Beruflich Dokumente
Kultur Dokumente
LG2 has Excellent machining properties. Medium strength, good pressure toughness
DESCRIPTION
and is not subject to dezincification and has reasonable corrosion resistance to sea
water and brine, making it suitable for pump and valve components.
LG2 is suitable for bearings having light loads and low to medium speeds with
adequate lubrication and for very light duty gears when loading is negligible.
Sizes normally stocked in Australia. Some branches may not hold the entire range.
Other sizes available on request.
PB1 – Phosphorus Bronze
Cu Pb Sn Ni Zn Sb P Al
Typical Analysis
(Ave. values %) 88.0 0.25 11.0 0.10 0.05 0.20 1.00 0.005
PB1 has good machining properties, high strength and good corrosion resistance to
DESCRIPTION
sea water and brine, making it suitable for pump and valve components.
PB1 is suitable for heavy load gears, worm wheels and bearings having medium to
high loads and speeds with good resistance to impact loading or pounding. PB1 must
have good lubrication and alignment.
Round cast
SIZE 19.05 31.75 50.8 69.85 82.55 114.3 152.4
RANGE
25.4 38.1 57.15 76.2 101.6 127
Hollow Bar Cast
SIZE 50.8x25.4 76.2x25.4 101.6x38.1 127x50.8 152.4x76.2
RANGE
63.5x25.4 76.2x38.1 101.6x50.8 127x63.5
63.5x38.1 76.2x50.8 101.6x63.5 139.7x88.9
63.5x44.45 88.9x63.5 114.3x63.5 152.4x50.8
Sizes normally stocked in Australia. Some branches may not hold the entire range.
Other sizes available on request.
954 – Aluminium Bronze
Cu Fe Ni Mn Al
Typical Analysis
(Ave. values %) 83.0 4.0 1.5 0.50 11.0
DESCRIPTION 954 is very hard and abrasive resistant has excellent strength and wear resistance
with reasonable machining properties. These physical properties remain good at
elevated temperatures. General corrosion resistance is good, but under some
circumstances may suffer dealuminifation.
APPLICATIONS High strength bearings, Good impact resistance, Poor anti-seizure properties.
Sizes normally stocked in Australia. Some branches may not hold the entire range.
Other sizes available on request
Every care has been taken in listing this information, particularly specifications. Bohler Uddeholm Australia Pty Ltd will not accept
responsibility for any loss or other damage caused to any person or Company as a result of the use of information contained herein
Notes