Beruflich Dokumente
Kultur Dokumente
Nuventura GmbH
WELDING PROCEDURE SPECIFICATION (WPS)
Company Name: Nuventura GmbH
Preheat and Interpass Electrical Initial and Interpass Cleaning: Grind to re-
Temperature (QW-406) Characteristics move cutting oxide, solvent clean to remove
(QW-409) cutting oil. Grind or wire brush to remove
Minimum Preheat: 50F Current Type: DC slag or silica deposits.
Maximum Interpass: 350F* Polarity: See Table Orifice or Gas Cup Size: #4 to #12
Preheat Maintenance: Not Required Amperage: See Table Oscillation: N/A
Gas (QW-408) Electrode Feed Speed: N/A Contact Tube to Work Distance: N/A
Shielding Gas: 100%Argon Voltage: N/A Multiple or Single Pass: Either
Composition: Welding Gr. Multiple or Single Electrode: N/A
Flow Rate: 8-20 CFH Travel Speed: See Table Peening: Not Permitted
Gas Backing: Ar or N at Tungsten Type: 2% Thoria Other:
5-15 CFH Tungsten Size: 3/32, 1/8 When welding different types of 300 series
Trailing Shield: None stainless to each other, select a filler metal
Pulsed Current: None
designated for both types.
Filler M etal Current Travel Other
Welding
Weld Layer Volts Speed * Base
Process Class Dia. (in) Type/Polarity Amps Filler M etal
(ipm) M etal
1 GTAW As Above 3/32 or 1/8 DCSP 60-100 2-4 304 308, 308L, 316, 316L
2 GTAW As Above 3/32 or 1/8 DCSP 70-100 2-4 304L 308L, 316, 316L
Balance SM AW As Above 3/32 DCRP 40-80 2-4 316 316, 316L
Balance SM AW As Above 1/8 DCRP 65-110 316L 316L
2-6
Balance SM AW As Above 5/32 DCRP 100-150 321,347 308L, 321
Balance SM AW As Above 3/16 DCRP 120-190 4-8 *These values are recommended
only, not mandatory
The undersigned contractor, a member of the Nuventura GmbH, hereby adopts this jointly developed procedure
as its company Welding Procedure Specification and certifies that this procedure has been qualified
Contractor: By:
Title:
WPS 11-23-1
Typical Joint Designs
Other joint designs shown on Engineering drawings supersede these joint details
Butt welds
30 to 45 30 to 45
3/32 to
1/8 3/32 to 1/8
See note 1
See Note 1 3/16 Nom. 3/32 to 1/8
Note 1: 1/8 inch maximum except for B31.1 and B31.5 work, 1/16 i nch maximum
X 1/16 min
Approximately
1/16 before
X
Smaller of
T or 1/4 Z