Beruflich Dokumente
Kultur Dokumente
STEP 1: To design a crankshaft, first the dimensions are taken from video source.
STEP 2: CREO Software is opened, a new part file is created and in settings the
default dimensions are set to millimeters.
STEP 3: Select sketch draw a circle on the front plane and extrude it.
STEP 6: Extrude cut is done partially on the top and bottom surface of the
counterweight.
STEP 7: Fillet is applied to the edge of the counterweights.
STEP 8: Fillet is applied to the corners of the main journals.
STEP 10: The crank is copied and rotated at an angle of 180 degree.
STEP 11: The crank is again copied and rotated at an angle of 180 degree.