Beruflich Dokumente
Kultur Dokumente
ALL CAN BE ACCOMPLISHED WITHOUT THE NEED FOR REVERSE CIRCULATION EQUIPMENT OR LOADING YOUR WELL
WITH FLUID!
OPERATION
The Model DA Tubing Pump may be run on tubing or drill pipe. The tool's hexagonal Kelly transmits surface rotation of the pipe to
the lower end of the pipe whenever rotation or drilling is required. The Tubing Pump is designed to clean out sandfill, junk, or any
other loose debris from a well with fluid levels too low to permit using a Cavins Hydrostatic Tubing Bailer or Junk Snatcher. The
Tubing Pump is actuated by reciprocating the pipe. On the upstroke of the piston, fluid and debris is vigorously pulled from the well
into the lower end of the pipe and retained by the check valve. On the downstroke of the piston, fluid and debris within the pump
barrel is pumped upward through the full open passage in the Kelly into the tubing above the pump. Fluid reenters the annulus
through the screen sub or a ported sub located above the pump in the pipe. If circulation of a well is impossible due to sandfill
above the perfs, the screen or ported sub may be omitted to allow reverse circulation of the well through the Tubing Pump's full
open passages until the perfs are uncovered and fluid returns are lost. The double action design of the piston, the unobstructed
passage through the Kelly, and the fluid mixing port greatly reduce the probability of sand or other debris clogging the pump and
interfering with the pump's operation until all cleanout operations are completed.
MULTIPLE APPLICATIONS
By substituting a mill, bit, burning shoe, retrieving tool, etc. to the bottom of the work string, the Model DA Tubing Pump may be
utilized in various cleanout, drilling, and fishing applications.
<--Back