Beruflich Dokumente
Kultur Dokumente
ORC-Energy Systems
GEOCAL®®
GEOCAL®
GERMANIA
GEOCAL
8
1 gen-set
Most of the time waste heat from in- 2 fuel tanks
1 Motor-BHKW
Electrical Power Output: dustrial facilities has a low tempe-
3 4 3 exhaust heat exchanger
2 Kraftstofftanks
0,05 – 5,0 MW rature (up to 400 °C),aus butIndustrieanla-
appears
Abwärmemengen 4 thermal oil cycle/
Thermal Power Input: in enormous volumes. This made it 3 Abgaswärmetauscher
gen sind häufig auf geringem Tempe- primary cycle
0,5 – 25,0 MW difficult to develop such large ener-
raturniveau (bis max. 300 °C), je- 1 5 thermal oil pump
4 Thermalölkreislauf/
Operating Time: gy potentials economically with the 6 pre-heater evaporator
Primärkreislauf
8.000 h p.a. doch oft mit gewaltigen Volumenströ-
classic water-steam process becau- 7 unit
Staff: men
se of highanzutreffen.
investmentAus costsdiesen
and low Grün- 5 Thermalölpumpe
7 fresh steam pipe/
0,1 – 0,4 Employees den konnten bislang derartige
thermodynamic efficiency factors.große 6 Vorwärmer-
secondary cycle
Energiepotentiale mit dem klassi- 8
9 8 Verdampfer-Einheit
ORC-turbine
Theschen Wasserdampfprozess
INDUCAL-process offersaufgrund
the 9 generator
7 Frischdampfleitung/
possibility to efficiently transform
hoher Investitionskosten und geringer 10 condenser
10
6 5 Sekundärkreislauf
these energy potentials
thermodynamischer Wirkungsgradeinto elec- 11 condensate-feed pump
8 ORC-Turbine
tricity 12 cooling cycle
nichtwith the ORC-process.
ökonomisch erschlossenForwer-
the optimal use of the heat sour- 9 Generator
den.
ce a working medium is selected, 10 Kondensator
Das INDUCAL®-Verfahren bietet hier
depending on the temperature
die Möglichkeit, diese Energiepoten- 11 Kondensat-Speisepumpe
and the quantity of the exhaust, 11
thattiale
will mit
showHilfe des ORC-Prozesses
a preferably high 12 Kühlkreislauf
evaporation pressure at the ex- zu
effizient in elektrische Energie
wandeln.
pected Für die
working optimale Nutzung
temperature of
the der
cycle. The pressure
Wärmequellen wird jelimit
nachin Tem-
a plant has to be less than
peratur und Quantität des Abgasstro- 20
barsmes to ein
conform with the Steam
Arbeitsmedium bestimmt,expanded, gaseous working fluid and thermal power inputs starting The electrical efficiencies of the IN-
Boiler
welchesCodebei(DampfkV). Becau- is transferred
den zu erwartenden In diesemfrom the ORC-turbo
Expander-Generator- at 2 MW;
dium INTEC GMK
abzugeben. operates derDUCAL-modules
Eine Nutzung Leistungsbereichrange from 9Kosten-
vor allem to
se of this it is possible to operate generator directly into the recupe- with axial ORC-turbines. At these 21 percent, depending on the qua-
Arbeitstemperaturen im Kreisprozess Aggregat wird die thermische Energie Kondensationswärme ist oft nicht vorteile gegenüber der Turbine auf-
INDUCAL-ORC power plants fully rator- condenser unit to be lique- applications the ORC can be coo- lity of the heat source.
einen möglichst hohen Verdamp- des Arbeitsmediums in elektrische möglich, da die Kondensationstem- weisen. Die elektrischen Wirkungs-
automated without supervision ac- fied as also to give its remaining led directly by the ambient air for
fungsdruck
cording to theaufweist. Als obere
Steam Boiler Code. Gren- Energie gewandelt. Anschließend peratur
highest nur etwas
electrical über der Ac-
efficiencies. Umge- grade der INDUCAL®-Module liegen
energy to the liquid working medi-
Incoming industrial waste heat can umwird
ze für die Drücke innerhalb der Anla- dascounter
in the entspannteflow.noch gasförmige bungstemperatur
cording liegt. INDUCAL
to the temperature of the - je nach Qualität der Wärmequelle
®
ge ist dieusing
be collected Dampfkesselverordnung
a thermal oil cy- Using Arbeitsmedium aus dem
the condensation heat Expander
is not heatAnlagen
source werden
also hot in water for he-Fäl- zwischen 9 und 21 %.
den meisten
cle (DampfkV)
(primary cycle) maßgebend,
and transferred direkt in
wodurchpossible die ofRekuperator-Kondensa-
most the time, becau- lenpurposes
ating stromgeführt
can be betrieben.
provided byDie
witheine
the Beschränkung
pre-heater vaporizer unit se tor-Baugruppe
der Betriebs- the condensation überführt, um dort
temperature the erzeugte
ORC condenser.
elektrische Energie steht für
to the working fluid (secondary cy-
drücke unterhalb von 20 bar gewähr-liesverflüssigt slightly higher
zu werden thansowie
the ambi-
die Rest- die Deckung des Eigenbedarfes der
cle)leistet
whichwird.is inHierdurch
the ORC-module. ent air temperature.
wird es mög- energie an das sich im Gegenstrom Most of the At Industriebetriebe
smaller thermalzurinput poweroder
Verfügung
After
lich,this process®-ORC-Anlagen
INDUCAL the vaporizedvoll-time INDUCAL-power
befindliche verflüssigte plants are
Arbeitsme- ranges
kann forin dasexample from
öffentliche Netzsmall
gespeist
Philosophie
power-operated. Therefore the gen-sets or „low enthalpy“ heat
automatisch, ohne Beaufsichtigung werden.
produced electricity can be used sources such as industrial water
Das Potential der zur Verfü- hinsichtlich der DampfkV, zu betrei- Bei den verwendeten Expansionsma-
to supply the industrial companies cooling cycles the screw expanders
gung stehenden Abwärme ben. schinen handelt
technology is used.esHeresich the
je nach
ORCLei-
themselves or can be fed into the
aus Industrieanlagen ist in Anfallende Industrie-Abwärme kannpower grid. stung der
is always Wärmequelle
cooled directly byum theTurbinen
am-
einer Größenordnung vor- durch einen Thermalölkreislauf (Pri- oder
bient air.Schraubenmaschinen.
Screw expanders distin- Ab einer
handen, dass ca. 5-8 Pro- märkreislauf) gesammelt und in derThe choice of expansion machine thermischen
guish themselves Leistung
to bevon ca. 2 MW
extremely
zent der industriell benötig- Vorwärmer-Verdampfer-Einheit antechnology depends on the thermal robust
wirdatdieevery part load case.
ORC-Turbine Due
der Baureihe
ten Elektroenergie Europas das Arbeitsmedium (Sekundärkreis-power and temperature level of the to the patented variable expander
AFA 10 der Firma AG KK&K einge-
aus Abwärmeressourcen working
lauf) medium is run through
im ORC-Kreislauf the heat source and can be either a
übertragen geometry
setzt. Beiadjustment and modu-Lei-
kleineren thermischen
ORC-turbine. In this ORC-turbo turbine or a screw expander. lar units highest efficiencies and
erzeugt werden können. werden. Das verdampfte Arbeitsme- stungen kommen Schraubenexpan-
generator the thermal energy of highest operation flexibility can be
(Quelle: MBB Studie 8/91) dium wird einem Expander zugeführt. der zum Einsatz, welche in diesem
the working medium is transfor- For the electrification of „high ent- granted.
med into electricity. Afterwards the halpy“ heat sources above 300°C
INTEC - at home worldwide
INTEC Service GmbH INTEC Energy Systems Sdn Bhd INTEC Heating Solutions Pvt. Ltd.
John-Deere-Str. 43 6F-21, IOI Business Park, B - 410/A, Galleria
D-76646 Bruchsal, Germany Bandar Puchong Jaya, Opp.Bayer House, Hiranandani Gardens
Tel.: +49 7251 93 243-41 47170 Puchong, Selangor, Powai, Mumbai - 400 076
Fax: +49 7251 93 243-97 Malaysia India
E-Mail: service@intec-energy.de Tel.: +603 5891 6642 Tel.: +91 22 322 690 50
Fax: +603 5879 9824 Fax: +91 22 421 560 94
E-Mail: yap.fw@intec-energy.de E-Mail: bharat.k@intec-energy.de
INTEC UB Pte Ltd.
4 Battery Road
INTEC GMK GmbH
Bank of China Building Schneider Engineering GmbH
Reuterstraße 5
#25-01 Hildburghauser Str. 79
D-18211 Admannshagen-Bargeshagen
Singapore 049908 D-12249 Berlin
Tel.: +49 38203 775814
Tel.: +65 6408 8000 Tel.: +49 30 7544 9399-0
Fax: +49 38203 775820
Fax: +65 6408 8001 Fax: +49 30 7544 9399-21
E-Mail: info@gmk.info
E-Mail: info@intec-ub.com E-Mail: info@schneider-kessel.com
www.intec-ub.com
www.intec-energy.com
INTEC products
■ Heat transfer oil heaters ■ ORC power generation