Beruflich Dokumente
Kultur Dokumente
ENGLISH
INSTALLATION MANUAL
IMPORTANT
• Read this manual carefully before installing the
product
• The service of installation must be performed only
by authorized personnel and in accordance with
national wiring standards.
• After reading the entire manual, keep it for future
reference.
Operating instruction
INSTALLATION INSTRUCTION
- Always use a power circuit specifically dedicated to the door. For wiring follow
the manufacturer's instructions.
- Tighten the screws of the electrical terminals to prevent loosening.
- Make sure the power source has the required capacity.
- Make sure the thickness of the cable conforms to what is stated in the
specification of the power source.
- Never install a differential circuit breaker in wet or damp areas.
EQUIPMENT NEEDED
1 Flexometer 10 Level
2 Suitable lifting equipment (stairs, 11 Set of wrench (17 mm, 13 mm, 10
elevator, ecc.) mm, 8 mm)
3 Screwdriver set 12 Tester
Elevator Forklift
DoorHan CAN CHANGE THIS MANUAL AT ANY TIME AND WITHOUT NOTICE.
THE PICTURES IN THIS MANUAL COULD CHANGE COMPARATED TO SOME PARTS OF THE
DOOR.(this does not change its operation)
2 Installation manual
Operating instruction
n
MECHA
ANICAL AS
SSEMBLY
Y
1 2
Ph
hotocells cab
bles passing and transom
m fixing
4 6
5 7
WAR
RNING: INS
STALL CROS
SSED PHOT
TOCELL
installation manual 3
Operating
g instruction
WITH
H OTHER PHO
OTOCELLS NEA
AR THE DOOR CAN CAUSE REFLECTION
R PROBLEM
STR
RUCTURE LIFTING
L
FOR
R SIZE GREEATER THEN THOSE E LISTED LIFT THE COOLUMN AN ND THE TRRANSOM
INDIV
VIDUALLY (first
( lift the
e column then
t suppo
ort over the
e transom)
4 Insta
allation manua
al
Operating instruction
n
TR
RANSOM FIXING
A
10
LEVEL
L
A A
Control unit
YES
CUR
RTAIN INSE
ERTION
1
EVERSE
RE
CURTAIN TENSIO
ONING AND COLUM
MNS FIXING
11
Curtain
Guide
Plastic
Guide
Screws
MAX
X!
installation manual 5
Operating instruction
YES NO
SAND BAGS
YES NO
6 Installation manual
Operating instruction
Clean the window with a soft cloth and if necessary with water and
Window soap ( do not use any solvent that could damage the window) Six-month
installation manual 7
Operating instruction
INTERVENTION DESCRIPTION
PERIODICITY
POINT
- Verify the condition of the fixing frames, the correct
closure of the wall anchors and of the passing bars(if
Structure present) Six-month
- Control that there aren’t any structural deformations due to
crashes
- Verify the electrical connections in the control board and
verify that there is no water in.
- Control the electrical connections in the junction box and
control that there is no water in it
- Control the conditions and functioning of the safety
Electrical components Six-month
components (photocells, safety edge and emergency
button)
- Control the conditions and functioning of the opening
components (opening buttons and optional if present)
- Verify that all the electrical cables are in good condition.
- Verify the condition of the motor
- Control the condition of the motor brake
- Control the wear and tension of the drive chain of the
motor adapter.
- Control the condition of the reducer: oil leak, fixing to the
motor, fixing of the structure.
- Control the correct clamping of the bolts for any part of the
structure.
Mechanical
- Verify the axiality of the winder roller Six-month
components
- Control the condition and greasing of the bearings.
- Control the condition of the anti wear washers on the
columns
- Control the condition and regulation of the guides ( on the
dynamic doors)
8 Installation manual