Beruflich Dokumente
Kultur Dokumente
Abstract. Traffic related noise pollution accounts for nearly two-third of the total noise pollution in an
urban area. Noise, a by product of urbanization, industrialization and motorization, is increasingly recognized
as an environmental nuisance that effects human health and wellbeing. Traffic noise on existing urban road-
ways lowers the quality of life and property values for persons residing near these urban corridors
Surat is now the tenth largest city of India having an estimated population of 40 lakhs plus at present. An
inconceivable population growth rate of 76.02 % was observed in the last decade as a result of rapid
industrialization. Surat is well known as diamond city and is also famous for silk and jari industry. Owing to
its rapid industrialization and better job opportunities, observation is made for the migration from all over
India and particularly from Orissa, U.P., M.P., Bihar and Rajasthan.
Due to explosion of population and rapid industrialization the transportation in the city increased to un-
imaginary heights, but due to the want of efficient Mass Transit System, individual vehicular growth also
touched escalating heights. As on 31-12-2006, the vehicles registered at R.T.O. is 13 lakhs plus. This is
equivalent to the highest growth rate of Delhi. Thus the explosion of population, rapid industrialization and
highest growth rate in vehicle population made the traffic problems complicated.
This research paper highlights the noise pollution study carried out on three of the busiest urban corridors of
Surat city.
Keywords: Urban corridor, noise pollution, traffic noise
1. Introduction
Due to urbanization, there is a huge increase in the vehicular population on the urban corridors. In India,
transportation demand in urban areas continues to increase rapidly as a result of both population growth and
changes in travel patterns. During the first decade of the 21st century only, the urban areas in the country
confront a historic transportation crisis that has become a planning war against increasing mobility gridlock
and noise pollution. Due to absence of a good, convenient and efficient public transport system in urban
areas, there has been a need to develop the major corridors of the cities.
Traffic related noise pollution accounts for nearly two-third of the total noise pollution in an urban area.
Traffic noise on existing urban road-ways lowers the quality of life and property values for person residing in
vicinity of these urban corridors. Thus, the study of road traffic noise in big cities is an important issue. Due
to limited availability of land resources and finances, many highways and important roads are in the
residential and commercial areas. Hence there will be some adverse and environmental effects including
psychological and physiological effects to those living to proximity of these corridors.
The recognition of road traffic noise as one of the main sources of environmental pollution has led to
develop models that enable to predict noise level from fundamental variables. Traffic noise prediction
models are required as aids for urban corridors and highways. In addition, sometimes these models are used
in the assessment of existing or envisaged changes in traffic noise conditions.
So the present study was carried out to analyze the present state of noise pollution in three major
corridors of the Surat city and to develop a linear regression model to analyze the corridors and to suggest
proper measures to reduce the noise within permissible limits.
144
2. Studyy Area Profile
In Indiaa, geographical point of view Surat city is 260 km north off Mumbai ciity and 224 km k south off
Ahmedabadd city. On map m it is locatted at Latituude 210o 12' N, Longitudde 72o 52'E near bank of o river Tapi..
Surat is a ciity located onn the westernn part of Inddia in the statte of Gujaratt. It is one off the most dy
ynamic citiess
of India witth one of thee fastest grow
wth rate due to t immigratiion from variious parts off Gujarat and d other statess
of India.
Surat iss now the tennth largest citty of India haaving an estiimated popullation of 40 llakhs plus att present. Ann
inconceivabble populatioon growth rate r of 76.022 % was ob bserved in thhe last decaade as a ressult of rapidd
industrializaation. Surat is
i well know wn as diamonnd city and iss also famouus for silk andd jari industrry. Owing too
its rapid inddustrializatioon and betterr job opportuunities, obseervation is made
m for the migration frrom all overr
India and paarticularly frrom Orissa, U.P.,
U Bihar.
Due to explosion of o populationn and rapid industrializaation the traansportation in the city increased too
unimaginaryy heights buut due to the want of effiicient Mass Transit
T systeem, individuual vehicular growth alsoo
touched thee heights. AsA on 31-122-2006, the vehicles
v reggistered at R.T.O.
R is 133.00 lakhs plus.
p This iss
equivalent tot the higheest growth raate of Delhii (capital of India) Thuss the explosiion of population, rapidd
industrializaation and higghest growthh rate in vehiccle populatio
on made the traffic
t probleems compliccated.
Surat ciity is an outccome of the expansion
e off the city’s liimits at varioous intervals geared to acccommodatee
the additionnal populatioon and the inccreasing economic activiities. In the year y 1664, thhe city was liimited to thee
inner walledd city coveriing an area of o 1.78 sq. kmms. In 1707,, with the coonstruction off the outer wall,
w the areaa
of the city increased
i to 7.36 sq. kmss. For the neext almost 25 50 years the increase in tthe city area wasn’t veryy
a in 1963 the city covered an area of 8.18 sq. kms. In the same year 133.77 sq. kmss. was addedd
significant and
to the city area,
a increasiing its total area
a to 21.955 sq. kms. Fro om 112.27 sq. kms, the ppresent area of Surat cityy
is 326.515 sq.
s kms. Surat’s populatiion has grow wn drastically y. In the yearr 2001 the poopulation of the city wass
around 25 laakhs and at present
p it is 40
4 lakhs pluss. (As shown n in Fig-1)
F 1: Year wise
Fig. w populatio
on of Surat cityy
3. Vehiccular Growth of Su
urat city
The enoormous grow wth of the texxtile, diamonnd, and other Industries within
w the cityy, and setting
g up of largee
scale industtries in Hazirra and other industrial
i poockets aroun
nd the city haave resulted iin the increasse in trade &
commerce activities
a andd uplift of thhe socio-econnomic statuss of the peopple of Surat ccity. This is evident
e from
m
the exponenntial growth of vehicles; particularly the 2-wheelers and cars (fig 2). The composition n of vehicless
is shown in Fig 3.
145
Fig. 2: Growth of vehicles registered at Surat city
Total there are six corridors in Surat city. These corridors are (i) Kamrej-Varachha corridor (ii) Olpad-
Rander corridor (iii) Hazira-Adajan corridor (iv) Sachin-Udhna corridor (v) Kadodara-Sahara corridor (vi)
Dumas-Athwa corridor. These six corridors include diversified activities of business, residence,, commerce
and industries. A mix type of traffic has been observed on these corridors. Different type of land- use pattern
has been seen along these corridors. Due to these reasons, out of the six corridors, Athwa, Sahara and Udhna
corridors were selected for the study purpose.
146
Fig. 4: Map of Surat city showing major corridors
147
2
PCU, observed R value was found 0.77. This proves existence of direct relation between PCU and corridor
2
noise level. There is an inverse relationship between open space and noise level, with R value 0.60.
On the basis of the experimental values, the major parameters PCU, building height and open space were
regressed with noise level and regression model was built which is as follows.
6. References
[1] C. M. Harris, “Hand Book of noise control”, McGrawHill, USA, 1979.
[2] D. Banerjee, “Evaluation and analysis of road traffic noise in Asansol: an industrial town of eastern India”,
International Journal of Environmental Research and Public Health, 2008, 5(3) 165-171.
[3] EPA Report, “Information on levels of environment noise; requisite to protect public health and welfare with and
adequate margin of safety”, 1974.
[4] G. Cammarat, S.Cavalieri, “Noise prediction in urban traffic by a neural approach”, International Workshop on
Artificial Neural Networks, Sitges, Barcellona, Spain, 1993.
[5] Ghorbanali Mohammadi1, “An Investigation of Community Response to Urban Traffic Noise” Iranian Journal of
Environmental Health Science, 1998, 2 (4), 229-236.
[6] Golmohammadi, R., Abbaspour M., Nassiri P, Mahjub, “Road Traffic Noise Model”, Journal of Res Health
Science, 2007, 7(1), 13-17.
[7] Guoxia Ma, Yujun Tian, Tianzhen Ju and Zhengwu Ren, “Assessment of traffic noise pollution from 1989 to 2003
in lanzhou city”, Environmental Monitoring and Assessment, Springer, 2006.
[8] Pardia M, Jain S, Mittal N, “ Modeling of metropolitan traffic noise in Delhi” Institute of Town Planners (India)
Journal, 2003, 21(1), 5-12.
[9] R. S.Nirjar, “A study of transport related noise pollution in Delhi”, Institution of Engineers (India) Journal, 2002.
[10] S. P. Singal, “Noise Pollution and Control Strategy”, Alpha Science International, 2005.
[11] S. L. Nema, “Noise Pollution by Vehicles in Some Area of Bhopal City” Institution of Engineers (India) Journal,
1988.
[12] Y. H. Chan, “Biostatistics201: Linear Regression Analysis”, Singapore Med Journal, 2005, 45(2), 55.
148