Beruflich Dokumente
Kultur Dokumente
FS
C- FS control board
- FS communication abnormality. A serial communication is
1002 (FSCB) Printer control
unavailable between the FS control board (FSCB) and the
board (PRCB)
printer control board (PRCB).
FS-510
C- FS control board
- Flash ROM abnormality. A checksum error of the flash ROM
1003 (FSCB)
is detected.
FS-511 Shift motor (M8) drive abnormality.
- When starting the home position movement, the shift home
Shift motor (M8) Shift
C- sensor (PS10) does not turn ON a specified period of time
home sensor (PS10) FS
1101 after M8 turns ON.
control board (FSCB)
- When starting the shift position movement, PS10 does not
turn OFF a specified period of time after M8 turns ON.
FS-511:Tray lift motor (M7) drive abnormality.
- While in the main tray up drive, the main tray upper limit
sensor (PS19) does not turn ON within a specified period of Tray lift motor (M7) Main
C- time after M7 turns ON. tray upper limit sensor
1102 - While in the main tray down drive, the lock signal of M7 is (PS19) FS control board
detected. (FSCB)
- While in the M7 ON, the main tray upper limit switch (SW2)
or the main tray lower limit switch (SW3) turns ON.
FS-511: Alignment motor (M5) drive abnormality.
- While in the alignment home position search, the alignment Alignment motor (M5)
C- home sensor (PS9) does not turn ON within a specified Alignment home sensor
1103 period of time after M5 turns ON. (PS9) FS control board
- While in the alignment operation, PS9 does not turn OFF (FSCB)
within a specified period of time after M5 turns ON.
FS-511: Paper exit roller release motor (M13) drive
abnormality.
Paper exit roller release
- When starting the pressure position drive, the exit roller
C- motor (M13) Exit roller
home sensor (PS13) does not turn ON within a specified
1104 home sensor (PS13) FS
period of time after M13 turns ON.
control board (FSCB)
- When starting the separation position drive, PS13 does not
turn OFF within a specified period of time after M13 turns ON.
C-
1110 SD: Saddle stapler motor /Rr drive abnormality
- When the saddle stapler motor /Rr turns ON, it
does not get off from the home position within a
specified period of time.
- After its getting off from the home position is
Saddle stapler motor /Rr SD control
detected, it does not get to the home position
board (SDCB)
within a specified
period of time.
- After the saddle stapler motor /Rr turns ON for
reverse rotation, it does not get to the home
position within a pecified period of time.