORM and K6ROT in V2001
S-2
Defaults for SNORM and K6ROT in V2001
(cont.)
The default combination in V2001 may cause problems in
cases where forces are transferred through the drilling
degree-of-freedom.
S-3
Effect of K6ROT – Flagpole Example
Intentional loading of the drilling degree-of-freedom in shells
may be discredited as bad modeling practice.
S-4
Effect of K6ROT – Ring with Stiffener
Example
Unintentional loading of the drilling degree-of-freedom occurs in
some cases, for example, in stiffened shells modeled with
beams and offsets.
Z 10
R= 246
2
246
n
Θ 2
246
246
246
246
S-5
Effect of K6ROT – Ring with Stiffener
Example (cont.)
K6ROT SNORM Offset Disturbance Comments
With PARAM, K6ROT, 100., we always get 6 rigid body modes for a
free system, here we get only 1 rigid body mode due to symmetry
conditions
What’s New in MSC.Nastran 2004, July 2003
S-6
Why is K6ROT= 100. a Good Value ?
SPC =
123456
0.5
0.5
T= 1.e-4
Y
X 1.0
S-7
Why is K6ROT= 100. a Good Value ? (cont.)
Fine Meshes
1.0100 64x64
Normalized Tip Displacement
1.0000
32x32
0.9900
0.9800 16x16
0.9700
0.9600
0.9500
8x8
0.9400
0.9300
4x4
0.9200
0.9100
0. 10. 100. 1000. 1e +4 1e +5 1e +6
K6ROT
S-8
Why is K6ROT= 100. a Good Value ? (cont.)
Coarse Meshes
1.0000
4x4
Normalized Tip Displacement
0.9000
0.8000
2x2
0.7000
0.6000
0.5000
1
0.4000
0.3000
0.2000
0.1000
0. 1.e+1 1.e+2 1.e+3 1.e +4 1.e +5 1.e +6
K6ROT
S-9
K6ROT With and Without SNORM
Z 1N
S-10
K6ROT With and Without SNORM
•Shell normals reduce impact of K6ROT in Curved Shells
Effect of K6ROT in the Hook Example
Normalized Tip Displacement
5.0
3.0
2.0
QUAD4 With Normals
1.0
0.0
0 1.0 1.e+2 1.e+4 1.e+6
K6ROT
20 x 136 Mesh
MID3=1 with transverse shear flexibility
S-11
New Default for K6ROT
The membrane test shows that K6ROT=100. is the best
choice.
S-12
New Default for K6ROT (cont.)
K6ROT=100. has always been the default in nonlinear
SOLs 106 and 129
S-13
Remark for New K6ROT Default
S-14