Beruflich Dokumente
Kultur Dokumente
Tension Members
100 mm
60 mm
108 mm
60 mm T T 248 mm
160 mm
70 mm 70 mm
2 s s? 1
s s
2) Determine the maximum allowable tensile load that can be carried by tension member made
of an angle section L160x100x12mm connected at the end to gusset plate by two rows of
22mm diameter bolts as shown below. Fy 345MPa & Fu 485MPa .
100 mm
2
1
Ta ? 60 mm
50 mm 160 mm
1
2
50 50 50 50 mm
50
1
3) A tension member supporting a service design axial tension load of 210 kN. The member is
to be connected at the end to gusset plate by two rows of 22mm diameter bolts in a pattern
as shown below. The length of member is 1.9m. Assume the member as main tension member
with limiting slenderness ratio of l r 240 where r I A .
Fy 250MPa & Fu 400MPa .check if it is adequate.
T 210 kN
g
s s