Beruflich Dokumente
Kultur Dokumente
Free or Demo test for GATE-2010 All India Test Series In Aerospace(sectional test)
()
c) ()
d) ()
a) [ ()] b)(-1)n [ ()]
c) (-1)n [ ()] d) (-1) [ ()]
Q.3) The general solution of the equation = is
a) +Cey+1=0 b) +Cex+1=0
Q.4) The order of the differential equation of the family of curves ax2+by2=c is
a) Uniformly d) linearly
c) parabolically d) hyperbolically
b) [(
− ) + ( − ) + ( −
) ]
c)
[(
− ) + ( − ) + ( −
) ]
d) [(
− ) + ( − ) + ( −
) ]
Q7.) A column of solid circular cross-section and length L can have various end condition. Choose the
correct set that matches the end condition (listed in group I) with the corresponding effective length for
buckling (listed in group II).
Q.8) For two shafts connected in parallel find which statement is true
Q.9)The maximum thickness to chord ratio for the NACA 24014 airfoil is
Q.11) According to kutta-joukowski theorem, the circulation at the trailing edge of the airfoil is
Ques.12 Consider the lifting flow ones a circular cylinder with given radius and circulation. If !∞ is
doubled keeping the circulation same then the shape of the streamline
Q.13) According to thin airfoil theory of symmetric airfoil the quarter code point is
Q.14) For an elliptic orbit of satellite, let the smallest distance form centre of primary be "#$% and
(
greatest distance "#& . Then ' ) *(sectorial velocity) for the satellite in terms of "#$% +,- "#& is
Where you assume primary is earth and K=√/0, = 22,"3234 56 773832 5"93
:;< :;=>
a=
C C
?@ (
A)&B ?@ ?
A B&B
a) b)
D
C C
?@ (
A)&B ?@ ?
A B&B
c) d)
D
Q.15) For a fixed centre of gravity location of an airplane, when the propeller is mounted on the nose of
the fuselage
Q.16) let an airplane in a steady level flight be trimmed at a certain speed. A level and steady flight at a
higher speed could be achieved by changing
Q.17) An airplane model with a symmetric airfoil was tested in a wind tunnel .Cmo (Cm at angle of attack,
α=0) was estimated to be 0.08 and 0 respectively for elevator settings (E ) of 5 degree up and 5 degrees
FG
down. The estimated value of the elevator control power ( FHA; ) of the model will be
Q.18) A centrifugal pump is discharging 4500lit/min and operates at 1800rpm.If this pump is required to
operate at 1200rpm assuming its efficient remains same then the discharge is
b) That the relative velocity vector should have the same direction as that of the tangent at the inlet tip
of the blade.
c) That the absolute velocity vector should be tangential at the inlet tip of the blade.
Q.20)which one of the following values is nearer to the vacuum specific impulse of a rocket engine using
liquid hydrogen and liquid oxygen as propellants.
Q.21) The order of the differential equation of the family of all circles in the xy-plane with their centers
lying on the parabola x=y2 is
a) 1 b) 2 c) 3 d) 4
I
Q.22) The differential equation I + 3 + − 4=0 with the boundary conditions y (1) =5 and y (2) =7
has
N KLM )KLM D)
Q.23) JO
)
-, equals to
Q.24) L-1 ((
)P)=
Q.25) solve Q + Q – 4y=Q
RST
RST
a) y=C1x2 + C2 − b) y = C1 +C2 x2 −
D D
RST RST
c)y = C1 x2 +C2 + d) y=C1 Q +C2 x +
D D
FU FU
Q.26) If p=F & q=F , then the partial differential equation from Q + 4 + (V − 2) = W ,where a & c
are arbitrary constants is
a)X = Y b) Y = X c) X = Y d) Y = X
Q.27) x − 4 = QZQ + 4 , then the solution is, where A is a constant
a)[1 + − = ] b) [1 + + = ]
c) [1 − + = ] d) [1 + + = ]
Q.28) The von Mises yield criterion or the maximum distortion energy criterion for a plane stress
problem with
and as the principal stresses in the plane and as the yield stress requires
a) − + ≤ b)| | ≤
c)| | ≤ d) | | ≤
Q.29) An Euler-Bernoulli beam having a rectangular cross-section as shown in the figure, is subjected to
`
non-uniform bending moment along its length.!U =
. The shear stress distribution aU across its
cross-section is given by
b U bc?fgB U
a) aU = dc fg b) aU = (1 − )
e de (fg)
b U bc?fgB
c) aU = c (f ) d) aU =
d e g de
z !U
Q.30)A beam of I cross-section, as shown in fig. is subjected to a shear force V=100KN. The stress on the
section AA (with 5.6304 x 106 mm4)(A=1920 mm2) is
Q.31) A circular rod of length L and torsional rigidity GJ is fixed at one end and free at the other end if a
twisting moment T is applied at a distance of L/2 from the fixed end, the angle of twist at free end will
be
hi hi hi hi
a)j b) j c) d)
j j
Q.32) The bending moment distribution in a beam as a function of distance x is given by M=5x2+20x-7N-
m the shear force at x=2m is
Q.33) A beam of rectangular cross –section is subjected to transverse loads.In a section where the shear
stress at 1/4th of the beam depth is 120 MPa,the maximum shear stress is
Q.34) A thin wire of 2mm diameter with young’s modulus 200GPa is wrapped around a drum of
diameter 8m. The maximum bending stress in the wire is
Q.35) If a thin spherical shell is subjected to an internal pressure then change in volume will be equal to
kX
kX
a) D)l '1 − #* b) '1 − *
m)l #
kXn
kX
c) (1 − #) d) (1 − #)
m)l m)l
a) The ratio of power utilized by runner to that supplied by the water at entry to the turbine.
b) The ratio of power supplied by water at entry to the power utilized by runner.
c) The ratio of power available at the turbine shaft to that supplied to it by the runner
d) The ratio of power supplied by the runner to the power available at the shaft
Q.37) The following table list various kinds of boundary layer thickness and the corresponding equation
are given in the second column, not necessarily in that order. Match each boundary-layer thickness with
its mathematical-equivalent expression
Column -1 column-2
H o o
A) Nominal thickness 1)JO '1 − * -4
pq pq
H o o
C) Momentum thickness 3) JO '1 − * -4
pq pq
H o
D) Energy thickness 4) JO '1 − p * -4
q
A) B) c) d)
a) 2 4 1 3
b) 1 2 2 2
c) 3 1 3 4
d) 4 3 4 1
Q.38) Experiment were conducted in a wind tunnel with a wind speed of 60 Km/hr on a flat plate 2m
long and 1m wide. The specific weight of air is 1.15kg/m3. The plate is kept at such an angle that the
coefficients of lift and drag are 0.75 and 0.15 respectively. What are the lift and drag forces?
Q.39) Suppose the gravitational force varies inversely as the nth power of the distance. Then the time
period of a planet in circular orbit of radius R around the sun will be proportional to
Q.40)The largest and shortest distance of earth from the sun are r1 and r2 .Its distance from the sun
when it is perpendicular to the major axis of the orbit drawn form the sun is
:C : : : :C : :C :
a) b) :C : c) : d)
D C C :
Q.41)A missile is launched with a velocity less then zero escape velocity. The sum of its kinetic energy
and potential energy is
Q.42)A satellite is moving around the earth with the speed v in a circular orbit of radius r,if the orbit
radius is decreased by 1% its speed will
Q.43) what is the velocity change required to transfer a satellite from a circular 600Km orbit with an
indination of 28 degree to an orbit of equal size with an inclination of 20degree.(Re=6378Km)
Q.44) An airfoil section is known to generate lift when placed in a uniform stream of speed rN at an
incidence ∝ .A biplane consisting of two such section of identical Chord C, separated by a distance h is
shown in the following figure:
b) Both the airfoil experiences an down wash and a decreased approach velocity.
c) Both the airfoil experiences an up wash and airfoil A experiences a decreased approach velocity while
airfoil B experiences a increased approaches velocity.
d) The incidence for the individual sections of the biplane is not altered
Q.45) An ideal ramjet is flying at a Mach number M. The exhaust gas static temperature at the outlet of
the nozzle is Te. The ambient static temperature is Ta. Gas constant R and specific heat ratio t do not
very through the ramjet. Assuming that nozzle exhaust static pressure is equal to the ambient pressure
and fuel air ratio f<<<1, the thrust per unit mass flow rate is
h h
a)Ztuv& w[hx y b) Ztuv& w[hx − 1y
= =
h h
c)0 Ztuv& w[hx − 1y d) 0Ztuv& w[hx y
= =
Q.46) The polytrophic efficiency of the compressor is 85%. If the ideal outlet temperature of the
compressor is twice that of the inlet, then what is the isentropic efficiency of the compressor? (take
t& = 1.4 +,- tT = 1.33)
Q.47) A satellite in Earth orbit has a semi-major axis of 6,700Km and an eccentricity of 0.01. What is the
satellite’s altitude at perigee?
Q.50) The wing dihedral, which is the angle between the plane of each wing and the horizontal when the
aircraft is unbanked and level and is (+ve) when wing lies above horizontal plane through its root
contributes
Statement:-An axial flow compressor has an overall pressure ratio of 4.0 and mass flow of 3Kg/s. If
the polytropic efficiency is 88% and the stagnation temperature rise per stage must not exceed 25K
Assume equal temperature rise in all stages (Ambient stagnation condition are 1.01 bar,
288K)(Assume t = 1.4)
a) 8 b) 6 c) 7 d) 5
statement: A planet of mass M has three satellite of equal mass m, each moving in the same circular orbit of
Radius R. satellites are equally spaced and form an equilateral triangle.
`
`
(c)r = (} + √ }) (d) r = '30 + }*
| | √
Q.54.The orbital speed of each satellite such that they maintain this confrigration is
# ` 1/2 ` # 1/2
(a) V= (√| − |
) (b) V= (
|
+
√|
)
Statement:
Consider a vortex filament and straight line through the centre of the loop , perpendicular to the
plane of the loop .
Q. 55) The expression for a velocity at a distance A on the line ,as induced by the vortex filament is
where ( Γ is the circulation )
C I
a) ΓR/2(A + R ) b) ΓRA/2(A + R )
C I
c) ΓA/2(A + R ) d) ΓR /2(A + R )
a)0
b)|
Γ
c) m|
Γ
d) D|
Γ
k & k
a) + tan
( ) b) − tan
(&)
k & k
c) − tan
( ) d) + tan
(&)
N M
)
Q.58)JO dt equal to
)
k k k k
a) D b) c) d)
D
A turboprop engine operates at an altitude of 3000 meters above mean sea level and an aircraft speed
of 525 Kmph. The data of the engine is given below:
Compressor efficiency=0.790
Q.59) what is the pressure rise through the inlet diffuser?(Use above data)
Q.60) what is the air standard efficiency of the engine?( use above data)