INCUBATOR ORERATION INSTRUCTION
1.All the cable lines must be connectted with
residual current operated protective devices
before operate it and working voltage at220V.
2.Before incubation, you should check the
working conditions of all parts of incubator, and
be high proficiency in controller operation
3.Once the programme setted,do not adjust
it again except necessary.
4.Turnon the fan when the incubator power
on.the temperature probe should besetted in
the middle and low of inside of incubator,and the
humidity probe should be setted in themiddle
and up of inside of incubator.
5.During the incubation, you should check
all the parts of incubator working
conditions, Including temperature
heating, humidifiy and automatic egg turning
6, The water level in the tray must be higher
than heaters,and seal up completely the water
hole before use.
7.Once electricity power is off,must use
standby power, like generators, battaries.
8.This instruction is only for reference,
9.We hold no liability for damages caused
by long time electricity off and errors dueto
operation