Beruflich Dokumente
Kultur Dokumente
Electrical safety.
This product is intended for use when supplied with power from the designated battery
or power supply unit.Other usage may be dangerous and will invalidate any approval
given to this product.
to your device.This product is equipment with a USB cable and USB ICSP PIC
Programmer V2010 for connecting with desktop or notebook computer.Be sure your
appropriate outlet which is properly installed and grounded in accordance with all local
indicated on the electrical rating label.If you are not sure of the type
and burns if the battery pack is handled improperly.Do not attempt to open
product..
Li-ion
Dispose of used batteries carefully to ensure that a small child does not consume
batteries.
substances.
anything onto the screen.You may be injured or the product can be damaged.
Do not press OR touch on start botton with wet hands its can may be damaged
Do not press strongly upon the panel with a hand or sharp object such as
Avoid touching the screen or holding your finger (S) against it for long periods of
to screen.
When cleaning the product and its components,unplug the power first and wipe it
discolourations.Do not spray with water or wipe with a wet cloth.Never use glass
can damage the product and its panel.Otherwise,this may result in fire,electric
Do not place the product where it might be exposed to dust .this may cause a fire
hazard.
Make sure cable all in good condition to use and do not damage the cable.
Do not place a heavy object, or the product itself,on power cables.Otherwise, this
Do not drop metallic object such as coins,hair pins,chopstick or wire into the
dropped into the product,unplug the power card and contact the service centre.
MAINTENANCE
Clean your LCD Display to keep the best performance and to extend the product
lifespan.
CAUTION
Make sure to turn the power off and disconnect the power cord and all
When the LCD Display is left unattended and unused for a long time,
disconnect the power cord from the wall outlet to prevent possible from
To remove dust or light dirt,wipe the surface with a dry, clean and soft cloth.To
remove major dirt,wipe the surface with a soft cloth dampened in clean water or
diluted mild detergent.Then wipe immediately with a dry cloth.check the fuis
regularly.
CAUTION
Avoid touching the screen at all times,as this may resultin damage to the
screen.
Do not push,rub,or hit the screen surface with your fingernail or a sharp
Do not spray liquid onto the surface. If water enters the LCD Display,it
Battery
Keep batteries in safe place.and aslo clean the dusk on the battery.
CAUTION
Do not keep battery in water .if the water enters the battery, it may result
Do not charge battery a long time.it may result damage the Battery.
Troubleshooting instruction
PROBLEMS SOLUTION
another battery.
5.LED light doesn’t function 5.check main board if make problem again change
main board.
SERVICE LOCATIONS.
Lcddisplay2x16.blogspot.com
Contact us:04-4042975
WEEE notice
The Directive on waste Electrical and Electronic Equipment (WEEE),which entered into
force as European law on 13th February 2003,resulted in a major change in the
treatment of electrical equipment at end-of-life.
The purpose of this Directive is,as a first priority,the prevention of WEEE, and in
addition, to promote the reuse, recycling and other forms of recovery of such wastes so
as to reduce disposal.
The WEEE logo (shown at the left)on the product or on its box indicates that
this product must not be disposed of or dumped with your other household
waste.You are liable to
Dispose of all your electronic or electrical waste equipment by relocating
over to the specified collection point for recycling of such hazardous waste.Isolated
collection and proper recovery of your electronic and electrical waste equipment at the
time of disposal will allow us to help conserving natural resources.Moreover,proper
recycling of the electronic and electrical waste equipment will ensure safety of human
health and environment.For more information about electronic and electrical waste
equipment disposal, recovery,and collection points, please contact your local city
center,household waste disposal service ,shop,from where you purchased the
equipment,or manufacturer of the equipment.
LCD DISPLAY SPECIFICATIONS
Size : 151.7x73.8x8.5mm
Weight : 180 g
Display : 2x16(LCD)
Sound : buzzer
Battery : ordinary voltage(11.1v)
: Full- charge voltage(12.6)
: Capacity-2200mAh
: Dimension- 105mm x 33mm x 21mm
CABLE FOR UIC00B : This is a 10 ways rainbow cable with IDC socket.
: Compatible with UIC00B programmer rainbow cable.
: length: 20cm
USB ICSP PIC PROGRAMMER V2010 : Compatible with Windows XP,Vista and 7.
: Compatible with microchip’s PICkit 2.
: NO EXTERNAL POWER REQUIRED for
UIC00B to function
: This programmer comes with mini USB cable
And rainbow cable.
: Dimension : 7.5cm x 3 cm.
This limited warranty shall apply to the CYTRON product (the Product’).CYTRON
warrants that the product is at the time of original purchase free of defects in materials
and workmanship (‘’Limited Warranty’’).This LIMITED WARRANTY DOES NOT AFFECT
YOUR STATUTORY RIGHTS.
2. ) Unless otherwise agreed by the customer, this limited warranty shall last for twelve
(12) month from the date of original purchase for lcd devices, and twelve (12) month for
accessories (whether included in the lcd device sales package or sold separately) other
than the media on which any software is provided ,CD-ROM, memory card (‘’Warranty
Period’’).customers shall present the PROOF OF PURCHASE upon claiming this Limited
Warranty.This Limited warranty is only valid and enforceable in the countries where the
product is sold.Warranty service availability and response times may vary from country
and may also be subject to a registration requirement in the country of purchase.
3)Throughout the warranty period CYTRON or its authorized agent will, at their discretion,
without charge and subject to clause 7 repair or replace a defective product .Repair or
replacement may involve the use of functionally equivalent reconditioned unit . Cytron will
return the repaired product or replaced with another functional equivalent product to the
customer in good working condition .All replaced faulty parts or components will become
the property of CYTRON.