Sie sind auf Seite 1von 3

Utilize your fingers to push both battery discharge tabs from the battery, and lift the battery

out of
the PC.

Evacuate the three indistinguishable Phillips screws from the memory entryway.

Try to record which sets of screws originated from where. This will help when re-collecting.

Lift the memory entryway up enough to take a few to get back some composure on it, and slide it
toward you, pulling it far from the packaging.

Evacuate the two Phillips tightens the battery compartment close to the hook.

Evacuate the accompanying 6 screws:

Two 10 mm T6 Torx screws on either side of the RAM opening.

Four 14.5 mm Phillips screws along the pivot.

Evacuate the four Phillips screws on the port side of the PC.

Turn the PC 90 degrees and expel the two Phillips screws from the back of the PC.

Turn the PC 90 degrees again and expel the four Phillips screws from the side of the PC.

Try not to yank the capitalized off rapidly. The case is joined to the rationale board through a strip
link.

Lift up at the back of the case and work your fingers at the edges, liberating the case as you go.
When you have liberated the sides, you may need to shake the case here and there to free the front
of the capitalized. This stage can be very precarious. Over the DVD peruser are 4 tabs set back which
haul out vertically.

Note that the two little tongues on the left hand front of the capitalized may twist while you
evacuate the capitalized. At the point when re-introducing, you may need to twist them back to fit in
the furrows in the lower case.

Detach the trackpad and console strip link from the rationale board, evacuating tape as important.

Expel the capitalized.

Detach the orange hard drive strip link from the rationale board.

Utilize a spudger to painstakingly release the cement securing the rest light and IR sensor connectors
to the highest point of the hard drive.

emove the two silver Phillips screws securing the hard drive holding section to the lower case.

In a few machines these screws may have T6 Torx heads.

Slide the Bluetooth board out of its space beside the hard drive. The Bluetooth board is as yet
associated with the orange hard drive link, so don't endeavor to expel it from the PC.

Lift the hard drive up with one hand and utilize your other hand to expel the holding section from
the side of the hard drive.

isconnect the orange hard drive link.

In the wake of introducing the new hard drive, ensure the vent opening (to finish everything) isn't
secured by the orange lace link.
Expel the two silver T6 Torx screws and dark elastic guards from the correct side of the hard drive.

You'll have to exchange these screws and guards to your new hard drive in case you're evolving
drives.

Expel the two dark T6 Torx screws and dark elastic guards from the left half of the hard drive.

You'll have to exchange these screws and guards to your new hard drive in case you're evolving
drives.

In the event that you are introducing another hard drive, we have an OS X introduce manual for get
you up and running.

Das könnte Ihnen auch gefallen