Beruflich Dokumente
Kultur Dokumente
Download
BSNL JTO(EE) 2010 from www.JbigDeaL.in Powered By © JbigDeaL
www.estudentzone.com
™
J
J
B
B
I Set-D ELECTRICAL ENGINEERING I
G
G
D SECTION-I D
s 2 64
E QUESTION NUMBER 1-20 transfer function G s are, E
s 2 12s 100
A
CARRY 1 MARK EACH respectively, A
L a. 10 and 1.2
L
b. 10 and 0.6
J 1. The main scale of a vernier calliper is ruled in c. 8 and 1.2
J
1 mm units. The vernier scale is 49 mm long d. 8 and 0.75
B B
and divided in 50 units. The resolution of the 8. The gain at the breakaway point of the root
I vernier calliper is locus along the real axis of a unity feedback I
a. 0.002 mm system with the transfer function
G G
K
D
b. 0.005 mm G s 2 is
c. 0.01 mm s s 1 D
E d. 0.02 mm a. K = 0 E
2. A frequency counter with a gating time of 50 b. K = 0.5
A A
ms counts 1254 cycles of an input square c. K = 1
L wave. The frequency of the input wave is d. K = 1.25 L
a. 39.87 Hz 9. Gain margin of the unity feedback system with
J b. 62.70 Hz 100 J
c. 1.254 kHz the loop transfer function G s is
B d. 25.08 kHz s 13 B
L
4. Wattmeters are based on the principle of a. stable L
a. permanent magnet moving coil meter b. unstable
b. electrodynamic meter J
J c. marginally stable
c. electrostatic meter d. sustained oscillatory B
B
d. moving iron meter 11. The unit of the permittivity of free space (0) is I
I 5. The resolution of a Gray-coded optical shaft a. C2 N–1 m–2
encoder with 10-bit output is approximately b. C2 N m2 G
G
a. 0.098° c. C–2 N m2 D
D b. 0.176° d. C–2 N m–1
E
c. 0.225° 12. A positively charged object is placed in the E
d. 0.352° centre of a room with a uniform magnetic A
A 6. If y(t) Y(s) indicates a Laplace transform field. If the magnetic field is pointing east, the
pair, then y(t) for t0 when L
L object will
2 s
3 3e a. move east
Y s is J
J
s 2 s 3 b. move north
B
B c. move south
2t
3e 3e 2t
a. d. remain stationary I
I
13. The input impedance of a quarter-wave long
b. 3e 3e 3 t 2 u t 2
2 t 2 G
G short-circuited lossless transmission line is
a. purely reactive D
D c. 3e 3e 3e t 2 3e 3 t 2
2 t 3t 2
b. purely resistive E
E c. infinite
d. 3e2t 3e3t 3e 2 t 2 3e3 t 2 u t 2
d. dependent on the characteristic impedance A
A
7. The undamped natural frequency in rad/s and of the line L
L the damping ratio of the system with the 14. For a plane wave propagating in the free
space,
JbigDeaL JbigDeaL JbigDeaL JbigDeaL Download from www.JbigDeaL.in Powered By © JbigDeaL JbigDeaL JbigDeaL JbigDeaL JbigDeaL
JbigDeaL JbigDeaL JbigDeaL JbigDeaL
VA = 600 t u(t+1) V, VB = 600(t+1) u(t) V and galvanometer having a full scale current of
D D
IC = 6 (t—1) u(t—1) A, where u(.) denotes the 100 A. The value of shunt resistor required
E unit step function. For this circuit, the current i for obtaining an ammeter of full scale current E
c. 1.1 J
J
d. 10.0
B
B 23. An average responding analog ac voltmeter
using half wave rectifier to read RMS value of I
I
the input sinusoidal voltage. If the meter reads
a. -9 A G
G 24 V for a square wave input with zero mean,
b. -6 A D
D the actual RMS value of the input is
c. -1 A
d. 0 A 24 2 E
E a. V
19. Assuming the transformer in Fig. I.19 ideal, A
A
the effective value of the load seen by the 24
source is b. V L
L 2
J
J 48 2
c. V
B
B
24 I
I
d. V
2 G
G 24. A resistance is measured by the voltmeter-
D
D a. 0.5 ammeter method. The voltmeter reading is 25
b. 50 V on the 100 V scale and the ammeter reading E
E
c. 500 is 250 mA on the 500 mA scale. Both meters
A
A d. 5000 are accurate within ±1 per cent of full-scale
20. If an electrical transformer and a mechanical reading. The maximum possible error, in L
L percent of measured value of the resistor is
gear system are considered analogous to each
JbigDeaL JbigDeaL JbigDeaL JbigDeaL Download from www.JbigDeaL.in Powered By © JbigDeaL JbigDeaL JbigDeaL JbigDeaL JbigDeaL
JbigDeaL JbigDeaL JbigDeaL JbigDeaL
D D
Gain in dB -20 -20.5 -26 -60
E E
A
Phase in
0 0 -90 -180 A
Degree
L L
0.9
a.
J
s 3 2
J
0.9 B
B b.
s s 3
I I
a. 1 H 0.9
c. G
G
b. 0.1 H s 1 s 3
D c. 0.5 mH D
0.9
d. 0.2 mH d.
E
27. An RTD having a sensitivity of 0.4 /°C is s 1 s 30 E
A connected in a dc bridge having 100 fixed 32. The diagonal form of the state space A
resistors in other three arms. The bridge representation of a SISO system with the L
L
supply is 5.4 V with the RTD connected to Y s 3s 2 6 s 2
transfer function can be J
J zero potential and the bridge is balanced at U s s 3 3s 2 2 s
0°C. At room temperature the bridge B
B expressed as
unbalanced output voltage is 0.2 V with the
I RTD side of the output being positive. The 0 0 0 1 I
G
room temperature is x 0 1 0 x 1 u
G
a. 6.4°C a.
0 0 2 1 D
D b. 15°C
E c. 25°C y 1 1 1 x E
d. 40°C 0 0 0 1 A
A
x 0 1 0 x 1 u
28. The volumetric flow rate (Q) for a turbine
flowmeter with 8 blades in the rotor is given L
L b.
by Q = k, where the constant k = 2 × 10–5 0 0 2 1 J
J m3/rad and is the rotor angular velocity in y 3 6 2 x
rad/s. If a proximity device used to pick-up B
B
presence of rotor blades gives output of 48 0 0 0 1 I
I pulses/s, the flow rate is x 0 1 0 x 1 u
c. G
G a. 3 × 10–5 m3/s 0 0 2 1
b. 24 × 10–5 m3/s D
D
c. 9.6 × 10–4 m3/s y 0 1 2 x
E
E d. 12 × 10–4 m3/s
A
A
29. Which of the following conditions ensures that
exactly two roots of s3 + as2 + s + c = 0 lie in L
L the right half of the s-plane?
JbigDeaL JbigDeaL JbigDeaL JbigDeaL Download from www.JbigDeaL.in Powered By © JbigDeaL JbigDeaL JbigDeaL JbigDeaL JbigDeaL
JbigDeaL JbigDeaL JbigDeaL JbigDeaL
I
system are 2 rad/s and 0.5, respectively. When R0C0 R0 C0
I
the steady state error to a unit step input is 1 1 1
G zero, then the controller parameters are d. A ,B ,C G
R0C0 R0 C0
D a. K=4, a=3, b=2
38. A unit step sequence is applied as the input to D
b. K=1, a=3, b=2
E a system with the closed loop transfer function E
c. K=4, a=2, b=3
4z 2 8z 1
T z
A d. K=1, a=2, b=3 A
. The steady state error of
L
34. The transfer function of the system with the 12 z 2 5 z 2
state space representation L
the system is
1 0 0
1 u; y 1 1 x u is
1
J x a. J
0 1 15
B B
1 3
a. b. I
I
s 1 15
G 4 G
1 c.
b. 15
D s 1 11
D
E
c.
s 2 d.
15
E
L
d.
s 2 indicates that isolated magnetic charges do not
exist?
L
J
s 1 s 1
a. div Bdv 0 J
JbigDeaL JbigDeaL JbigDeaL JbigDeaL Download from www.JbigDeaL.in Powered By © JbigDeaL JbigDeaL JbigDeaL JbigDeaL JbigDeaL
JbigDeaL JbigDeaL JbigDeaL JbigDeaL
I plates is 0.3 mm and area of each of the plates between the points a and b are I
is 0.02 m2. If vacuum is used as dielectric
G G
between the plates, the voltage rating of
D capacitor is D
E
a. 0.118 mV
E
b. 118V
A c. 8.475 kV A
d. 8.475 MV a. IN = — 1.5 A, RN = 8
L
(Given that the permittivity of free space is b. IN = — 1.5 A, RN = 10 L
I I
G G
D D
a. 50/31 A E
E
b. 5/11 A
A c. 5/31 A A
a. –13.5 V
L
d. 0 A b. – 6.75 V L
45. The current (iC) through the capacitor in Fig. c. – 4.5 V
I.45 is J
J d. 0 V
a. 0 A 50. A balanced 440 V, 3 phase supply is driving a B
B
b. 0.625 sin(200t) A parallel combination of star and delta loads. If I
I c. 0.88 sin(200t — 45°) A
both the loads have resistance of 10 per
d. 1.25 sin(200t) A G
G phase, the supply current per phase is
46. The capacitor in Fig. I.46 is initially
D
44 D
discharged. At t = 0 s, the switch is closed. At a. A
t = 100 ms the current (IC) through the 3 E
E
capacitor is b. 44 3A A
A
176
L
c. A L
3
J
J d. 176 3 A
B
B
a. 0 mA I
I 4
b. mA G
G 5e
12 D
D c. mA
5e E
E 4
d. mA A
A e
L
L
JbigDeaL JbigDeaL JbigDeaL JbigDeaL Download from www.JbigDeaL.in Powered By © JbigDeaL JbigDeaL JbigDeaL JbigDeaL JbigDeaL
JbigDeaL JbigDeaL JbigDeaL JbigDeaL
D
a. MVI M, 8F
b. LHLD 8088 a. I and II D
JbigDeaL JbigDeaL JbigDeaL JbigDeaL Download from www.JbigDeaL.in Powered By © JbigDeaL JbigDeaL JbigDeaL JbigDeaL JbigDeaL
JbigDeaL JbigDeaL JbigDeaL JbigDeaL
JbigDeaL JbigDeaL JbigDeaL JbigDeaL Download from www.JbigDeaL.in Powered By © JbigDeaL JbigDeaL JbigDeaL JbigDeaL JbigDeaL
JbigDeaL JbigDeaL JbigDeaL JbigDeaL
generated emf is J
J
a. 505 V B
B
b. 502.5 V I
I
c. 497.5 V
G
G d. 495 V
D
D 36. A 250 V DC shunt motor has armature
a. E E
E resistance of 0.1 and shunt resistance of
b. DE 10. When connected to DC supply, it A
A
c. E/(1-D) develops a back emf of 242 V at 1500 rpm. L
L The armature current at the time of starting is
d. E(1-D)
JbigDeaL JbigDeaL JbigDeaL JbigDeaL Download from www.JbigDeaL.in Powered By © JbigDeaL JbigDeaL JbigDeaL JbigDeaL JbigDeaL
JbigDeaL JbigDeaL JbigDeaL JbigDeaL
I
b. 2 d. 125 I
G
c. 1.75 42. A 2.5 kVA, 100/400 V single phase G
D
d. 1.5 transformer has a leakage reactance of 0.06, D
E
measured from the primary side. The leakage
38. An induction motor operating at 0.8 pf lagging E
reactance (in pu) measured from the secondary
A is consuming 300 kW. A zero real power side of the transformer is A
consuming synchronous motor is connected
L a. 0.96 L
across the induction motor to raise the pf to
0.92 lagging. The reactive power drawn by the b. 0.9
J J
synchronous motor is
c. 0.015
B B
a. - 352 kVAR
d. 0.1
I I
b. - 225 kVAR
43. A single phase 50 Hz generator supplies an
G G
c. - 127.8 kVAR inductive load of 5000 kW by means of a 20
D d. - 97.2 kVAR km long overhead transmission line whose D
total resistance and reactance are 0.39 and
E 39. An interconnector cable having a reactance of E
3.96, respectively. The receiving end voltage
A
j0.05 pu links two generating stations G1 and is required to be kept constant at 10 kV. The A
G2 as shown in Fig. II.39 where |V1| = |V2| = 1 efficiency of transmission line when pf of load
L L
pu. The load demands at two buses are SD1 = is improved to 0.9 lagging is
15 + j5 pu and SD2 = 25 + j15 pu. The total J
J a. 98.08%
reactive power (in pu) at the generating station
B
B G1 when = 15° is b. 97.64%
I
I c. 82.1%
G
G d. 78.83%
D
D 44. Two generating stations G1 and G2 of ratings
E
10 MVA and 8 MVA respectively are linked E
by a line rated at 5 MVA, 0.1 Pu reactance.
A
A Each station has a reactance of 0.5 pu. If the
a. 25.68 base MVA is 10 MVA, short-circuit MVA of L
L
b. 25 G1 is
J
J a. 36.6
c. 5.68 B
B b. 34.28
d. 5 I
I c. 32.15
40. A 10 MW generator is connected to load
G
G through a transmission line. If the incremental d. 10
dF D
D cost of production is 0.1P 3 Rs./MWhr 45. If a bias voltage of VT (in V) is applied to a
dP forward-biased silicon p-n junction diode with E
E and loss in transmission line is 1 MW, the a non-ideality coefficient of 2, the diode A
A incremental cost of received power in current (in A) shall be
Rs./MWhr is L
L a. I0
a. 5.44
JbigDeaL JbigDeaL JbigDeaL JbigDeaL Download from www.JbigDeaL.in Powered By © JbigDeaL JbigDeaL JbigDeaL JbigDeaL JbigDeaL
JbigDeaL JbigDeaL JbigDeaL JbigDeaL
J
b. e 1 I0 c. 4
B
B
d. 5
I
c. eI 0 I
50. The sequential circuit shown in Fig. II.50 will
G
d. e 1 I 0 act as a G
D
D
46. Assuming the forward diode drop as 0V, the
E
output voltage V0, as shown in Fig. II.46, is E
A
A
L
L
J J
B B
I I
G a. Mod—1 counter G
D a. 0 V b. Mod—2 counter D
E b. 5 V c. Mod—3 counter E
L d. 6.5 V L
47. Two two-port networks are connected in
J cascade. The combination is to be represented J
B
as a single two-port network. The parameters B
of the network are obtained by multiplying the
I I
individual
G a. z-parameter matrix G
D b. h-parameter matrix D
E c. y-parameter matrix E
A d. ABCD-parameter matrix A
J
J
a. 2 V B
B
b. 6 V I
I
c. 10 V G
G
d. 20 V D
D
49. How many minimum number of NOR gates E
E are required to realize a two-input X-OR gate?
A
A a. 2
L
L b. 3
JbigDeaL JbigDeaL JbigDeaL JbigDeaL Download from www.JbigDeaL.in Powered By © JbigDeaL JbigDeaL JbigDeaL JbigDeaL JbigDeaL
JbigDeaL JbigDeaL JbigDeaL JbigDeaL
G a. sympathy
2. The World Wide Web was invented by G
D
b. reward
a. Tim Berners-Lee D
E
c. thankfulness
b. Narayanmurthy E
d. stimulation
A c. Sabeer Bhatia A
11. The appropriate missing word in the blank
L d. Charles Babbage L
space in the sentence “I prefer coffee _____
3. How many diagonals does a quadrilateral tea.” is
J J
have? a. than
B B
a. one b. over
I I
b. two c. for
G G
c. four d. to
D d. eight D
12. The appropriate missing word in the blank
E 4. ISO 14000 standards deal with space in the sentence “Many relatives attended E
b. production management a. of L
L
JbigDeaL JbigDeaL JbigDeaL JbigDeaL Download from www.JbigDeaL.in Powered By © JbigDeaL JbigDeaL JbigDeaL JbigDeaL JbigDeaL
JbigDeaL JbigDeaL JbigDeaL JbigDeaL
B B
I I
G G
D D
E E
A A
L L
J
J
B
B
I
I
G
G
D
D
E
E
A
A
L
L
J
J
B
B
I
I
G
G
D
D
E
E
A
A
L
L
JbigDeaL JbigDeaL JbigDeaL JbigDeaL Download from www.JbigDeaL.in Powered By © JbigDeaL JbigDeaL JbigDeaL JbigDeaL JbigDeaL