Beruflich Dokumente
Kultur Dokumente
Research enginner
San jose, Cebu City
2 March 2018
Mr. Wildonis C. Go
Research Engineer
CITE Technical Istitute, Ins
Mr. Go
As requested in your letter march 2, 2018, an investigation was made to determine the usesses of
cutting tools of electronics. Special recommendations were to be made regarding the direct applicatons
of the various pcb faprication. A report on this investigation is now completed.
The investigation was beun on December 24, 2017 in the laboratory of CITE Technical Institute, Inc and
the tests were done on march 3, 2018. The test definitely established that the correct types of tools
must be used on pcb fabrication if the satisfactory results are to be obtained. The timespend on the
investigation was devided equally between research and actual expirements.
LIBRADILLA JERIC L.
Research Engineer
ABSTRACT
An investigation of various types of cutting tools on electronics was requested pcb fabrication could be
made. Poorly designed pcb fabrications can cause a complete failure of these parts.
Test were made to determine the durability of the cutting tools expansion, contraction, and
compression. The problem were recorded so that the relative results could be seen. On the basis of the
test, recommended designs for pcb fabrication.
The body of the report is divided to include each test and the results; the recommendetions deal
specially with the use of the prescribed parts of the tools
INTRODUCTION
CITE Technical Institute, Inc in Cebu City. CITE Technical Institute, Inc will required numerous
and various cutting tools. This report covers tests that were conducted to determine the best
applications for the types of cutting tools that used in pcb fabrications. The efficiency of these parts
depends entirely on the pcb fabrications.
The tests indicates that the cutting tools should be in proper way, during the
expirements and it recoomended that the specific suggestions offered in the conclusion and
recommendation sections be followed.
CONTENTS
Letter of Transmittal…………………………………………………….
Abstract ……………………………………………………………………….
Introduction…………………………………………………………………
Cutting tools…………………………………………………………………
The use of tools in electronics………………………………………
Conclusions………………………………………………………………….
Recommendation ………………………………………………………