Beruflich Dokumente
Kultur Dokumente
* PM(Preventive maintenance)
2. Roll out
Different project is carried out either new installation or swapping.
Types of Tower:-
1. GBT(Ground base tower)….18m, 24m, 30m, 50m, 70m, 80m
2. RTT(Roof Top Tower)…..6m, 9m, 12m, 15m, 18m
3. Monopole tower….single leg tower
4. 3 leg tower
5. 4 leg tower
2. Electrical work
a. DG
b. Transformer
c. 3 phase line
d. Inverter
e. UPS
f. Battery bank
g. Solar installation
h. Rectifier
i. AC
3. Transmission work
a. Radio(MW,RRU,ODU)
b. Optical
c. GSM(2G/3G/4G)
d. BTS(BBU, IDU, ATN, Alarm card)
e. MUX
Types of BTS
a. Indoor /room BTS
b. Outdoor BTS
c. Shelter
GSM/RRU
a. 900 band(2G)
b. 1800 band(2G)/4G
c. 2100 band(2G)
MW(Microwave):
Mw is used for transferring signal from one location to
another(i.e one tower to another)
MW main part is Feed horn which is connected with
ODU directly or through help of waveguide
Power
a. Battery
Battery are connected in series to make -48v
DC
Positive terminal is grounded and negative
terminal is provided to MCB
To prevent the equipments from lightning strokes. Because the cloud is negatively charged at bottom it requires a zero
or a positive potential to discharge, and it selects the ground(Zero potential) to discharge. If the
Telecom Equipments are fed with positive the cloud will choose the low resistance tallest positively charged
Antenna's to discharge, this could damage the entire setup of Telecom equipments. So the Telecom equipments
are fed with Negative supply Voltage.