Beruflich Dokumente
Kultur Dokumente
Selection parameters of the indoor units can be found under the chapter Indoor unit details
Selection parameters of the outdoor units can be found under the chapter Outdoor unit details
Only the data published in the data book are correct. This program uses close approximations of these data.
1. Material List
Model Qty Description
RXQ12TY1 1 Cooling only VRV IV STD(TY1)
RXQ8TY1 1 Cooling only VRV IV STD(TY1)
FXAQ40PVE 2 VRV AP - Wall Mounted(Flat Panel)
FXAQ50PVE 2 VRV AP - Wall Mounted(Flat Panel)
FXFQ63LUV1 4 VRV FLU - Ceiling Mounted Cassette(Round Flow)
KHRP26A22T 5 Refnet branch piping kit
KHRP26A33T 1 Refnet branch piping kit
KHRP26A72T 1 Refnet branch piping kit
BRC1E62 8 Remot Kontrol berkabel (Navigation Remot Kontrol)
BYCP125K-W1 4 Panel dekorasi
BHFP22P100 1 Unit outdoor pipa koneksi multi-kit
R410A 8.6kg Extra refrigerant charge
Piping 6.4 11.8m
Piping 9.5 33.2m
Piping 12.7 11.8m
Piping 15.9 48.1m
Piping 19.1 3.4m
Piping 22.2 9.7m
Piping 28.6 28.0m
Page 1
Rq SC Required sensible cooling capacity
Max SC Available sensible cooling capacity
Tevap Evaporating temperature of indoor unit coil
Tdis C Indoor unit discharge air temperature in cooling
Tmp H Indoor temperature in heating
Rq HC Required heating capacity
Max HC Available heating capacity
Tdis H Indoor unit discharge air temperature in heating
Airflow Supplied airflow
Sound Sound pressure low and high
PS Power supply (voltage and phases)
MCA Minimum Circuit Amps
WxHxD WidthxHeightxDepth
Wght Weight of the device
The calculation shows the peak discharge temperatures (lowest temperature in case of cooling mode / highest
temperature in case of heating mode), assuming the indoor unit is running at full load at the given indoor
temperature design conditions. In practice the discharge temperature will modulate based on actual capacity
requirements and during defrost mode (heating mode).
The analysis of the suction and discharge temperature values may help in preventing a cold draft and to ensure a
thermal comfort level.
Page 2
IU1-6 34-39 220V 1ph 0.4 1050×290×238 14
IU1-7 37-42 220V 1ph 0.5 1050×290×238 14
IU1-8 37-42 220V 1ph 0.5 1050×290×238 14
The Xpress Selection Program is property of Daikin Europe NV. Daikin Europe NV cannot be held liable for any inaccuracy, reliability of the outcome of the Xpress Selection
Program.
Page 3
3. Outdoor Unit Details
3.1. Table of Abbreviations
Name Logical name of the device
Model Device model name
Tmp C Outdoor temperature in cooling
CC Available cooling capacity
Rq CC Required cooling capacity
Tmp H Outdoor conditions in heating (dry bulb temp. / RH)
HC Available heating capacity (integrated heating capacity)
Rq HC Required heating capacity
Piping Largest distance from indoor unit to outdoor unit
Bse Refr Standard factory refrigerant charge (5m actual piping length)
excluding extra refrigerant charge
For calculation of extra refrigerant charge refer to the databook
Ex Refr Extra refrigerant charge
PS Power supply (voltage and phases)
MCA Minimum Circuit Amps
WxHxD WidthxHeightxDepth
Wght Weight of the device
The Xpress Selection Program is property of Daikin Europe NV. Daikin Europe NV cannot be held liable for any inaccuracy, reliability of the outcome of the Xpress Selection
Program.
Page 4
3.2. Outdoor Details
Name Model Comb Tmp C CC Rq CC Tmp H HC Rq HC
% °C BTU/h BTU/h °C BTU/h BTU/h
Out 1 RXQ20TNY1 86 32.0 150572 143645
Sufficient distance should be respected between the modules according to the service & operation space rules as
mentioned in the databook.
The Xpress Selection Program is property of Daikin Europe NV. Daikin Europe NV cannot be held liable for any inaccuracy, reliability of the outcome of the Xpress Selection
Program.
Page 5
4. Piping Diagrams
Pipes marked with * in the diagrams must be connected to the device with a reducing joint.
Q1
X
R
.0 m
8
2 ]
.9 2
5
1
t 1
u
O
Y RQ
T
2 X N
T
0
2
[6
×
.6
8
1 R
Y
HF
B
Q8
X
2 .7
1
1
Y
T
2 8
× .6
2 P
P
P 2
R
H
K
0
1
. 5
9
7 2
A
6
×1
.5
m [1
.7
2 ]
9 .1
1
×
T K
9
HR
.
9
6 A
2
P T
2
. 5
2 [1 ]
. 5
9
m
1 .9
×
HR
K 6 A
2
P T
2
×1
.5
9
m
.9
.9
5
2
P 2
R
H
K A2
6 T
4.1. Piping Out 1
.m
2 m [1
.0
2 ] . 0
2 [1 ]
m . 6
5 [1 ]
m
×1
.4
6 .7 IU
2 - 8 6
1 ×1
.4 .7 IU 1
2 -7 6
. 42 .7 IU
1
× - 6 6
1 ×1
.4 .7 IU
2 - 5
1
m [1
.7
9 ] . 7
0 mF Q5
A
X V E 3
P
0 m F
.0 Q5
A
X V E F
P
0 X A
0 P
4
Q E
V Q4
A
X
F V E
P
0
×2
.5
9 . K
P 2
R
H 3 3
A
6 T
. ×
9 5 .1
9
1 HR
K 6 A
2
P T 9
2 . 5
1 .9
× HR
K 6 A
2
P T
2
.3 5
9 [2 .9
m
0
1
× ] 3 1
×
.5
9 [ ]
m
.9
5 m1
6
3
×
.5
9 []
.9
5 .2 5
9 [ .9
m
0
1
× ]
- 4
1
IU - 3
1
IU IU 1
- - 2
1
IU
X Q
F F LU
3
6 1
V Q6
X
F LU V
3 1 Q6
X
F LU 1
3 V F X F
3 LU
6
Q 1
V
The Xpress Selection Program is property of Daikin Europe NV. Daikin Europe NV cannot be held liable for any inaccuracy, reliability of the outcome of the Xpress Selection
Program.
Page 6
5. Wiring Diagrams
P1P2 = Please select the cable type and size in accordance with the databook.
F1F2 = Please select the cable type and size in accordance with the databook.
Q1
2
,Q
Q1
t 1
u
O
RX
0 T
2
Q
RX
2 RX
,Q 8
Q
Y 1
N
2 T
1
Q 1
Y
T Y
IN F
1 L1 L2
, F
1 2
L1 ,L2 L3
2 4
,N
, L3
. A
6
1
3 p
A
,N
h
3 p
h
, 2
1
F
, 2
1
F
IU 1
F F
X 3
6
Q
IU 1
F X
6 3
Q
F
F X
, 2
1
F
, 2
1
F
6
Q
F
-4
LU V
IU 3
IU 1
F F
X 3
6
Q
-3 P
LU V
LU
1
- V
1
-2 P
LU V
IU 1
1
, 2
1
P
1 L,N 0
A1
.4
, 2 B
1
L,N 0
1 L,N 0
-8 P
, 2
1
P
C1
R
B
p h
A1
.4
L,N 0
, 2 B
1
A1
.4
, 2 B
1
p h
A1
.4
C1
R
6 2
E
C1
R
p h
C1
R
B
p h
6 2
E
C1
R
6 2
E
6 2
E
6 2
E
5.1. Wiring Out 1
F X
5 0
Q
A V E
P
, 2
1
F L,N 0 A1
.5 p h
, 2
1
P
F X
5
Q
AIU 0
V
P-7 E
1 C1
R
B 6 2
E
, 2
1
F L,N 0A1
.5 p h
IU 1-6 P , 2 B
1 C1
R 6 2
E
F X
4 0
Q
A V E
P
, 2
1
F L,N 0 A1
.4 p h
, 2 B
1
P C1
R 6 2
E
F X
4
Q
AIU 0
V
P-5 E
1
, 2
1
F L,N 0A1
.4 p h
The Xpress Selection Program is property of Daikin Europe NV. Daikin Europe NV cannot be held liable for any inaccuracy, reliability of the outcome of the Xpress Selection
Program.
Page 7
6. Device Options
6.1. Outdoor Unit Options
Model Description Used by
BHFP22P100 Unit outdoor pipa koneksi multi-kit Out 1 [RXQ20TNY1]
The Xpress Selection Program is property of Daikin Europe NV. Daikin Europe NV cannot be held liable for any inaccuracy, reliability of the outcome of the Xpress Selection
Program.
Page 8