Beruflich Dokumente
Kultur Dokumente
Course-wide Content
Glossary
Multiple Choice Quiz
Sample PowerPoint (See related pages)
Message Board
Chapter 3
Quizzes
Results Reporter
Multiple Choice Quiz
More Resources Out of 34 questions, you answered 34 correctly, for a final grade of 100%.
PowerPoint Slides
34 correct (100%)
Flashcards
Selected Solutions 0 incorrect (0%)
Animations 0 unanswered (0%)
0 ungraded (0%)
Please answer all questions.
Your Results:
The correct answer for each question is indicated by a .
A)periodic signals
B)electromagnetic signals
C)aperiodic signals
D)low-frequency sine waves
2 CORRECT A periodic signal completes one cycle in 0.001 s. What is the frequency?
A)1 Hz
B)100 Hz
C)1 KHz
D)1 MHz
A)peak amplitude
B)frequency
C)phase
D)slope
A)signal amplitude
B)frequency
C)phase
D)time
5 CORRECT If the bandwidth of a signal is 5 KHz and the lowest frequency is 52 KHz, what is the highest frequency?
A)5 KHz
B)10 KHz
C)47 KHz
D)57 KHz
6 CORRECT What is the bandwidth of a signal that ranges from 1 MHz to 4 MHz?
A)4 MHz
B)1 KHz
C)3 MHz
D)none of the above
A)decreases
B)increases
C)remains the same
D)doubles
8 CORRECT Given two sine waves A and B, if the frequency of A is twice that of B, then the period of B is ________ that of A.
A)one-half
B)twice
C)the same as
D)indeterminate from
10 CORRECT If the maximum amplitude of a sine wave is 2 V, the minimum amplitude is ________ V.
A)2
B)1
C)-2
D)between -2 and 2
http://highered.mheducation.com/novella/MixQuizProcessingServlet 1/4
2/24/2018 Multiple Choice Quiz
11 CORRECT A signal is measured at two different points. The power is P1 at the first point and P2 at the second point. The dB is 0. This
means ________.
A)P2 is zero
B)P2 equals P1
C)P2 is much larger than P1
D)P2 is much smaller than P1
________ is a type of transmission impairment in which the signal loses strength due to the resistance of the transmission
12 CORRECT
medium.
A)Attenuation
B)Distortion
C)Noise
D)Decibel
________ is a type of transmission impairment in which the signal loses strength due to the different propagation speeds of
13 CORRECT
each frequency that makes up the signal.
A)Attenuation
B)Distortion
C)Noise
D)Decibel
14 CORRECT ________ is a type of transmission impairment in which an outside source such as crosstalk corrupts a signal.
A)Attenuation
B)Distortion
C)Noise
D)Decibel
15 CORRECT When propagation speed is multiplied by propagation time, we get the ________.
A)throughput
B)wavelength of the signal
C)distortion factor
D)distance a signal or bit has traveled
A)analog
B)digital
C)(a) or (b)
D)none of the above
A)analog
B)digital
C)(a) or (b)
D)none of the above
18 CORRECT _______ data have discrete states and take discrete values.
A)Analog
B)Digital
C)(a) or (b)
D)None of the above
A)analog
B)digital
C)either (a) or (b)
D)neither (a) nor (b)
A)Analog
B)Digital
C)(a) or (b)
D)None of the above
A)Analog
B)Digital
C)(a) or (b)
D)None of the above
A)Amplitude
B)Time
C)Frequency
D)Voltage
http://highered.mheducation.com/novella/MixQuizProcessingServlet 2/4
2/24/2018 Multiple Choice Quiz
A)Frequency
B)Phase
C)Amplitude
D)Voltage
25 CORRECT A sine wave in the ______ domain can be represented by one single spike in the _____ domain.
A)time; frequency
B)frequency; time
C)time; phase
D)phase; time
26 CORRECT A _________ sine wave is not useful in data communications; we need to send a _______ signal.
A)composite; single-frequency
B)single-frequency; composite
C)single-frequency; double-frequency
D)none of the above
27 CORRECT The _____ of a composite signal is the difference between the highest and the lowest frequencies contained in that signal.
A)frequency
B)period
C)bandwidth
D)amplitude
A)digital
B)analog
C)either (a) or (b)
D)neither (a) nor (b)
29 CORRECT Baseband transmission of a digital signal is possible only if we have a ____ channel.
A)low-pass
B)bandpass
C)low rate
D)high rate
30 CORRECT If the available channel is a ____ channel, we cannot send a digital signal directly to the channel.
A)low-pass
B)bandpass
C)low rate
D)high rate
31 CORRECT For a ______ channel, the Nyquist bit rate formula defines the theoretical maximum bit rate.
A)noisy
B)noiseless
C)bandpass
D)low-pass
32 CORRECT For a ______ channel, we need to use the Shannon capacity to find the maximum bit rate.
A)noisy
B)noiseless
C)bandpass
D)low-pass
A)Attenuation
B)Distortion
C)Noise
D)All of the above
34 CORRECT The _________ product defines the number of bits that can fill the link.
A)bandwidth-period
B)frequency-amplitude
C)bandwidth-delay
D)delay-amplitude
Routing Information
My Instructor: HTML
My TA: HTML
Other: HTML
http://highered.mheducation.com/novella/MixQuizProcessingServlet 3/4
2/24/2018 Multiple Choice Quiz
To learn more about the book this website supports, please visit its Information Center.
Copyright 2018 McGraw-Hill Global Education Holdings, LLC. All rights reserved.
Any use is subject to the Terms of Use and Privacy Center | Report Piracy
http://highered.mheducation.com/novella/MixQuizProcessingServlet 4/4