Sie sind auf Seite 1von 4

DOC. NO.

: --
ISSUED ON: 13/10/09
AUTHORISEDSTATEMENT
BY: OF
DEPT:MANUFACTURING REQUIREMENTS(SOR) FOR PRE
TOOL
S.No. Description 1
1 Tool design/drawing is to be approved by us (before start work)
2 Tool drawings to be supplied to us(All Punch,die,holders,strippers,die set
etc.)
3 Tool shut Height-Max (mm)
4 Die Plate thickness+Base plate (Parallel Block)
5 Die set thickness (at Clamping area height)
6 Tool die Set Size-Max[L-RXF-B]
7 Tool clamping Slot width /Hole Dia
8 Tool Clamping slot /Hole Position
Front Left side From shank Centre
Rear right side from Centre
9 Shank size
10 Shank thread
11 All Stripper plates to have guide with pillar
12 Each stage to have separate stripper plate
13 Die set pillars with Brass bush(4 Pillar with Leader pin and Ball Bearing
cage assy all pillar must fixed with screws/grub screws)
14 Components ejection, preferrably without air
15 If components ejection by air, air nozzles is to be fixed in Tool itself.
(Quick coupling)
16 Components collection provision
17 Slug/Burr collection provision
18 Provide Scrap/Strip cutter
19 For springs, fasteners, pins, screws, dowels and bushings specification
can include type, size and preferred manufacturer.
20 All inserts retainers, strippers, and die blocks should be inserted using
wire EDM process it is good practice to stress-relieve all components after
machining, this will prevent cracking/splitting
21 All pneumatic connections should be of quick-coupling type
22 All progressive dies(Auto pressing) should have a designated strip start
point. This should be a mechanical type to help the operator during set up
and coil change time
23 Features for Quick die and punch insert replacement may be arranged

24 Minimum safety features[pin] to fix in the tool with misfeed limit switch.

25 Avoid sharp corners wherever possible especially in operator working


area
26 Name plate to be provided indicating the part No. of the Component and
stage of pressing
27 Name Plate to have details like,Tool number and type of material used-
Coil size(width&thick),shut height,Front mark and Weight.
28 Tool Manufacturer name/date supply to be marked in the tool
29 Punch,Die, Stripper's should be permanently marked/identified with
stage/position etc.
30 Raw material for proving the tool will be provided by us
31 On getting apporoval for samples, minimum lot specified by will be
produced and approved by our QA before acceptance of the tool.
32
33
PAGE 1 OF 1
N: 13/10/09
SEDSTATEMENT
BY: OF
REMENTS(SOR) FOR PRESS
TOOL
Remarks

Das könnte Ihnen auch gefallen