Sie sind auf Seite 1von 7

Basilica of Saint Peter, Vatican : Assembly Instructions

Before starting assembly :


Writing the number of each section on its back side before
Indicates where sections should be glued
cutting out the sections is highly recommended. together.
(* This way, you can be sure which section is which even
after cutting out the sections.)

Glue the rear sides of the upper


parts of 1 and 2.

View of completed model


* This model was designed for Papercraft and may differ from the original in some respects.

Assembly Instructions : Seven A4 sheets (No. 1 to No. 7)


* Build the model by carefully reading the Assembly Instructions , in the parts sheet page order.

*Hint: Trace along the folds with a ruler


and an exhausted pen (no ink) to get a sharper, easier fold.

Assembly Instructions
Glue
Mountain fold(dotted line)
The glue spot(colored dot)
Make a mountain fold.
shows where to apply the glue.
Valley fold(dashed and dotted line) Glue spot(Red dot)
Make a valley fold. Glue parts with the same number together. Make the curved windows
Scissors line(solid line) in Parts 6 and 8 face the
Glue spot(Green dot)
Cut along the line. front.
Glue within the same part.
Cut in line(solid line) Glue spot(Blue dot)
Cut along the line. Glue to the rear of the other part.

Scissors, set square, glue(We recommend stick glue), pencil, used


Tools and materials ballpoint pen, toothpicks, tweezers, (useful for handling small parts)

Before gluing, crease the paper along mountain fold and valley
Assembly tip fold lines and make sure rounded sections are nice and stiff.

Glue, scissors and other tools may be dangerous to young children


Caution so be sure to keep them out of the reach of young children.
Basilica of Saint Peter, Vatican : Assembly Instructions

See the illustration for the locations of the parts.


Glue the Parts 18 so that the windows
face outside and the doors face inside.

Door Window
Basilica of Saint Peter, Vatican : Assembly Instructions

Glue rear sides of the Parts 21 and 22.


For the Parts 23 to 27, fold the upper part,
glue the rear sides, and glue the part immediately
below the glued surface to the main body.
Basilica of Saint Peter, Vatican : Assembly Instructions

Glue the rear sides of the sculptures.


Basilica of Saint Peter, Vatican : Assembly Instructions

For Parts 40 and 44, fold the upper parts and glue
the rear sides, and for the Parts 38, 39, 42 and 43,
glue the rear sides and glue the part immediately
below the glued surface to the Part 41.

Assemble the other side in the same way.


Basilica of Saint Peter, Vatican : Assembly Instructions
Basilica of Saint Peter, Vatican : Assembly Instructions

After assembling the main body on the basement,


attach reinforcement parts in the sides and center
of the rear side of the basement.

Reinforcement parts

Finished!

Das könnte Ihnen auch gefallen