1-Channel relay module, with photoelectric isolation
The module can be high or low by a jumper setting trigger With power and relay action indicator The module Operating voltage 5V The module uses genuine quality relay, normally open interfaces Maximum load: AC 250V/10A, DC 30V/10A Module interface: DC+: positive power supply (VCC)(5V) DC-: negative power supply (GND) IN: The control end, the driving current should be more than 4m ACOM: The control of loop of earth wire
5V 2 Channel Relay Module:
Module size : 50mm * 41mm * 18.5mm ( L * W * H )
Has four mounting bolts holes , hole 3.1mm, 44.5mm * 35.5mm pitch Interface : 1. DC +: positive power supply ( voltage required by the relay , there 5V.9V.12V and 24V choice ) 2. DC-: negative power connection 3. IN1: 1 channel signal to trigger the end , you can set a high or low level control relay 3. IN2: 2 -channel signal to trigger the end , you can set a high or low level control relay Outputs : 1. NO1: After a relay normally open interfaces , relay before floating, shorted pull with COM1 2. COM1: 1 relay common interface 3. NC1: 1 relay normally closed port, COM1 relay shorted before and after the pull- vacant 4. NO2: 2 -way normally open relay interface, the relay before floating , pull back and COM2 short 5. COM2: 2 Common Interface relay 6. NC2: 2 -way normally closed relay interface relay short front and COM2 , pull vacant post 9V 1 Channel Relay Module: