Beruflich Dokumente
Kultur Dokumente
CBP consumption based planning use hostorical data to calculate the future requirements with the
help of material forecast or static planning procedures. Net requirements calculation is not triggered
by an independent or a dependent requirement. In nutshell net requirements calculation is triggered
when stock levels falls below a reorder point or by forecast requirements calculated from past
consumption data.
MRP procedures supported in consumption based planning are:
Forecast-Based Planning
Time-phased planning
This document we will discuss the usage of Manual Reorder Point Planning.
Manual Reorder Point Planning : In manual reorder point planning both the reorder level and the
safety stock level manually maintained in material master.
Automatic Reorder Point Planning : In automatic reorder point planning, both the reorder level and
the safety stock level are determined by the integrated forecasting program.
Manual Reorder Based Planning:
Master Data for Raw Material to be Maintained: ( Material Master – MM01/MM02)
In MRP1 View, MRP Type as VB -Manual reorder point planning. Once VB is selected system will
prompt to enter the reorder point. Based on the quantity entered in reorder point, if stock falls below
the reorder point system will plan the procurement proposals during MRP run. For the given example
reorder point maintained as 100.
Another important field is Lot size. What lot size system should plan incase stock falls below the
reorder point. Generally recommended lot size for reorder point planning is to go with lot size HB
-Replenish to maximum stock level. Once lot size is maintained as HB system will prompt to enter to
Maximum stock level. For the given example Maximum lot size maintained as 400.
e
Stock Requirements List: (MD04)
As displayed below current stock for Raw Material SPICES is Zero. Ie; Available stock is less than
reorder point. For the given example safety stock is not considered.
PR converted to Purchase Order for Qty 10 and again executed MRP(MD03). Now PR generated for
390 Qty as shown below. Why?? System considers the available purchase orders and available
stock during MRP. Considering the both if still stock is less than the reorder level, then PR will be
generated for the max lot size qty – (Stock + purchase orders). Hence PR generated for (400 -
(0+10)) = 390 qty as diplayed in below screen shot.
Raw Material SPICES is BOM item for FERT Material BEEFMORTADEL. Production order created
for 500 qty for FERT BEEFMORTADEL as shown below. Now Question is Will the dependent
requirement qty of 500 for Material SPICES will be considered by MRP?? Answer is NO. MRP will
not consider the dependent requirement quantity for reorder point raw materials.
After Order creation again MRP(MD03) executed for material SPICES. As displayed below PR is for
390 qty only. Production Order adtional requirement qty is not considered by MRP.
Open PR converted to PO and further GR completed for both PO and stock updated to 400 as
shown below.Now stock is more than the reorder point level. Executed MRP (MD03) for the material
SPICES, but as discussed already MRP did not consider any dependend requirements and hence
no addtional PR is generated as shown below.
Another 200 qty issued against the order, now stock is Zero as displayed below.
If MRP is executed what is expected?? PR should be generated. Yes..As stock is less than the
reorder point upon MRP run system generated PR for Max lot sixe 400 qty as displayed below.
Note: If MRP Type is maintained as VB with reorder point for FERT/HALB materials then during
MRP run system also considers the respective production orders qty for the FERT/HALB material as
available quantity. If purchase order exists for the material then that also is conisdered as available
qty.
Eg: HALB 1 – Stock 0, Reoreder point 100, Max Lot size is 400, Production Order for 10 qty. Then
PR Qty = 400 – (0+10) = 390 qty.