Beruflich Dokumente
Kultur Dokumente
Power-Frequency Control
ElmSecctrl
DIgSILENT GmbH
Heinrich-Hertz-Str. 9
72810 - Gomaringen
Germany
http://www.digsilent.de
info@digsilent.de
Version: 2016
Edition: 1
Copyright © 2016, DIgSILENT GmbH. Copyright of this document belongs to DIgSILENT GmbH.
No part of this document may be reproduced, copied, or transmitted in any form, by any means
electronic or mechanical, without the prior written permission of DIgSILENT GmbH.
Contents
1 Power-Frequency-Control 3
1.1 Concept . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
List of Figures 6
1 Power-Frequency-Control
1.1 Concept
The task of the Power-Frequency-Control is to set the active power balance as typically done
by secondary control. If an unbalance between the scheduled active power values of each gen-
eration unit and the loads plus losses occurs, primary control will adapt (increase/decrease)
the active power production of each unit, leading to an over- or under-frequency situation.
The secondary frequency control will then control the frequency back to its nominal value, re-
establishing a cost-efficient generation delivered by each unit.
Please consider that the Power-Frequency-control only will be active if the load-flow calculation
setup dialog, Sub-page “Active Power Control” is using According to Secondary Frequency
Control.
Please multi-select the active power sources (synchronous machines) and the bus whose fre-
quency should be controlled. Remember that a multi-select is made by (left-)clicking the first
element (e.g. the bus) and keeping the Control key pressed while clicking on the remaining
elements (e.g. the synchronous generators). The dialog as shown in Figure 1.1 should appear.
• Frequency Control
The global frequency in the system is controlled by the units listed
• Power-Frequency-control
The active power exchange of the zone the bus mentioned belongs to is controlled. Please
see the Manual for a description how to define zones.
Control Mode
Contribution of the different active power sources in controlling the frequency. The percentage
of each source to feed an actual value different from its set point can be set according to two
different options
Like for the station control, the Power-Frequency-Control is a PowerFactory element that can-
not be found in the graphic. However it is a specific calculation element, that is also listed when
selecting the icon Objects relevant for the calculation . It icon is shown as . If you experi-
ence problems with the Power-Frequency control, you may please check that you did not define
multiple Power-Frequency controllers for the same bus or zone, as these may result in conflicts
during the calculation.
List of Figures